The URL can be used to link to this page

Browse Search

Home My WebLink About20161922.tiffCOLORADO Department of Public Health & Environment Dedicated to protecting and improving the health and environment of the people of Colorado Weld County - Clerk to the Board 1150 O St PO Box 758 Greeley, CO 80632 June 15, 2016 Dear Sir or Madam: On June 22, 2016, the Air Pollution Control Division will begin a 30 -day public notice period for Saddle Butte Rockies Storage Et Terminals LLC - Lucerne Crude Oil Terminal. A copy of this public notice and the public comment packet are enclosed. Thank you for assisting the Division by posting a copy of this public comment packet in your office. Public copies of these documents are required by Colorado Air Quality Control Commission regulations. The packet must be available for public inspection for a period of thirty (30) days from the beginning of the public notice period. Please send any comment regarding this public notice to the address below. Colorado Dept. of Public Health Et Environment APCD-SS-B1 4300 Cherry Creek Drive South Denver, Colorado 80246-1530 Attention: Clara Gonzales Regards, Clara Gonzales Public Notice Coordinator Stationary Sources Program Air Pollution Control Division Enclosure 4300 Cherry Creek Drive S., Denver, CO 80246-1530 P 303-692-2000 www.colorado.gov/cdphe John W. Hickentooper, Governor 4 -c 7 -d/ai40 Larry Wolk, MD, MSPH, Executive Director and Chief Medical Officer ee:PL,P&..)NL 6, —AD —4 , (. 2016-1922 Air Pollution Control Division Notice of a Proposed Project or Activity Warranting Public Comment Website Title: Saddle Butte Rockies Storage Et Terminals LLC - Lucerne Crude Oil Terminal - Weld County Notice Period Begins: June 22, 2016 Notice is hereby given that an application for a proposed project or activity has been submitted to the Colorado Air Pollution Control Division for the following source of air pollution: Applicant: Saddle Butte Rockies Storage Et Terminals LLC Facility: Lucerne Crude Oil Terminal Crude Oil Storage / Polishing Facility NWSW SEC 26 T6N R65W Weld County The proposed project or activity is as follows: Applicant proposes to construct a new crude oil terminal. The Division has determined that this permitting action is subject to public comment per Colorado Regulation No. 3, Part B, Section III.C due to the following reason(s): • permitted emissions exceed public notice threshold values in Regulation No. 3, Part B, Section III.C.1.a (25 tpy in a non -attainment area and/or 50 tpy in an attainment area) The Division has made a preliminary determination of approval of the application. A copy of the application, the Division's analysis, and a draft of Construction Permit 16WE0318 have been filed with the Weld County Clerk's office. A copy of the draft permit and the Division's analysis are available on the Division's website at https://www.colorado.gov/pacific/cdphe/air-permit-public-notices The Division hereby solicits submission of public comment from any interested person concerning the ability of the proposed project or activity to comply with the applicable standards and regulations of the Commission. The Division will receive and consider written public comments for thirty calendar days after the date of this Notice. Any such comment must be submitted in writing to the following addressee: Christopher Kester Colorado Department of Public Health and Environment 4300 Cherry Creek Drive South, APCD-SS-B1 Denver, Colorado 80246-1530 cdphe.commentsapcd@state.co.us 1 COLOR, 16WE0318 CDPHE Permit number: Date issued: Issued to: Construction Permit Air Pollution Control Division Facility Name: Plant AIRS ID: Physical Location: County: General Description: Issuance: 1 Saddle Butte Rockies Storage and Terminals, LLC Lucerne Crude Oil Terminal 123/9E5E NWSW SEC 26 T6N R65W Weld County Crude Oil Terminal Equipment or activity subject to this permit: Facility Equipment ID AIRS Point Equipment Description Emissions Control Description FUG 001 Fugitive component leak emissions None CRDTK-1 002 Eight (8) 30,000 barrel and two (2) 100,000 barrel internal floating roof crude oil storage vessels Internal Floating Roof CRDTK-2 003 Eight (8) 400 barrel fixed roof crude oil storage vessels. Enclosed Flare CRDTK-3 004 One (1) 30,000 barrel internal floating roof crude oil storage vessel. Internal Floating Roof and Enclosed Flare PWTNK 005 Two (2) 750 barrel fixed roof produced water storage vessels. Enclosed Flare This permit is granted subject to all rules and regulations of the Colorado Air Quality Control Commission and the Colorado Air Pollution Prevention and Control Act (C.R.S. 25-7-101 et seq), to the specific general terms and conditions included in this document and the following specific terms and conditions. REQUIREMENTS TO SELF -CERTIFY FOR FINAL AUTHORIZATION 1. YOU MUST notify the Air Pollution Control Division (the Division) no later than fifteen days of the latter of commencement of operation or issuance of this permit, by submitting a Notice of Page 1 of 11 u. o €:to; he kws. isirs' for th4equipment covered by this permit. The Notice of Startup onlin "re"' www.colorado.gov/pacific/cdphe/other-air-permitting- notices. Failure to notify the Division of startup of the permitted source is a violation of Air Quality Control Commission (AQCC) Regulation Number 3, Part B, Section III.G.1. and can result in the revocation of the permit. 2. Within one hundred and eighty days (180) of the latter of commencement of operation or issuance of this permit, compliance with the conditions contained in this, permit shall be demonstrated to the Division. It is the owner or operator's responsibility to self -certify compliance with the conditions. Failure to demonstrate compliance within 180 days may result in revocation of the permit. A self certification form and guidance on how to self -certify compliance as required by this permit may be obtained online at www.colorado.gov/pacific/cdphe/air-permit-self-certification. (Regulation Number 3, Part B, Section III.G.2.) 3. This permit shall expire if the owner or operator of the source for which this permit was issued: (i) does not commence construction/modification or operation of this source within 18 months after either, the date of issuance of this construction permit or the date on which such construction or activity was scheduled to commence as set forth in the permit application associated with this permit; (ii) discontinues construction for a period of eighteen months or more; (iii) does not complete construction within a reasonable time of the estimated completion date. The Division may grant extensions of the deadline. (Regulation Number 3, Part B, Section III.F.4.) 4. The operator shall complete all initial compliance testing and sampling as required in this permit and submit the results to the Division as part of the self -certification process. (Regulation Number 3, Part B, Section III.E.) 5. The operator shall retain the permit final authorization letter issued by the Division, after completion of self -certification, with the most current construction permit. This construction permit alone does not provide final authority for the operation of this source. EMISSION LIMITATIONS AND RECORDS 6. Emissions of air pollutants shall not exceed the following limitations. (Regulation Number 3, Part B, Section II.A.4.) Annual Limits: Facility Equipment ID AIRS Point Tons per Year Emission Type PM2.5 NO, VOC CO FUG 001 --- --- 25.1 --- Fugitive CRDTK-1 002 --- --- 17.0 --- Point CRDTK-2 003 --- --- 0.8 --- Point CRDTK-3 004 --- --- 0.5 --- Point PWTNK 005 --- --- 0.5 --- Point ote: See "Notes to Permit Holder" for information on emission factors and methods used to calculate limits. Facility -wide emissions of each individual hazardous air pollutant shall not exceed 8.0 tons per year. Facility -wide emissions of total hazardous air pollutants shall not exceed 20.0 tons per year. COLORADO Air Pollution Control Division Page 2 of 11 actit idg ermUionDlimitati for hazardous air pollutants shall apply to all permitted emissi'ort unitsat this facility. Compliance with the annual limits, for both criteria and hazardous air pollutants, shall be determined on a rolling twelve (12) month total. By the end of each month a new twelve month total is calculated based on the previous twelve months' data. The permit holder shall calculate actual emissions each month and keep a compliance record on site or at a local field office with site responsibility for Division review. 7. Point 001: The operator shall calculate actual emissions from this emissions point based on representative component counts for the facility with the most recent gas and liquids analyses. The operator shall maintain records of the results of component counts and sampling events used to calculate actual emissions and the dates that these counts and events were completed. These records shall be provided to the Division upon request. 8. The emission points in the table below shall be operated and maintained with the emissions control equipment as listed in order to reduce emissions to less than or equal to the limits established in this permit. (Regulation Number 3, Part B, Section III.E.) Facility Equipment ID MRS Point Control Device Pollutants Controlled CRDTK-1 002 Internal Floating Roof VOC and HAP CRDTK-2 003 Enclosed Flare VOC and HAP CRDTK-3 004 Internal Floating Roof and Enclosed Flare VOC and HAP PWTNK 005 Enclosed Flare VOC and HAP PROCESS LIMITATIONS AND RECORDS 9. This source shall be limited to the following maximum processing rates as listed below. Monthly records of the actual processing rates shall be maintained by the owner or operator and made available to the Division for inspection upon request. (Regulation Number 3, Part B, II.A.4.) Process Limits Facility Equipment ID AIRS Point Process Parameter Annual Limit CRDTK-1 002 Crude Oil Throughput 21,900,000 barrels CRDTK-2 003 Crude Oil Throughput 60,000 barrels CRDTK-3 004 Crude Oil Throughput 21,900,000 barrels PWTNK 005 Produced Water Throughput 2,190,000 barrels The owner or operator shall monitor monthly process rates based on the calendar month. Compliance with the annual throughput limits shall be determined on a rolling twelve (12) month total. By the end of each month a new twelve-month total is calculated based on the previous twelve months' data. The permit holder shall calculate throughput each month and keep a compliance record on site or at a local field office with site responsibility, for Division review. COLORADO n Control Ctvislcn Page 3 of 11 STA iTa' E' ''Y R U 6 O REQUI''_.MENTS 10. Points 002, 003, 004, and 005: The permit number and ten digit AIRS ID number assigned by the Division (e.g. 123/4567/001) shall be marked on the subject equipment for ease of identification. (Regulation Number 3, Part B, Section III.E.) (State only enforceable) 11. Points 003, 004, and 005: No owner or operator of a smokeless flare or other flare for the combustion of waste gases shall allow or cause emissions into the atmosphere of any air pollutant which is in excess of 30% opacity for a period or periods aggregating more than six minutes in any sixty consecutive minutes. (Regulation Number 1, Section II.A.5.) 12. This source is subject to the odor requirements of Regulation Number 2. (State only enforceable) 13. Point 001: Minor sources in designated nonattainment or attainment/maintenance areas that are otherwise not exempt pursuant to Section II.D. of Regulation No. 3, Part B, shall apply Reasonably Available Control Technology for the pollutants for which the area is nonattainment or attainment/maintenance (Reference: Regulation No. 3, Part B, III.D.2.a). The requirement to apply RACT shall be satisfied by installing/implementing the following emission controls: a. Directed Inspection is Maintenance as described below shall satisfy the requirement to apply RACT. i. Auditory/visual/olfactory inspection (AVO) will be performed on a semi- annual basis. ii. For each leak found in the AVO inspection, a gas detector may be used to determine the size of the leak. The gas detector shall be regularly calibrated. Component leaks greater than 10,000 ppm shall be managed in accordance with item (vi) below, unless it is unfeasible to make the repair without shutting down the affected operation of the facility. Component leaks less than 10,000 ppm shall not require repair. For such component leaks that require a shutdown to be repaired, repair shall occur during the first shutdown of the affected operation after the leak is discovered. iii. For repair, valves adjacent to the equipment to be repaired will be closed if practicable, minimizing the volume released. iv. Repaired components shall be re -screened using AVO to determine if the leak is repaired. v. The following records shall be maintained for a period of two years: • The name of the site screened via AVO inspection and the name of the inspector. • Components evaluated with the gas detector. • Repair methods applied. • Dates of the AVO inspections, gas detector calibrations, attempted repairs, successful repairs, repair delays, and post -repair screenings. vi. Leaks shall be repaired as soon as practicable, but no later than 15 calendar days after detection, unless it is technically or operationally infeasible to make the repair within 15 calendar days. Records documenting the rationale shall be maintained if it is technically or operationally infeasible to make the repair within 15 calendar days. 14. Point 001: The owner or operator shall follow the Directed Inspection and Maintenance (DIEM) program and record keeping format as approved by the Division, in order to demonstrate COLORADO Pollution Control Division Page 4 of 11 lid ce'?n a on ingrasis wi the requirements of this permit. Revisions to your DIEM Van a?'ionipro 15. Points 002, 003, 004, and 005: Minor sources in designated nonattainment or attainment/maintenance areas that are otherwise not exempt pursuant to Section II.D. of Regulation No. 3, Part B, shall apply Reasonably Available Control Technology for the pollutants for which the area is nonattainment or attainment/maintenance (Reference: Regulation No. 3, Part B, III.D.2.a). The requirement to apply RACT shall be satisfied by installing either an internal floating roof or closed vent system and enclosed combustion device on all crude oil and produced water storage tanks registered under these points. 16. Point 004: This storage tank is subject to the requirements of Regulation Number 7, Section IV. To demonstrate compliance with these requirements, the source shall comply with all applicable requirements for this tank under New Source Performance Standards, Standards of Performance for Volatile Organic Liquid Storage Vessels for which construction, reconstruction or modification commenced after July 23, 1984, Subpart Kb. 17. Points 002 and 004: These sources are subject to the applicable requirements of Regulation Number 7, Section VI.B.2. 18. Points 002 and 004: This source is subject to the New Source Performance Standards, Standards of Performance for Volatile Organic Liquid Storage Vessels for which construction, reconstruction or modification commenced after July 23, 1984, Subpart Kb. This facility shall comply with all applicable provisions of this regulation, as stated in 40 C.F.R Part 60, Subparts A and Kb. (Regulation Number 6, Part A, Subparts A and Kb) OPERATING 8: MAINTENANCE REQUIREMENTS 19. This source is not required to follow a Division -approved operating and maintenance plan. COMPLIANCE TESTING AND SAMPLING Initial Testing Requirements 20. Point 001: Within one hundred and eighty days (180) after commencement of operation, the operator shall complete a hard count of components at the source and establish the number of components that are operated in "heavy liquid service", "light liquid service", "water/oil service" and "gas service". The operator shall submit the results to the Division as part of the self -certification process to ensure compliance with emissions limits. Periodic Testing Requirements 21. This source is not required to conduct periodic testing, unless otherwise directed by the Division or other state or federal requirement. ADDITIONAL REQUIREMENTS 22. All previous versions of this permit are cancelled upon issuance of this permit. 23. A revised Air Pollutant Emission Notice (APEN) shall be filed: (Regulation Number 3, Part A, II.C.) • Annually by April 30th whenever a significant increase in emissions occurs as follows: For any criteria pollutant: For sources emitting less than 100 tons per year, a change in actual emissions of five (5) tons per year or more, above the level reported on the last APEN; or For volatile organic compounds (VOC) and nitrogen oxides sources (NO„) in ozone nonattainment areas emitting less than 100 tons of VOC or NO„ per year, a change in COLORADO Air Pollution Control Division Page 5 of 11 ions of e (1) ton per year or more or five percent, whichever is bo `='"" '" el r-` ed on the last APEN; or For sources emitting 100 tons per year or more, a change in actual emissions of five percent or 50 tons per year or more, whichever is less, above the level reported on the last APEN submitted; or For any non -criteria reportable pollutant: If the emissions increase by 50% or five (5) tons per year, whichever is less, above the level reported on the last APEN submitted to the Division. Whenever there is a change in the owner or operator of any facility, process, or activity; or • Whenever new control equipment is installed, or whenever a different type of control equipment replaces an existing type of control equipment; or • Whenever a permit limitation must be modified; or • No later than 30 days before the existing APEN expires. 24. Federal regulatory program requirements (Le. PSD, NANSR) shall apply to this source at any such time that this source becomes major solely by virtue of a relaxation in any permit condition. Any relaxation that increases the potential to emit above the applicable Federal program threshold will require a full review of the source as though construction had not yet commenced on the source. The source shall not exceed the Federal program threshold until a permit is granted. (Regulation Number 3, Parts C and D). GENERAL TERMS AND CONDITIONS 25. This permit and any attachments must be retained and made available for inspection upon request. The permit may be reissued to a new owner by the APCD as provided in AQCC Regulation Number 3, Part B, Section II.B. upon a request for transfer of ownership and the submittal of a revised APEN and the required fee. 26. If this permit specifically states that final authorization has been granted, then the remainder of this condition is not applicable. Otherwise, the issuance of this construction permit does not provide "final" authority for this activity or operation of this source. Final authorization of the permit must be secured from the APCD in writing in accordance with the provisions of 25-7- 114.5(12)(a) C.R.S. and AQCC Regulation Number 3, Part B, Section III.G. Final authorization cannot be granted until the operation or activity commences and has been verified by the APCD as conforming in all respects with the conditions of the permit. Once self -certification of all points has been reviewed and approved by the Division, it will provide written documentation of such final authorization. Details for obtaining final authorization to operate are located in the Requirements to Self -Certify for Final Authorization section of this permit. 27. This permit is issued in reliance upon the accuracy and completeness of information supplied by the owner or operator and is conditioned upon conduct of the activity, or construction, installation and operation of the source, in accordance with this information and with representations made by the owner or operator or owner or operator's agents. It is valid only for the equipment and operations or activity specifically identified on the permit. 28. Unless specifically stated otherwise, the general and specific conditions contained in this permit have been determined by the APCD to be necessary to assure compliance with the provisions of Section 25-7-114.5(7)(a), C.R.S. 29. Each and every condition of this permit is a material part hereof and is not severable. Any challenge to or appeal of a condition hereof shall constitute a rejection of the entire permit and upon such occurrence, this permit shall be deemed denied ab initio. This permit may be revoked at any time prior to self -certification and final authorization by the Air Pollution Control Division (APCD) on grounds set forth in the Colorado Air Quality Control Act and COLORADO Air Pollution Control Division Page 6 of 11 reg�latns if the Air ualy Contr.;(Commission (AQCC), including failure to meet any express term diton fe of e"'5*mit. ' the Division denies a permit, conditions imposed upon a permit are contested by the owner or operator, or the Division revokes a permit, the owner or operator of a source may request a hearing before the AQCC for review of the Division's action. 30. Section 25-7-114.7(2)(a), C.R.S. requires that all sources required to file an Air Pollution Emission Notice (APEN) must pay an annual fee to cover the costs of inspections and administration. If a source or activity is to be discontinued, the owner must notify the Division in writing requesting a cancellation of the permit. Upon notification, annual fee billing will terminate. 31. Violation of the terms of a permit or of the provisions of the Colorado Air Pollution Prevention and Control Act or the regulations of the AQCC may result in administrative, civil or criminal enforcement actions under Sections 25-7-115 (enforcement), -121 (injunctions), -122 (civil penalties), -122.1 (criminal penalties), C.R.S. By: Christopher Kester Permit Engineer Permit Histo Issuance Date Description Issuance 1 This Issuance Issued to Saddle Butte Rockies Storage and Terminals, LLC COLORADO Ain Pollution Control Division Page 7 of 11 No it issuance: 1) The permit holder is required to pay fees for the processing time for this permit. An invoice for these fees win be issued after the permit is issued. The permit holder shall pay the invoice within 30 days of receipt of the invoice. Failure to pay the invoice will result in revocation of this permit. (Regulation Number 3, Part A, Section VI.B.) 2) The production or raw material processing limits and emission limits contained in this permit are based on the consumption rates requested in the permit application. These limits may be revised upon request of the owner or operator providing there is no exceedance of any specific emission control regulation or any ambient air quality standard. A revised air pollution emission notice (APEN) and complete application form must be submitted with a request for a permit revision. 3) This source is subject to the Common Provisions Regulation Part II, Subpart E, Affirmative Defense Provision for Excess Emissions During Malfunctions. The owner or operator shall notify the Division of any malfunction condition which causes a violation of any emission limit or limits stated in this permit as soon as possible, but no later than noon of the next working day, followed by written notice to the Division addressing all of the criteria set forth in Part II.E.1 of the Common Provisions Regulation. See: https://www.colorado.gov/pacific/cdphe/aqcc-regs 4) The following emissions of non -criteria reportable air pollutants are estimated based upon the process limits as indicated in this permit. This information is listed to inform the operator of the Division's analysis of the specific compounds emitted if the source(s) operate at the permitted limitations. AIRS Point Pollutant CAS # Uncontrolled Emissions (Ib/yr) Controlled Emissions (Ib/yr) 001 Benzene 71432 301 301 Toluene 108883 501 501 Ethylbenzene 100414 201 201 Xylenes 1330207 702 702 n -Hexane 110543 201 201 002 Benzene 71432 203 203 Toluene 108883 339 339 Xylenes 1330207 136 136 Ethylbenzene 100414 474 474 n -Hexane 110543 136 136 003 Benzene 71432 182 9 Toluene 108883 303 15 Ethylbenzene 100414 121 6 Xylenes 1330207 424 21 n -Hexane 110543 121 6 004 Benzene 71432 100 5 . Toluene 108883 166 8 Ethylbenzene 100414 66 3 COLORADO Air Pollution Control Division Page 8 of 11 xyLapes Ji S3,0207 233 12 n -Hexane 110543 66 3 005 Benzene 71432 14 1 Toluene 108883 84 4 Ethylbenzene 100414 4 < 1 Xylenes 1330207 66 3 n -Hexane 110543 1258 63 Note: All non -criteria reportable pollutants in the table above with uncontrolled emission rates above 250 pounds per year (lb/yr) are reportable and may result in annual emission fees based on the most recent Air Pollution Emission Notice. 5) The emission levels contained in this permit are based on the following emission factors: Point 001: Component Gas Heavy Oil Light Oil Water/Oil Connectors 0 0 542 0 Flanges 0 0 1422 0 Open-ended Lines 0 0 2 0 Pump Seals 0 0 7 0 Valves 0 0 431 0 Other 0 0 154 0 VOC Content (wt. fraction) 0 0 1 0 Benzene Content (wt. fraction) 0 0 0.006 0 Toluene Content (wt. fraction) 0 0 0.01 0 Ethylbenzene (wt. fraction) 0 0 0.004 0 Xylenes Content (wt. fraction) 0 0 0.014 0 n -hexane Content (wt. fraction) 0 0 0.004 0 `Other equipment type includes compressors, pressure relief valves, relief valves, diaphragms, drains, dump arms, hatches, instrument meters, polish rods and vents TOC Emission Factors (kg/hr-component): Component Gas Service Heavy Oil Light Oil Water/Oil Service Connectors 2.0E-04 7.5E-06 2.1E-04 1.1E-04 Flanges 3.9E-04 3.9E-07 1.1E-04 2.9E-06 Open-ended Lines 2.0E-03 1.4E-04 1.4E-03 2.5E-04 Pump Seals 2.4E-03 NA 1.3E-02 2.4E-05 Valves 4.5E-03 8.4E-06 2.5E-03 9.8E-05 Other 8.8E-03 3.2E-05 7.5E-03 1.4E-02 COLORADO Air Pollution Control Civision Page 9 of 11 Table 2-4 Compliance with emissions limits in this permit will be demonstrated by using the TOC emission factors listed in the table above with representative component counts, multiplied by the VOC content from the most recent gas and liquids analyses. Point 002: CAS # Pollutant Uncontrolled Emission Factors lb/bbl Controlled Emission Factors lb/bbl Source VOC 0.001549 0.001549 EPA Tanks - Working and Breathing Emissions only 71432 Benzene 0.0000093 0.000009 108883 Toluene 0.0000155 0.000015 100414 Ethylbenzene 0.0000062 0.000006 1330207 Xylene 0.0000217 0.000022 110543 n -Hexane 0.0000062 0.000006 Note: The uncontrolled and controlled emissions factors for this point are based on the use of an internal floating roof tank in the EPA Tanks simulation. Point 003: CAS # Pollutant Uncontrolled Emission Factors lb/bbl Controlled Emission Factors lb/bbl Source VOC 0.50449 0.02522 EPA Tanks - Working and Breathing Emissions only 71432 Benzene 0.00303 0.00015 108883 Toluene 0.00504 0.00025 100414 Ethylbenzene 0.00202 0.00010 1330207 Xylene 0.00706 0.00035 110543 n -Hexane 0.00202 0.00010 Note: The uncontrolled and controlled emissions factors for this point are based on a fixed roof tank in the EPA Tanks simulation and a flare control efficiency of 95%. Point 004: CAS # Pollutant Uncontrolled Emission Factors lb/bbl Controlled Emission Factors lb/bbl Source VOC 0.00075886 0.00003794 EPA Tanks - Working and Breathing Emissions only 71432 Benzene 0.00000455 0.00000023 108883 Toluene 0.00000759 0.00000038 100414 Ethylbenzene 0.00000304 0.00000015 1330207 Xylene 0.00001062 0.00000053 110543 n -Hexane 0.00000304 0.00000015 Note: The uncontrolled and controlled emissions factors for th's point are based on the use of an internal floating roof tank in the EPA Tanks simulation and a flare control efficiency of 95%. COLORADO Dilution Control Division Page 10 of 11 "' CAS # ""' Pollutant Ffncontrolled Emission Factors lb/bbl Controlled Emission Factors lb/bbl Source VOC 0.007910 0.000395 Promax Flashing, Working and Breathing Emissions with pressurized water sample as input 71432 Benzene 0.000007 0.0000003 108883 Toluene 0.000038 0.0000019 100414 Ethylbenzene 0.000002 0.0000001 1330207 Xylene 0.000030 0.0000015 110543 n -Hexane 0.000574 0.0000287 6) In accordance with C.R.S. 25-7-114.1, each Air Pollutant Emission Notice (APEN) associated with this permit is valid for a term of five years from the date it was received by the Division. A revised APEN shall be submitted no later than 30 days before the five-year term expires. Please refer to the most recent annual fee invoice to determine the APEN expiration date for each emissions point associated with this permit. For any questions regarding a specific expiration date call the Division at (303)-692-3150. 7) This permit fulfills the requirement to hold a valid permit reflecting the storage tank and associated control device per the Colorado Oil and Gas Conservation Commission rule 805b(2)(A) when applicable. 8) This facility is classified as follows: Applicable Requirement Status Operating Permit True Minor NANSR True Minor 9) Full text of the Title 40, Protection of Environment Electronic Code of Federal Regulations can be found at the website listed below: http://ecfr.gpoaccess.gov/ Part 60: Standards of Performance for New Stationary Sources NSPS 60.1 -End Subpart A - Subpart KKKK NSPS Part 60, Appendixes Appendix A - Appendix I Part 63: National Emission Standards for Hazardous Air Pollutants for Source Categories MACT 63.1-63.599 Subpart A - Subpart Z MACT 63.600-63.1199 Subpart AA - Subpart DDD MACT 63.1200-63.1439 Subpart EEE - Subpart PPP MACT 63.1440-63.6175 Subpart QQQ - Subpart YYYY MACT 63.6580-63.8830 Subpart ZZZZ - Subpart MMMMM MACT 63.8980 -End Subpart NNNNN - Subpart XXXXXX COLORADO Air Pclluncn cantrcl c;v,slon Page 11 of 11 Colorado Air Permitting Project Version No. 1.00 Project Details Review Engineer: Package k: Received Date: Review Start Date: Section 01- Facility Information Christopher Kester 342967 1/14/2016 5/24/2016 Company Name: County AIRS ID: Plant AIRS ID: Facility Name: Physical Address/Location: Type of Facility: What industry segment? Is this facility located in a NAAQS non -attainment area? If yes, for what pollutant? ❑carbon Monoxide (co) Saddle Butte Rockies Storage & Terminals, LLC 123 9E5E Lucerne Crude Oil Terminal NWSW SEC 26 T6N R65W Oil Storage and Pipeline Injection Natural Gas Transmission & Storage Section 02 - Emissions Units In Permit Application Yes ❑Particulate Matter (PM) Ozone (NOx & VOC) AIRs Point S4 Emissions Source Type Emissions Control? Permit #s Issuance a Self Cert Required? Action Engineering Remarks 001 Fugitive Component Leaks No 16WE0318 1 Yes Permit Initial Issuance Newly permitted point 002 Crude Oil Storage Tank No 16WE0318 1 Yes Permit Initial Issuance Newly permitted point 003 Crude Oil Storage Tank No 16WE0318 1 Yes Permit Initial Issuance Newly permitted point 004 Crude Oil Storage Tank No 16WE0318 1 Yes Permit Initial Issuance Newly permitted point 005 Produced Water Storage Tank No 16WE0318 1 Yes Permit Initial Issuance Newly permitted point 006 Boiler or Process Heater No 16WE0651.XP 1 No APEN Required / Permit Exempt XP Heaters < 10 MMBtu/hr Section 03 - Description of Project Permitting several new sources at a new synthetic minor crude oil storage terminal. Section 04 - Public Comment Requirments Is Public Comment Required? Yes If yes, why?1 Greater than 25 tons per year in Non -Attainment Area Section 05 - Ambient Air Impact Analysis Requirements Was a quantitative modeling analysis required?2 No If yes, for what pollutants? If yes, attach a copy of Technical Services Unit modeling results summary. Section 06 - Facility -Wide Stationary Source Classification Is this stationary source a true minor? Is this stationary source a synthetic minor? Yes No Colorado Air Permitting Project Version No. 1.00 If yes, explain what programs and which pollutants here:.. Is this stationary source a major source? If yes, explain what programs and which pollutants here: 001 Fugitive equipment leaks Regulation 7 Information Operating Hours. 8760 hours/year Emission Factor Source Standard EFs - EPA -453,R95-017 Table 2-4 Control Efficiency Source'. None "'The mass fractions for VOC and HAPs in tee light oil stream were derived from the speciation profile for crude oil from EPA -ANN 4 0 9d Service Component Type Count Emission Factor (belle- source) Table 2-4 Table 2-S Control (%) Pollutant Mass Fraction Emissions tiny( Reg. 3 Gas Connectors Flanges Open -Ended Lines Pump Seals Valves other 0 0 0 0 0 0 200E-04 390E-04 2 00E-03 2.40E 03 450E-03 880E-03 100E 05 5 70E 06 1 50E- 05 350E-04 250E05 120E-04 0?% 00% 00% 00% 0.0% 0.0% VOC Benzene Toluene Eth9benzenn Xylenes n -Hexane 0 0 0 0 0 0 0 0 0 0 0 0 Heavy Oil Connectors Flanges Open -Ended Lines Pump Seals Valves Otbe- 0 0 0 0 0 0 750E-06 390E-0] 1400-04 0001.00 8.40E06 3.20E-05 750E-06 390E-07 7.20E-06 000E+00 840E-06 3.20E 05 0.0% 00% 00% 00% 0.0% 00% VOC Benzene Toluene Ethylbenzene Xylenes n -Hexane 0 0 0 0 0 0 0 0 0 0 0 0 Light Oil Connectors Flanges Open -Ended Lines Pump Seals Valves Other 542 1422 2 7 431 154 210E04 1101-04 14 0E-03 130E-02 750E-03 7.50E-03 5.20E-06 2.40E-06 14005 E 5.10E04 1.90E-05 110E 04 00% 0.0% 0.0% 00% 00% 00% VOC Benzene Toluene Emylbenzene Xylenes n -Hexane 1 0006 001 0004 0.014 0004 25072575 01504354 02507257 0.1002903 0351016 0.1002903 walenon Connectors Flanges Open -Ended Lines Puma seals Valves other 0 0 0 0 0 0 1.10E-04 2.90E06 250E-04 240E-05 980E-05 140E-02 1.00E-05 290E-06 3 50E-06 240E-05 9.70E-00 590E-05 00% 0.0% 00% 00% 0.0% 0.0% VOC Benzene Toluene Ethrbenzene Xylenes n -Hexane 0 0 0 0 0 0 0 0 0 0 0 0 Table Pollutant Uncontrolled Emissions Controlled Emissions Source VOC 25.07 tpy 2507 tpy standard EF Benzene 300 87 Ib/yr 300.87 IbNr Standard EF Toluene 501 45 lb/yr 50145 lb/yr Standard EF Elnylbenzene 200.58 lb/yr 20058 Iblyr Standard EF Xylenes 702.03 lb/yr 70203 lb/yr Standard EF n -Hexane 200.58 lb/yr 200.58 10/yr Standard EF Regulatory Applicability Reg 3 Reg.e Reg. 7 - EPA -453/R-95-017 Table 2-4 - EPA -453/R-95-017 Table 2 4 - EPA -453/R-95-017 Table 2-4 - EPA -453/R-95-017 Table 2-4 - EPA4531R-95-017 Table 2-4 - EPA -453/R-95-017 Table 2-4 Review Regulation 3, Part B, Section III o2 to determine is RACT is required, Yes Review 40 CFR, Part 60. Subpart KKK to determine if applicable to this source? No Review 40 CFR, Part 60. Subpart 0000 to determine if 60.5380 and/or 60.5385'5 applicable? Review Section IS/ILF to determine is LOAR is applicable, No No Crude Oil Storage Tank(s) Emissions Inventory Section 01- Admm54athe Information Facility AIRS ID: 123 9ESE 002 County Plant Point Section 02 - Equipment Description Details Detailed Emissions Unit Eight (3)30:000 bbl and two (2)100,000 bbl internal floating roof osdeot skate tanks Description: Emission Control Device I ternal floating Root Description Requested Overall VOC & HAP Control Efficiency%: Section 03- Processing Rate Information for Emissions Estimates Primary Emissions - Storage Tank(s) Actual Throughput= Requested Permit Limit Throughput= 21,900,000 Barrels lhblj per year 21,900,000 Barrels (hull per year Potential to Emit (PTE) Throughput= ..21,900,000 Barrels (bbl) per year Secondary Emissions- Combustion Deekefs) Heat content of waste gas- NA Btu/scf Volume of waste gas emitted per BBL of liquids produced - NA scf/bbl Actual beat content of waste gas routed to combustion desire = Request heat content of waste gas routed to combustion device = OVALUE! NVALUE, Actual Crude Oil Throughput While Emissions Controls Operating= 21,900,000 MMBTU per year MMOTU per year Potential to Emit lPTEl heat content of waste gas routed to combustion device= OVAEUF I MMBN per year Section 04 - Emissions Factors & Methodologies Will this storage tank emit flash emissions? Pollutant Crude Oil Storage Tanks Uncontrolled E.F. (Ibs/bbl Crude Oil Throughput) Controlled E.F. (lbs/bbl Crude Oil Throughput) Control Device Uncontrolled El. (Ibs/MMBtu waste heat corn Isusted) PM2.5 ""\,�"�W1OLXXVOI"`,._¢m'3- Ma 0.003549 0 001549 `si""„"Nil( 0000L 93.. 0000009 'N"XXX", ry 0.000015 .X-XX. IL""m v. 0000006 VII6XXX VIOPIOAN & ar 0.0000212... 0.000022 Nb.III:VVVI .\\\\ - ... .00000062 0.000006 V""\A"" 000000000 Illi""V,tt`u.m`.z.w Section OS - Emissions Inventory VOC 1 Benzene 0 006 Toluene 001 Ethylbenzene 0 004 Xylenes 0.014 n -Hexane 0.001 ^•The mass fractions for vac a d HAPs in the were derived from the speciabon profile for crude oil from EPA TANK 4.0.9d Emissions Factor Source Citation Criteria Pollutants Potential to Emit Uncontrolled (tons/year) Requested Permit imits Uncontrolled Controlled (tons/year) (tons/year) Actual Emissions Uncontrolled Controlled (tons/year) Icons/yearl PM10 PM2.5 NDg VOC CO ill 16,96 16,96 16,96 16.56 16.96 Hazardous Air Pollutants Potential to Emit Uncontrolled (tons/year) Requested Permit Limits Uncontrolled Controlled Items/year) (tons/year) Actual Emissions Uncontrolled Controlled Itono/yeah Oona/year) Benzene Toluene rthylenzene Xylene n -Hexane 224 TMP 0.10 010 0.10 010 0,10 0.17 0.17 0.12 0.17 0.17 0.07 0.07 0.07 0.07 0.07 0.24 0.24 0.24 0.24 0.24 0.07 0.07 0.07 0.07 0.07 0,00 5,00 0.00 0.00 a00 Section 96- Regulatory Summary AnaAAs Regulation 3, Parts AB Regulation 7, Section rill, B, C,l, C.3 Regulation 7, Sertlon XVII.C.2 Regulation 6, Part A, NSPS Subpart Kb Regulation 6, Part A, NSPS Subpart 0000 Regulation 9, Part E. MAC' Subpart HH (See regulatory applicability worksheet foe detailed analysis) Source requires a permit Storage Tank is not subject to Regulation 7, Section %VII Storage Tank is not subject to Regulation 7, Section %VILG2 Storage tank is subiert to NSPS Kb, including but not limited to, the following Storage Tank is not subject to NSPS 0000 Storage Tank Is not subject to MAR NH Section 97- Ink al and Periodic Sampling and Testing Requirements Does the company use the state default emissions factors to estimate emissions? mv.� tWu if yes, the theper itwill contain actual orrequestedCompliance" emissions estimated eg requirement m negreater lthan irequal to eotons VOC per year? If yes. the permit will mnbin an "Initial Comphance'tesling repunemenRo develop a site specific emissions !actor hazed on guidelines in PS Memo 1403 4 of19 K:\PA\2016\ 16WE0310-CP1 olsm Crude Oil Storage Tank(s) Emissions Inventory Does the company use a she specific emisians factor to estit te emrssionsa Yes."--"""" If yes end if D ere are flash emissions are the emissions factors hazed on a pressur zed liqu a sample of crude oil drawn at the facility being Permitted° abeggadk44e-Ata6a0fld tool If nothe permit will contain an Initial Compliance testing requirement to develop a site specific emissions factor cased on guidelines m P5 Mem O 14-03 Does the company request a control derceef/iency greater than 9Smoo for a flare orcombustion deuce? fdta If yes the permit will contain and intial compliance test condition to demonstrate the destruction efficiency of the combustion device hazed on inlet and outlet concentration sampling Section 00 - Technical Analysis Notes source used two tank rues to calculate eMbbl/dayfactors dfor this point MThe 30,Oo0ashtanks resulted Inaanand nfactor Mbl/dopo ach o and the 000,0006n1s, nos resulted Inan ae for wfactor alculted b1992 this ra. The source assumed a basis of 6o M661/tlaV and allotted A.1 Mbbl/day to each of the 30 WO bbl tanks and 13.7 Mbbl/day Co each of the 100,000 bid tanks. The VOC emission factor was calculated based on this. ratio. EPA Tanks was used to estimate the emissions from these tanks. The source receives flashed crude oil and will not exhibit am/flashing emissions. Section 09 - Inventory SCC Coding and Emissions Factors Uncontrolled Emissions AIRS Pointe Process SCC Code Pollutant Factor coot ol% Units 002 Cl /WIA63ATIngerim k Nloahng#oogiancta Va hltdngatea9amg.tones .M10 000 b/] 000 gallons crude o lthroughput PM2 5 0.00 b/1,000 gallons crude oil throughput NOx 0.00 6/1,000 gallons crude ail throughput VOC b/1,000 gallons crude oil throughput CO 0.0 .0 0 h/1000 gallons crude oil throughput Benzene 0.00 b/1,000 gallons crude oil throughput Toluene 0.00 b/1000 gallons crude oil throughput Ethylbenzene 000 b/1, 000 gallons crude oil throughput Xylene 0. W b/1,000 gallons crude oil throughput n- Hexane 000 O. 000 gallons crude oil throughput 224 TMP 000 6/1,000 gallons crude oil throughput Definitions for Drop Down Lists Storage Tank Emissions Factor Options State Default E.F. (includes flash) Other IDoaumented in Technical Analysis Notes) Site Specific E.F. (includes flash Site Specific EPA TANKS E.F. Working and Breathing Only Qualifiers No Yes Not applicable -stabilized tank Control evices Enclosed Flare Open Fare Vapor Recovery Unit IVFUI Control Device Combustion Emissions Factor Options AP -02 Chapter 13.5 Industrial Flares (NOa/CO) TNRCC Flare Emissions Guidance I000/CO) AP42 Toole 10.2(PM10/PM.25) SIC Codes - Storage Tank Emissions 4-04-003-12 Fixed Roof lank, Crude Oil, soot kingsbreatbmgdlatFmg loses 0,04,003-02 Fixed Roof Tank: Working & Breathing 1_053E5 4-00.003-22 External Floating Roof Tank, Crude Oil. worhingshrea lhingafl ashing 4 04003-06 External Floating Roof rank: Working and Breathing Losses 4-04-003-32 Internal Floating Roof Tank, Crude Oil, working/breathing/flashing 4-04-003,0] Internal Floating Roof Tank: Working and Breathing tosses SCC Codes- Flaring Combustion Emissions 3-1D-001-60 Flares 5 of 19 K.\PA\2016\16W E0318.CP1.rlsm Crude Oil Storage Tank Regulatory Analysis Worksheet Colones Regulation 3 Pares A and - APEN and Permit Requirements 1�• AINMENT Are uncontrolled actual emissions from any criteria pollutants from this individual source greater than TRY (Regulation i, Part A, SectionII.D.Lal? z. Is the construction date o 4/14/2014 and not mSited after 4/14/10(See PS Memo 1603 for additional guidance on grandfather applicability)? • If answer to0ns sthe crude oil throughputo than 40,000 gallons pee year?year?3. Are rural facility uncontrolled VOC emissions greater than STEM, NOagreater than 10 TPr or COemusiom greater than 10 TPy (Regulation 3, Part B, Section 4031? 'Not miehlnfe,mation NON -ATTAINMENT 1. Are uncontrolled emissions from any criteria pollutants from this individual source greater than 1 TPy (Regulation 3, Pan A, Section n,o.1,aP 2. is theconstruction date prior o4/1a/zolaa modified after 4/14/14(Se Memo 14-03 tor additional guidance on grandfather applicability)? • if is yes x the crude oil throughputlaathan 40,000 Ration per year? 3. Are total facility uncontrolled VOL emission irons the greater than 2 TRY, NOR greater Shan STPY or CO emlxnonx greater than 5TPy (Regulation 3. Part 9, Section II.1.21? sours requiem a permit Colorado Regulation 7. Section XVII 1. is tank located at a transmission/storage faculty' ]. Is this crude oil storage ank' located at an oil and gas eaploratlon and production operation, well production fanlity, natural gas compressor station' or natural gas processing plant? • s this crude oilrtora tank a fixed roofat rage tank? 4. Are uncontrolled actua lemiasioesot this storage tank eoualto or greater then Sloes per year VOC? !Storage Tank is sat sums m Regulation 7. Section XVII sectlonavll.g- Geneal Provieions tor Air Pollution Control Equipment and Prevention nfEmissions Section XVII.C.1 • Emissions Control and Monitoring Provisions Section3- Recordkeeping Requirements 5. Does tie crude oil storage tank cont ain only "stabilire a"liquids? Xreg, the following additional provision apply. 'Storage Tank is not rulbea to Regulation?. Section XVII. C,3 Section XVII.C.2 'Capture and Monitoring for Storage Tanks fitted with Air Pollution Control Equipment 40 CFR Part go. Subpart KB, standards of Perfnemene fn, Voluble Oceanic Liquid Storage Vessels 1. s the individual storage vessel capacity greaten than oequal to me ters ters (m'11'433 soLdI? 2. Does the storage vessel meet el meehe followingesmptlon in 60.160.111814114178'd114 a. e vessel has a design awdty tin than r equal to 1589.874 m' I' Iowa BEM noes fore mate stored, processed. ortratedprior to custody tans@,' as defined in -0allb4 3. Was this condensate storage tank constructed, reconstructed. or mohirm(see definitions 40 CFR, 6..3) after 23, 1904?nd 4. Does the tank meet the definition orstomge vessel"' In 60.1116? 5, Does the storage vessel store awnlame organic liquid (VOL)"' as defined in 60.1118? 6 Does the storage vessel many One othe fntlowmgadd3i nal exemptions: a Is the storage vessel a pressurevessel designed to operate in excess ol 204.9 kpa 7795 psi( and wdhout emissions to the atmosoMrele0110aeltT(ili or h. The design capacity is greater than or equal to Ill m' ("910 SAL( and stores a liquid amaximum true vaporpressure` less than 3.5 kpa (60..110blh11?; or c. The design capacity is greater Mantrap.' to 55 Ms 1'477 BBM but m11-950 Boo and stores a liquid with a mastnumtrue vapor pressures less than 15.0 kPa(W.110b161)? 'storage tank is subleT to NSPS Kb. including but out limited to. the Inllswing pe0vislonx Subpart A. General Provisions §60.11N- Emissions trol Standards for VOC §60113b .Testing and Procedures 460.115b Reporting and Remrdkeeping Requirements 4W,116b- Monitoring of Operations 40 CFR Part crSubpart 0000 Standards of Perbmwrte for Crude Oilnd Natural Gat orodercen Transmission and dsabutun 1. as this crude modified MI Storage vessel constructed, reconstructed. or mod( d (see definitons40 CFR, 60 1l after August 23, 2011? 2. Ones the Crude oil storage versa meet the deantlon of "storage venter' per 61543@ 3. Is this crude ou storage vessel o ted at a facility in theamore oil n atual gas al nuon segment,natural gat pmoesnngsegment or natural gas transmission and storage segment or the Industry? 4, Are potential VOLemisslons'from theiWltldual storage vessel greater than Orequal is Miens per year, Source Rea Go to next Gots next4 Source Reg Source is car Go to the n Go to men Go to the n. Go m the n. Go to Me n. mace s Soto then, Go to Me Go to then Subpart A. Ge-oral Pro visions per ;60.5425 Table 460Control Standards for MCC 360.5413 tand Paortlkeeoing Feuvirements 46 -3416tel - Raver and Closed Ven[ Sysrem Monioringregsirenenrs 566.5,117 - Control Device Moriter'ng PeouirementS No e'. pia storage vessel if previously determined to be subject to NIPS 0000 sue to emissions above 6 tons Per year VOC on the applinbility determination date,'4 should remain su hjectto NIPS 0000 per 60.5565fe}f31 even it potential VOC emissions drop below 6 tans per yearl 40 CRS Part 63, Subpart MAR HH, 03 and Gas Production Facilities .. n a facility that ir malor` for eAPsi L. sxstorage tired aoatedat an pit and natural gas production Matto t` s either of 'he follow 'r eclte,ia a. 4facility mat processes, upgrades St stores-ydmarbop upends 123 66rak rCR Maley at processes .0 grades or storevruu.+al gas prior'ofhe paint at whicrrnatural gas enters the natural gas'ransmisbon and storage course ategoryor is aellvered!0 a finaiend uses C63!601a0[311T Does the anc meet the denriiion of -storage vessel' 67_517 Doe, definition meet the p fogey _. potential for flash emission,' per 61l 5. a met m requirements a .art60, subpart CO Cr Subpar' 00007 [Stara subpart A.Genera l prsoslbrts per 563un :arable 2 463Emission mneol stanaam, 363773. Mon tor ng 663.774- RecorckeePlog 463.775- Reporting PAR Review PACT eview is required it Regulation 7 does not apply AND it the tank is in the nonattainment area. It the tank meets bath criteria, then review PPR requirements. Disclaimer This dewment assrsts operators NWT determ;nmg app6abllley orcertem regunments of :he Clean Ae Att Ifs Imoiemeohog regvlarmos and Ar OuaIty Control Comm.rtson regularmns. This document se Mg a rule r regulationand the analn^s d contains may not apply ro a particular situation baser! pon the Inmvmnanasts and circumstances This docemenmees not change or substitute for any law. regulator or any otherlegallylllNng regsllrment and rs not legally enforcea0/e In the event ob any conflict between :he language orthis document and the language of the Clean 41r Att, es implamentblg regalations, and Air Ouamy Conbol C0MM...on the languageofhe statute ornegulanaomat control The use ornommanos/ory/anguage such as'recommend 'nay,' 'Chatted and CJ1 1.5 rtendeolcdescrme ARC.^. interprelatrons and recommetdehons Mandatory terminology such as'musr and requiredare mtendedto dtscnbe controlling reaulrements under the c terms arrba wean .3n An Aone A;r Opanry Control Commission regwenons dpt MN comment epos not establish legacy miming reavirementu In and ciaeu Na Storage Tar Crude Oil Storage Tank(s) Emissions Inventory Section Ol - Adminsmative Information 'Facility Ails ID'. 3 County 9E53 003 Plant Point Section 01- Equipment Description Details Detailed Emissions Unit Eight 61)400 barrel fixed reef credo off storage vessels. Description: Emission Control Device Enebsed mue Desorption Requested Overall VOC & HAP Control Efficiency%: s Section 03- Processing Rata Information for Emissionates Primary Emissions- Storage Tan451 Actual Throughput. Requested Permit Limn Throughput= Potential to Emit (PTE) Throughput= 60,000 Barrels (bbl) per year 60,000 Barrels (bbl) per year 60,000 Barrels Ibbl per year Secondary Emissions- Combustion Device(s) Heat content of waste gas= 9700 Bts/si Volume of waste gas emitted per BBL of liquids produced = 6,33 scf/hbl Actual heat t of waste gas routed to combustion device = Request heat content of waste gas routed to combustion device - Actual Crude Oil Throughput While Emissions Controls Operating = 1,405 MM BTU per year 1,405 MM BTU per year Potential to Emit(PTE) heat content of waste gas routed to combustion device= 1,105 MM -EU per year Section 04- Emissions Factors&Metodologies Will ibis storage tank emit flash emissions? Crude Oil Storage Tanks Control Device VOC Benzene Toluene ENYlbenzene Xylenes rrMezane 0.006 001 0004 0.014 Boa —*The mass fractions for VOC a d HAPs In the were derived from the spema0on poetic for crude oil from EPA TANK 4.0.9d Pollutant Uncontrolled E.F. Ohs/bbl Crude Oil Throughput) Controlled E.F. (lbs/bbl Crude 00 Throughput) Uncontrolled E,G, (lbs./MMBtu waste heat combusted) Uncontrolled E.F. (Ibs/bbl Crude On Throughput) Emissions Factor Source Citation PM10 PM2,5 VOC CO Benzene Toluene ElM1beXylnzene neee ne H n-uane Section 05 - Emissions Ines tory 0.50449... 0.00303 0.00504 0.00702 0,00]06 0.00202 0.02522 0,00015 0.00025 0,00010 0,00035 0.00010 0.0075 0 0002 \,.. %XX' 44•7' 0,00]3 NANNLVVVVIii 0.31 Criteria Pollutants Potential to Emit uncontrolled (tons/year) Requested Permit Limits Uncontrolled Controlled (mns//year) (tons/year) Actual Emissions Uncontrolled controlled (tons/year) (tons/year) PMlo PM2.5 NDe VOC co 0.01 0.01 0.01 0.01 001 0.01 0.01 0.11 0.01 001 0.05 0.05 0.05 0.05 0.05 10.13 15.13 0.26 15.13 0.76 0.22 0.22 0,21 0,22 0,22 Hazardous Ale Pollutants Potential to Emit Uncontrolled (tans/year) Requested Permit Limits Uncontrolled Controlled (tons/yeerl (tons/year) Actual Emissions Uncontrolled Controlled (tons/year) (tons/year) Benzene Toluene Ethylbenaene %ylene n -Hexane 224 IMP 0.09 009 0.00 0.09 0,00 0.15 0.15 0.01 0.15 0.01 0.06 0,06 0.00 0,06 0,00 0.21 0,21 0.01 0.21 0.01 0.06 0.06 0.00 0.06 0.00 0,00 0.00 0.00 0,00 0.00 Secton 06- Reg ulat Regulation 3, Parts A,B Regulation 7, Section XVII.B, C.l, C.3 Regulation 7, Section XVII C.2 Regulation 6, Pan A, HOPS Subpart Kb Regulation 6, Pan A, POPS Subpart 0000 Regulation 8, Pan E, MALT Subpart HH (See regulatory appnobi4ty worksheet for derailed analysis} ry ry M Source requires a permit Storage tank is not subject to Regulation 7. section %VII Storage tank is not subject to Regulation 7. Section XVII.C.2 Storage Tank is non subjec to NSPS Kb Menage Tank is not subject to NSPS 0000 Storage rank is not subject to MAI:r HH Section 07- Initial and Periodic Sampling and Testing Requirements Does the company use the state default emissions factors to estimate emissions? - --- " to Ifyes, athe the permit uncontrolledactualan "Initial requested emissions esdmaleeto bent ogreater than otequal to 20tons VOC per year' se '(yes, the permit will contain an "Initial Compliance" testing requirement [o develop a site specific emissions factor based on guidelines in PS Memo 1403 t of 19 N:\PA\2016\16WEo318.CP1.slsm Crude OH Storage Tank(s) Emissions Inventory Does the company use a site specific emssons factor t0 eznmate emissions? 3es._ u yes and rthere flash emissions are the emissos factors based on a pressurizedliquidsample or crude oil dawn at the fadlity being permIted2 FCAt.91a$14 *-bedllbld It no, the permit will contain an "Initial Commiancetesting requirement to develop a site specific emissions!dent based on guidelines in PS Memo 14-03. oyes the permit reguest ontai control device efficiency fest-ondclM1ano %de ror a nstrate orcombustiondecer evic If yes. the permit will contain and meal compliance n[e tezt'o nditlon to demonstrate xt ate the destruction efficiency of the combustion device based on inlet and outlet con ceovation xam piing section 08- Technical Analysis Notes EPA tanks was used to estimate the emissions from these tanks. The zomce receives flashed crude oil and will not exhibit any flashing emissions. Section 09 - Inventory 5CC Coding and Emissions Factors AIRS Point II 003 Process it 5CC Code 01 Definitions for Drop Down Lists Storage Tank Emissions Factor Options State Default IT. )includes flash) Other I Documented in Technical Analysis Notes) Site SpecRe E.F. )includes flash) Site Specific EPA TANKS C.F. Working and Breathing Only Qualifiers No Yes Not applicable stabilized tank Control Devices Enclosed Flare Open Flare Vapor Recovery Unit (vRD) Control Device Combustion Emissions Factor Options AP 42 Chapter 13.5 Industrial Flares INOx/ml TNRCC Flare Emissions Guidance 1505/COB AP -42 Table 1.4-21PM30/PM.251 SCC [odes - S gank Emn issios 4-04-003-12 Fixed Rof Tank, Crude Oil, working Fbreath ngaflashing i oases a-00003.02 Fixed Roof Tank: Working & Breathing Losses 4-00-003-22 External Floating Roof Tank, Crude Oil, war kingabreathingafl ash) ng 4-04.003-06 External Floating Roof Tank: Working and Breathing Losses a-00-003-32 Internal Floating goof Tank, Crude Oil, work) ngabreathi nagflashing a-o4003A21nternal Floating goof Tank) Working and Breathing Losses 5CC Codes- Flaring Combustion Emissions 1-10-001-50 Flares n Uncontrolled Emissions Pollutant FactorControl % Units PMSC 000 ] b/1000 gallons nude oil throughput PMz5 000 6/1,000 gallons nude on throughput N0x 000 4 b/1,000 gallons nude oil throughput VOC 10 3 b/1,000 gallons crude oilthroughput 02s C000 17 5 b/1,000 gallons nude oil throughput W Benzene 0. 95 6/1,000 gallons nude od throughput Toluene 0.12 5 5/1,000 gallons crude oil throughput 1 Ethylbeniene 0,05 95 b/1,000 gallons crude oil throughput %ylene 0 12 55 h/1,000 gallons crude oil throughput n -Hexane 0,05 95 6/1,000 gallons crude oil throughput 224 TM 9 224 TMP 0.00 95 6/1,000 gallons crude oil throughput 90f 19 k_\PA\2016\ 16WE0310.CPlxlsm Crude Oil Storage Tank Regulatory Analysis Worksheet Colorado Regulation 3 Parts A and 6. APEN and Permit Requirements ATTAINMENT 1, Are uncontrolled actual emissions front any criteria pollutants from this individual source greater than 2TPy(Regulation 3, Pert A, Sectio011.0,1,.)? 2. Is the construction date prior to4/14/2014 and not modified after 4/14/14 (Ste PS Memo 14.03 for additional guidance on grandfather applicability)? h. 'laminar to 12 ism, is the crude og throughput less than 40,000 gallon per year? 3. Ace total facility uncontrolled VOC emgabnc greater thin 5 TPY. NON greeler than 10 TO, on CO emiscions greater than 1010' (Reguletlen 3. Pan II, Sect)o. 11.O.3)? [Not enough Information NON-ATiNNMENT 1. Are uncontrolled emissions from any criteria pollutants from this individual source greater men l TPy (Regulation 3, Part A, Section 11.0.1.x)? 2. .s the constructlon date prior to4/14/2014 and not modified alter 4/14/14 (See PS Memo 14-03 for additional guidance on grandfather applicability)? 2a. If answer to 02 dyes, Is the crude dl throughput 'Nathan 40.000 gallons per year? 3. Are total laollty uncontrolled VOC emissions from the greater than 2 WV. NON greater than 5 TPy or CO emissions greater than 5 TP3 (Reguitlon 3. Pant g, Section 11.0.2)? 'Source requires a permit Colorado Regulation 7, Section %MI 1. Is this tank located at a transmission/storage rarity? 3. k this crude oil storage tank' located at an oil and gas exploration and production operation, well production facility', natural gas compressor station' or natural gas processing plant? 3. Is this crude oil storage tent a fixed roof storage tank? 4. Are uncontrolled actual emisslorri of this storage irk ego' to or fir than 6 tons per year VOC7 [Storage Tank u not subject to Regulation 7, Section 003 Section RNLI —General Provisions for Air Pollution Control Equipment and Prevention of Emissions Section %NLC.1 - Emission Control end Monitoting Provisions Section 1MLGa • Recordkeeping Requirements 5. Does the crude oil storege tank contain only 'stebieed" liquids?Inge, the following additional provisions apply. [Storage Tank is not subject W Regulation 7, Section RVc.C.2 Y!S section RVILG2- Capture end Monitoring for Storage Tanks fitted with Air Pollution Control Equipment 40 QR. Pert 50. 9ubeeet Kb. Standards of ►ar onnar et fur yaktile OM* 4kls►d 0onme %I ssek 1. Is the individual storage vessel tapar]ry greater than or equal to 75 ocbic meters (m') (`472 SOLs]? 2. Does the storage vessel meet the following exemption in 60.11161dg4)? a Does the vessel has a design capacity less than or equal to 1,589.874 bit (`10m0 RBI) used far petroleum' or condensate stored,processed, or treated prior to custody transhrl as defined ft B0.111b7 3. Wes this condensate storage tank constructed, reconstructed, or modified (see definitions 40QR, 60.2) after July 23, 1984? 4. Does the tank meet the definition of 'storage vessel"' 6160.111b? S. Don the storage vessel store a'voltile manic liquid (VOL)'' as defined in 60.111b7 6 Does the storage vessel meet any one of the following additional exemptions? a. Is the storage vessel a pressure vessel designed to operate in excess of 204.9 4Pa I"29.7 psi) ono without emissions to the atmosphere (60.1 ]Ob(d)121JA or b. The design capacity is greater than or equal to 151 rri (^950 001) and stores a liquid with a maximum true vapor pressures less than 3.5 kPa (60.110b(b))?; or c. The design capacity is greater than or equal to 75 M' (-072 BBL) but less than 151 m' ('950 Mt) and stores a liquid with a maximum true vapor pressure' less Than 15.0 kPa(60.1106(b)17 [Storage Tank is not subject to N5P5 %b subpart A. Gerrerel Provisions 460.1124 - Emissions Cptifol Standards for VOC 000.113k - Testing and Procedures 460.1156 - Reporting and Recordkeeping Requirements )60.1166 . Monitoring of Operations 40 QR. Part 60. Subpart 0000. Standard. of ►erfomwnn 114 Crude gland Nature) Gas Production. Tansmission and Distribution 1. Was this crude al storage vessel constructed, reconstructed, or modified (see definitions40 CPR, 60.2) after August 23, 2011? 2. Does this crude oil storage vessel meet the definition of 'storage vessel" per 60.5430? 3. s this crude oil storage vessel located at a fxility in the onshore col and natural gas production segment. nature. gas processing segment or natural gas transmission and storage segment of the industry? a. Are potential VOC emissions' from the individual storage vessel greater than or equal to titans per yew? yes Gc :o the n c :o the n Yes No Iourte Req G010 nett. Go as newt Some Rep source isnt Storage Ten Storage Ter Gcta then heimare Tank is not subject In Nels, STISOLT _ per 5c2.5425Tab e3 560.53n55 General p roe for NCC 960.5013Testing and Procedures and 5ecorckeeaing Requirements 560.5415(e) -C r osetl ene5ystem Monttunng Requirements Controla Monitoring Requirements lgi eod a storagvessel is previously determined to be subject to NSPS 0000 due to emissions above 6 tons per year VOC on the applicability determination date. It should remain subject to N5 P50000 per 60.5365(e521 evend potential VCRemissions drop below 6 tons per Veer] 40 Mit Mrt 63 Subpart MAR RH, Oil and Gas Production Minims L Is the tank looted at a facility that ao0 for 1APs) 2 isthe storage tank located at an oil and natural gas production facility that meets either of the following criteria a. P amity that processesupgrades or stores sydmarpon Sgt..: [63.. fi0tal(2)1i GP ,acilaythet processes ua es or stores oral gas riir to thepomt at whichnature gas enters the natual gaz ansmissionandstoragesource category sr s final'63 .eo gees The tare meet the de9.orhtorage verse sIn ..6n goes me tany meet he definition n,.x r mho ortentlai Too oath emission, ' per 63 hop Is the sank merle,. to antra, requirements a nges 40 CPR part w. Subpar Fab or Supart opa0000, s,. Tank is net ruts.^., lc MAC Ntt Subpart A, Generalper 553 ial iareea 563 Control Standards 463.113 Monitoring 469 cordkeeoing 463.115 -Reporting PACT Review PACT review is required if Regulation 7 does not apply obD it the tank is in the non -attainment area. II the tank meets both criteria. then review RAC requirement. Disclaimer Th,s document aaoists operators with ocrermning appncakuniiy leer: reoorrements or the Clean Ad 3Cmits mplemsntingregwatlons.anear 00ardr Control Commissron regulations This dochmenru not rare or regurarlon and he analys,s st ccnrams may nor apply to a paMcular sd5arron based upon me inon9dual Facts and ClCumNanDa6. m,6 document does nor change orsuksemte for anylaw. reglrmen. n am other s.7ndAACog etyrequTement and u' not legally regulaeons rro e.ar In the Jr the of cram ccr reg latwn wl control u e o eemmanrand ma language orrhe Clean all Ac!,. es "M ,mplamennnd 793 ss ntanec TodtadryeoneClcwm regwdrecomaladguaga Mrthe atoryte ttrroiogymuch as The use of are Wendel toguage doccnhucharllmgr✓nand."mar" "shand lean', eetIdoalimy ontr lConrp esionregWarecsmmende document ulentdoes notrstahigy suchdab ana on,& Ascitl to tlescnbe ccntrolling mpuiremenrs upper;ne puM�" sinrsna 'arms m rna aaan.urAct ,ndar aparey Control epmmua,on regmarronb durrhm ppcpmam eras not asrabrt6n Iegs,rhmdmg rapp,ramantb,n spa pra6brc 5,0 -age Tar Crude Oil Storage Tank(s) Emissions Inventory section 01- Admmmative Information }Facility AIRi ID: 123 9ES3 004 County Plant Point Section 02 - Equipment Description Details Detailed Emissions Unit ohe(D) 50,700 hW internal Description: Emission Control Device Internal Floating:Roafand enclosed Pere Description: Requested Overall VOC & HAP Control ENlciency%: 95 Section 03, Processing Rate Information for Emissions Estimates Primary Emissions- Storage Tank(s) Actual Throughput= Requested Permit Limit Throughput= Potential to Emit (PTE) Throughput = Secondary Emissions - Combustion Devke(s) Heat content of waste gas= Volume of waste gas emitted per BBL of liquids produced = 0005936 scf/bbl Actual heat content of waste gas routed to combustion device Request heat content of waste gas routed to combustion device dl storage lank 21,900,000 Barrels (bbl) per year 21,900,0C9 Barrels (bbl) per year Barrels (bbl) per year 3700 Eltu/scf Actual Crude Oil Throughput While Emissions Controls Operating= 21,900000 481 MMON per year 401 MMBTU per year Potentialto Emit (PIE) heat content of waste gas routed to combustion device= 981 MMBTU per year Section 04. Emissions Factors & Methodologies Will this storage tank emit flash emissions? Pollutant PMID Section 05 - Emissions lute too Uncontrolled E,F. (Ibs/bbl Crude Oil Throughput) Controlled E.F. (ms/bbl Crude Oil Throughput) Uncontrolled F.F. Uncontrolled (Ibs/MMBtu E.F. (Ibs/bbl waste heat Crude Oll combated) Throughput) 0.0025 \\\\\\\\\NA D daoo r=aa o.om7 , 600003799 b\\\\��\\\\.: 60owogss 600000023 \\\\\\\\\\ 0.o 000304 C.o000d03a \\\\\ \\\%\ 00oo083w o 00000553 \\\\\ \\\\\ o OLC00304 3.000111ms3 \\\\\74.\\\\ o.000p9000 o.iw000000 l\\\\\\\\td-: VOC Benzene 0.006 Toluene 0.01 Etylbenzene o 004 Xylenes 0.014 n -Hexane 0.004 ^ the mass fractions for VOC and IIFPs in the were derived from the epeciuccn profile tar crude oil from EPA TANK 4.0.94 Emissions Factor Source Citation Criteria Pollutants Potential to Emit Uncontrolled ltans/ymrl Requested Permit Limits Uncontrolled Controlled (tons/year) (tons/year) Actual Emissions Uncontrolled Controlled (tons/year) (tons/year) PM10 PM2.5 NOB VOC co 0.00 0100,00 000 0.00 O,W 0 DO 0.00 000 0,02 002 0.02 9.02 8,31 831 0.42 8.31 0.42 0.07 0.07 0.07 0.m 007 Hazardous Air Pollutants Potential to Emit Uncontrolled (tons/year) Requested Permit Limits waontrmled Controlled Ituns/year) (tons/year) Actual Emissions Uncontrolled Controlled (cons/year) (tons/year) Benzene Toluene EMylbenzene Xylene mxvane 224 TMP 0.050 0,050 0.002 0.050 0.002 0.083 0.083 0.004 0,083 0.004 0.033 0.033 0.002 0.033 0.002 0.116 0.116 0.006 0.116 0.006 0.033 0,033 0.002 0.033 0.100 6000 0,000 0.000 (L000 0,000 section 06- Regulatory Summary Ana Regulation 3. Parts A,e Source requires a permit Regulation 7. Section XVII.B, C,1. C.3 Storage Tank is not subject to Regulation 7. Section XVII Regulation 7, Section XVILC2 Storage Tank is not subled to Regulation 7. Section XVII C.2 Regulation 6. Part A. NIPS Subpart Kb Storage tank is subject to POPS Rh. including but not limited to, the following Regulation 6, Part A, NIPS Subpart 0000 Storage Tank is not subject to NSPS 0000 Regulation 0, Part E. MACT Subpart NH Storage rank is not subject to MALI 116 guNlory applicability worksnmtfw detailed analysis) Section 01- Initial and Periodic Semolina and Testing Requirements Does the company use the state default emissions factors to estimate emissions? If yes, are the uncontrolled actual or requested emissions estimated to be greater than or equal to 20 tons VOC per year? If yes, the permit will contain an "Initial Compliance" testing requirement to develop a site specific emissions factor based on guidelines in PS Memo 14-03 12 of 19 K:\PA\2016\16 W E031&Col Blsm Crude Oil Storage Tank(s) Emissions Inventory Does the company use a site spetlncemalons factor to estimate emissions. If yes and if are flash em s ons are the emissions laeors based on a press[; zed liquid sample of crude oil drawn at the :.. • facility being permitted% No; gppBubina sHMhe21WfIF If no the permitwol contain an Initial Compliance testing requnemen[m develop asite specific emissions factor based on guidelines in PS Memo l4-03. Does the company request a control device efficiency greater than 95% for a fore or combustion devices No If yes, the permit will contain and inGel compliance test condition to demonstrate the destruction efficiency of the combustion [moire based on inlet and outlet concentration sampling Section 08- Technical Analysis Notes EPA Tanks was used to estimatethe emissions from them tanks. The source receives flashed crude oil and will not exhibit any flashing emissions. This point will potentially receive"highly volatile organic compounds" as defined under Regulation 7, Section lVA . The source will meer the requirements of this section by complying with NSPS Kb (tuition approval granted under Regulation 7, Section IVA21 in lieu of the requirements to store the highly volatile organic compounds "ina pressure tank which Is at all times capable of maintaining working pressures sai dent to prevent vapor loss to the ambient air" (Regulation], Section IV.5.1) Section 09. Inventory Scc Coding and Emissions Factors AIRS Point[ 004 process# 01 Definitions for Drop Down Lists Storage Tank Emissions Factor Options State Default E. F. (includes flash) Other (Documented in Tnchhrcr I Analysis Notes) Site Specific S.F. (includes lush( Site Specific EPA TANKS E . Working and Breathing Cnly Donliliers No Yes Not applicable Devices -stabilized tank Controlevices Enclosed Flare O pen Flare vapor Recovery and(VR8) control Device Corn bastion Emissions Factor Options S P -a2 Chapter 135 Industrial Flares (Non/CD) TN RCC Flare Emissions Guidance INOx/COI AP -42 Table 14-21PM10/PM.2 51 SCC Codes- Storage Tank Emissions 4-04-003-12 Fixed Roof Tank, Crude Oil, workingsdrearh ngeflashing losses 4-04-00102 Fixed Roof Tank. Working & Breathing Losses 4-00.003-32 External Floating Roof Tank, Crude Oil, worfing+brearhingrnashing 5-04 003,06 External Floating Roof Tank:Working and Breathing Losses 4.04-003-32 Internal Floarin g Roof Tank, Crude Oil, wookingrk eearhingrfashmg 4-01003-W Internal Floaun g Roof Tank. Working and Breathing Losses SCC Codes - Flaring Combustion Emissions 3-10-001-40 Flares Uncontrolled Ernissiom Pollutant Factor PM10 0.00 0.00 NOx 0.00 VOC 0.0 CO 0.00 Benzene 000 Toluene 0.00 Ethylbenaene 0.00 %ylene 0 00 ix -Hexane 0.00 224 IMP 000 Control% Units 0 b/1,000 gallons crude oil throughput 90 0 9S 95 95 95 95 95 6/1,000 gallons crude oil throughput b/1,000 gallons crude oil throughput b/1,000 gallons crude oil throughput b/1,000 gallons crude oil throughput 6/1,000 gallons crude oil throughput 6/1.000 gallons crude on throughput b/1000 gallons crude oil throughput 6/1,000 gallons crude oil throughput 6/1,000 gallons crude oil throughput 6/1.000 gallons crude oil throughput 13 of 10 K.\PA\2016\16W E0310_CP1 xlsm Crude 011 Storage Tank Regulatory Analysis Worksheet ao Regulatlon 3 PeN.L and ATTAINMENT 1. Are onSection olled actual emissions from any criteria pollutants from this inclividual neuron greater than 2lPY (Regulation 3,P Part A, 11.0.1.0)? 2. Is the construction date prior to 0/14/2014 and not modified after 4/14/14 (See PS Memo 14-03 for additional guidance on grandfather applicability)? 2a. If answer top] is yes. in the crude oil throughput less than 40,000 gallons per led? 3. Are total facility uncontrolled VOC emissions greater than 5 TPY, hoc greater than 10 TIP or CO emissions greater than lO TPY (Regulation 3, Part R, Section 11.5.3)? Not enough information NON -ATTAINMENT 1. Are uncontrolled em ns era « t anyis pollutants m this Individual source greater A. than l TOY (Regulation 3, Part section II.0.1.al? 2. Isthe constructron date pnor to4/14/2014 and not modified ater 4/14/14 (See PS Mo 14-03 for additional guidance on grandfather applicability)? 2a. It answer to 02 is yes, is the code oh throughput less than 40,00gallonper year? 3. Are total facility uncontrolled VOC emissions from the greater than 2TPY, NOx greater than 5 TPY or CO emissions greater than 5TPY {Regulation 3, Part g Section lL0.2)? fsa Tee ern rrtsa permit Colorado Regulation 7 SMbn MVll 1. Is this tank located at a transmission/storage hdllty, 2. s this crude oil storage tank' located at an oil and gas exploration and production operation, well production facility', natural gas compressor station' or natural gas processing plant? 3. Isthis crude oil storage tank fixed roof at rage tank) 4. Are uncontrolled actual emissionsHofthN storage tank equal tour greater than 6 tons per year VOC? IStoroge Tank is not sublect to RegolariOn 7. Sett %VII Section II.B- General Provisions or Mr Pollut Control Equipment and Prevention of Emoelonc Section oNLG1- EmControl and M ni rag Provisions Section %VII.C,3 - Record keeping Requirements 5. Does the crude oil storage tank contain only stabilized" liquids? If no, the following PMTon.' provisions apply. 'Storage Tank Regulatn T Sec on NVlll.2 Section XV1I.C.2 - Capture and Monitoring for Storage Tanks fitted with Air Pollution Control Equipment at CTR Part 65 Subpart Kb Standards of performance for Volatile Organic )quid Stomas Vessels 1. Is the individual storage vessel capacity greater than or equal to ?5 cubic meters imt) (-472 BBLs)? 2. noes the storage vessel meet the following exemption In EC.111b)d?4l? a. Does the vsel has a design a atlty less than or equal tot1,sgg.874 POIDOOD BBL]u Dr pet condensate stored, processed, or treated prior to custody transfer 60.111 as defined in b? 3. Was this condensate storage tank constructed, reconstructed, or modified Dee definitions 40 CFR, 60.21 afterluly 23, 19544? a. Does the tank meet the definition of `storage vsse l"a in 10.11lb? 5. Does the storage vessel store a"volatile organic liquid {VOW' as defined in g111b? 6. Does the storage vessel meet any one of de following addltionalexemptlons: a. Is the storage pr essure v cel designed to operate in excess or 204.9 Spa r29.7 pail as without nn eaxix to re )00. 06w)i2u?: e b. the design opacity is greater an or eqw to 151 m'[-950 90Ll and stores a liquid with a maximum true vapor pressur2less than 3.5 kPa (60.1100(b07; or c. The design capacity is greater than or equal to 75 Mil"472 BBL] but less than 151 m' 095OBed and stores a liquid wlwitha maximum true vapor pressure' less than 15.0 kPa(60.110b1b117 'Stange tank is subsea so NAPS Pb. Including karat limited to. the following provisions b112b- Emissions Provisions 4trol Standards fon VOC 560.11So - Tand Procedures 660.11Ebt reporting and Record keeping Regdrements 60.116b 4 - Monitor int of Operations 40 CFR Part 60 Subpart 0000 Standards of Pedarmanae for crude Oil and NaturalGat Production i oo ark Distribution n crude oil storage vessel co utled, reconstructed, or modified) Dee definition 40 CFR, 60.2) after August 23, 20117 2. Does Psis crude al storage vessel meet the defnitianor'storage vessel' per 60.X30? Is this crude el storage vsel mated at a facility in the onshore oil and natural gas production ne men m natural al gaxoce sing segment or natural gas Iranm andstarage Segment of the industry? 4. Are potential VOL emissions' from the lndividwl storage vessel greater than or equal to 6 tons per year? Source ext Go to next, Go to next I Source Reg Source is no Coto then Go to men GO to the n i, nbpart n. general P' Imns snet 40054 23 Table3 §605345 Emissions control Standards for V 00 460 5413 resnng and Pmaenscs 460 95(g)- Notification. apportng and Reromktto, 3ede:emend §60_Sa161e1 CMonitoring Requirements §50,5417 cons. Cemee s Recatrements (Noe: I a storage vessels previously determined to be subject to Nail 0000 due to emissions above 6 tons per year 000 on the applicability determination date. s should remain subject to MPS 0000 per 60.53651e1131 even Npeentiel VOC emissions drop below 6bm per year] 40 CFR, an 53, Subpart MAR NN Oil and Gat Proaveinn 5atBltlea _ OCatea at a facilllymat,.Tack HAP'? 2 Erie storageank located at an oil aro natural gas prom. onmcley that meets enter ofMerollovn rig criteria. a. N faemy that processes, 30grates or stores Mmpaarbon liquids' 163 76001P)), OR b. A fadliry that process, upgrades ar stores natural gas prier to the point at whim natural gas enters me natural gas transnlssion and storage source category or is delivered to a final end user 1632522Ia2I311T . Does. tang meet thedenniti ct'storage resseltin 63] 611 ones me tans I the definition or -swage v with the potential nor flash e 's per 53 61? IS the tank suolee to control requirements unde4103 Pitt 60, Subpart Kb or subpart 00001 1st - Tank s not subject to VAC? NN Subpart A. General p30011 Standards§63 64Iaj"a bIt2 463 Control pn §63-773- Monittoring 463.774- teaotdkeepog §63.775 -Reporting CI Review sN PAR review is required it Regulation 7 does not apply AND if the tank is in the non -attainment Disclaimer lithe tank meets both criteria. Men review RAM requirements. This document rase ls6 operators mtlh determmmg apo2cabdEy of ertain ,equiremenrs of the Clean Air Act Rs unplemenl13g reguladoms and Air Qualey Control Cgmmrson ,egulatnns. This document.h not a rule or regulation, and the agalysi6 it contains may not apply ro a panlcularsrtuation based upon the indrvldual facts and circumstances Mrs document does not ?mane or sobstYute for any law regulanoe or any other legally brndvig requeemect and rs not legally enforceable In the event o/any conflict netween the language of this document and the language of *he glean 9u Act. Re mplementng regmatisn6. aed Av pueoobeControl Commlpeton regulatlpns the language of the or regulari3n well control The use of on-manaamry language such as'recgmmeno."'may ' 'should'a end.cdescibe AFC', mrermretaoons and recommendations Mandat0rytemtnel1gh suc,e as 'must" and 'equlred"e itttife cescnbe controlling requreemente under the .arms or the Clean An Act and All Ouaby Control Commission regu/abong but rhrs document does not establish regally brndmg mpureements m and el Itself �5mrage Tar Condensate Storage Tank(s) Emissions Inventory Issuance Date: December 30. 2015 Section 01- Adminstratlee information acuity AIRs ID: 113 9ESE 005 County Plant Point 5ec3ion 02 -Equipment Description Detailq Detailed Emissions Unit Description: Emission Control Device Description: Requested Overall VOC & HAP Control Efficiency W Two (2)750 bbl fixed roof produced water storage tanks Enclosed flare 95 section 03 - Processing Rate Information for Emissions Estimates Primary Emissions- Storage Tank(s) Actual Produced Water Throughput= Requested Permit limit Throughput = Potential to Emit (PTE) Produced Water Throughput= 2,190,000 Barrels (bbl j per year Actual Produced Water Throughput While Emissions Controls Operating = ;190,000 Barrels (bbl) per year 2,19%000 Barrels Ibbl l per year Secondary Emissions - Combustion Deyice(s) Heat content of waste gas= 2045 Btu/scf Volume of waste gas emitted per BBL of liquids produced = 0.00219 scf/bbl Actual heat content of waste gas routed to combustion device = Request heat content of waste gas routed to combustion device = Potential to Emit (PTE) heat content of waste gas routed to combustion device = Section 04- Emissions Factors & Methodologies Will this storage tank emit flash emissions? 368 MMBTU per year 368 MMBTU per year 360 MMBTU per year Produced Water Storage Co trol Pollutant u PM2.5 NOR Vac Co Benzene Em (benzene X lens Hewn 224 TMP Uncontrolled F.F. (Ibs/bbl Produced Water Throughput) Controlled E.F. (Ibs/bbl Produced Water Throughput) \\\\\\\\\ `\\\w\\" \\\\\\1.\\\ 0.00039 Uncontrolled E.F waste heat combusted) Uncontrolled E.F. (Ibs/bbl Produced Water Throughput) 0.000007 0.000038 x900002 0.000030 0.000574 Section 05- Emissions Inventory 2.000000 0000002 0.000000 0,000002 0.000029 0.00002 Criteria Pollutants Potential to Emit Uncontrolled (tons/year) Requested Permit Limits Uncontrolled Controlled (tons/year) (tons/year) Actual Emissions Uncontrolled Controlled (tons/year) (tons/year) PM10 PM25 N0a VOC Co 0.0 0.0 0.0 0.0 0.0 0.0 0.0 00 0.0 0.0 0.01 0.01 0.01 0.01 0.01 3.66 B.E6 0.43 8.66 0.43 0.06 0.06 0.06 0.06 0.06 Hazardous Air Pollutants Potential to Emit Uncontrolled (tons/year) Requested Permit Limits Uncontrolled Controlled (tons/year) (tons/year) Actual Emissions Uncontrolled Controlled ltuns/yea0 (two/Year) Benzene Toluene Etbylbenzene Xylene n -Hexane 224 TMP 0.0071394 0.0071394 0.00035697 0.0071394 0.0'0035697 0.0419385 0.0419365 0.002096925 0.0419385 0.002096925 0.00202356 0.00202356 0.000101170 0.00202356 0.000101178 0.03307995 0.03307995 0.001653990 0.03307995 0.001553990 0.628968 0.628968 0.0314484 0.628968 0.0314484 0.0342735 0.0342735 0.001713675 0.0342735 0.001713675 Section 06- Regulatory Summary Ana is Regulation 3, Parts A, B Source requires a permit Regulation 7, Section %VILE, Cl, 0.3 Storage Tankisnot subject to Regulation 7, Section XVII Regulation 7, Section XVII.0.2 Storage Tank is not subject to Regulation 7, Section XVII.0.2 Regulation 6, Part A, NIPS Subpart 0000 Storage Tank is not subject to NSPS 0000 en regulatory applIcability worksheet or detailed analysis) Emissions Factor Source Citation 16 of 19 K'.\PA\2016\16WE0318.Opt slsm Condensate Storage Tank(s) Emissions Inventory issuance Cate_ December 30, 2010 Section 07- Initial and Periodic Sampling and Testing neon irementt Does the company use a site specific emisions factor to estimate emissions? Yes If yes and if there are flash emissions, are the emissions factors based on a pressurized rqud water sample drawn _.._ at the facility beng permitted and analyzedusingflash liberation analysis, This. eaple should be considered repreeravwltcftgenerally means ste-spectc and collected within a yeara of the appis received date However[ if the facility has not been modified leg., no new wells brought on -I net then it may be appmprate Co use anolderste -se it sample Yes If no, the permit will contain an "Initial Compliance" testing requirement co develop a site specific emisions factor. See PS Memo 14-03, Questions 5-9 and 5 12 for additional guidance on testing. Does the company request a control deviceeHicienry greater than 95% for a flare or combustion devices Np, It yes, the permit will contain and intial compliance test condition to demonstrate the destruction efficiency of the combustion device based on inlet and outlet concentration sampling Section 03 -Technical AnaNsis Notes Promax was used to estimate the emissions learn these tanks. The source receives pressurized water and will exhibit flashing emissions. Section 09- Inventory 5CC Coding and Emissions Factors Alps Point N 005 Process It 5CC Code to 4-04-05345 Fined Roof Tank. Produced Water, coot kingcbteathingrllashino losses uncontrolled Em nits Pollutant Factor PM10 000 0 PM35 000 0 NOx 000 0 VOC 0.2 95 CO 0.90 0 Benzene o.00 95 Toluene o. 00 95 Ethyl kengenc o. 00 95 xylene t. tt 95 n -Hexane 0.01 9s 224 TMP 0.00 95 Control % Units h/1,000 gallons liquid throughput b/1,000 gallons liquid throughput b/1,000 gallons liquid throughput b/1,000 gallons liquid throughput 6/1,000 gallons liquid throughput b/Lots gallons liquid throughput b/Loon gallons liquid throughput 6/1,000 gallons liquid throughput b/l,o0o gallons liquid throughput b/Lots gallons liquid throughput b/Lo00 gallons liquid throughput 17 of 19 K VPAA2m6A1bW [0318 CP1xlsm Produced Water Storage Tank Regulatory Analysis Worksheet Please note that NSPS Kb might be might be applicable for certain tanks at water management and injection facilities. It the tanks you are reviewing are at one of these facilities, please review NSPO Kb. Colorado Reeuladm 3 Pain A and B-APEXand Permit Requirements ATTAINMENT A Are unCOntrOlled actual e emissions from any criteria pollutants from Indivldualsource greater Y (Regulation 3. Pal? tssha m Ian R. se e ttpeaa totucongless olled than t%vsiosude oil redethe tank loo4o getter than 10TPPT facility Mr emissions greater lhan igaS tPYfRegterrin3,Partl5start 6, 3.3)1 ll.N]NI 3. Are total facility encon[ra lied anon ions greater mans TPY.NOx greater than 1G TPV or COgreater than 1G NY jR egulation 3. Part 5, Section ll.O.31? Nm enough information NON -ATTAINMENT 1. Are 'led emissions from any criteria pollutants from this individual source greater than 170 °Regulation 3, Part A, SecIi.h.l.aj? 2. Istheoperator imrng Jess than ix crude nil and the tank looted at non-commeroal facially for pro eSSing oil and gaswastewater? 11egulat rtniID.1.Ml 3. Are total facility llcontrolled VOC emrslom greater than 2 TPY, NOe greater than 5TM or CO emissions greater than 5 TPY (Regulation 3, Pont B. Sectionalt 0.2)? 'Source requires permit Colorado Regulation a. Shun XVII - Is this tank located at a transmission/storage Facility/ 2. Is this produced water storage tank' located at an oil and gas exploration and production operation, well production tank'''. natural gas compressor station' or natural gas processing plant? 3. Is l is Prodkrqedwaterstoragetank a axed roof storage tank? 4. Are uncontrolled actual em col this ragk et equal to or greater than 6 tons per year ROC? oeaga Tank is not subject toR OalaXani, Section Ohs Section XVn6—Gene rel Pns for AG Pollution ContPollUOon Control Epui menr and Preventiom n of Ensiuns SMio .. - Ern " Control and Monitaring Pr nns iio Section XVILC3- Record keeping Requxements 5. Coes the produced water storage tank contain only 'stabdlaed"liquids? lam, the following additional proeisiom apply. [Stara e Tank is not au" "situ Regulalias 2, he 0011-C.? Section XVII.C.2 . Capture and Monitoring Tor 5lorage Tanks fitted with Air Pollution Control Equipment 40 CfR Part 60 Subpart 0000, standards of Pedomunce for crude Oil and Natural Gas Production, Transmission and Distribution 1 as thix produced water storage vessel tnmvurted, reconstructed, or modified free definitions aO CPR, 60.21 after August 23, 201➢ 2. Does t is produced waters rage vessel meet the definition of /storage vessel" per 60.5430? 3. Is this produced water storagevessel lrcated at a facility in the onshore oil and natural gas ProdUCtron segment, natural gas processing segment or natural gas transmission and storage segment of the industry? 4. Are potential VOA emissions, from the individual s[ 'agevessel greater than or equal to 6 tons per year? 'Storage Tank is non subject to NIPS 0000 Subpart A. General Provisions per 460.5425 Table 3 6600005- Emissions Control Standards nor hOC 4605413- 0.osanlgl a NONrcatianProcedures 46Reporting and Rerotdkeeping Requirements 460.541610- Cover Closed Vent System Monitoring Requirements §60.5413- Control Device Monitoring Requirements Nato gasman vessel is enviously deternenedto be subject to POPS 000O due to emissions above 6 tons per year vote on the applicability determination date, itabould remain subject to NIPS 0000 per 60.536510(2i even if potential VIX emissions drop below 6tonaper yearj PAR Review PACT wNee is required if Regulation 7does not apply AND looks tank is in the non -attainment area. Nine tank meets both criteria. than review RACY requirement. Disclaimer Yes Source Flea rce Reg Goo it neon Source is nt Go to the n Go to the n 6a to then Storage Tar ibis document asssrseoerafors with deeerminng aoFahly or radar rear .ne Clear A) Act ,ts mpement,ngegaaronsandP'oualty Contra, C regualcns. Ths documents not arwe regwanon andrbeartalyss tcontars may,lot apptyto a oamur atmnsased upon the odmd.al roc, and e Ths document does ro, changeor mAat,ute rbr anyaw. ego:aecn or anyrherbgay[ ng.quremenr ardbnot !egad / etm ..rany conticr between heag,ayeo'hs.ocument andme anyuage of ,Le A, Act. ito !myem it.g eyue.na and r Quayd..ca_dm. regua.00s b uage urine stature egu2d zl eoln rvyangbao vclias end -'may" 'snou/d �ardce tended.. descrce ARCS nreroretatons and recommends,ons Manoe[ryr okgysuch a d)equne desc7be confrothrg Tqurremertsunderrhe to orrhe Dean Ar AcandL aryconroi Comm,.regularions,:hes dOCL.ment:OeStstabish.egad/b ne,gegrrements r anoot.sse/r C O N m onent Leak E [Leave blank unless APCD has already assigned a permit k & AIRS ID] [Provide Facility Equipment ID to identify how this equipment is referenced within your organization.] 0 LL Section 02 — Requested Action (Check applicable request boxes) Section 01 —Administrative Information Request for NEW permit or newly reported emission source G .c 0 L sc u L E c C Ca C z C �.l Q V c Ca L O E .7:▪ 0- E T `v N F E ° p p U Ca F N 0 F ❑ ❑ E F O a c. CO ▪ 0.0 N U U ❑ ❑ Request to limit IIAPs with a Federally enforceable limit on PTE APEN Submittal for update only (Please note blank APENs will not be accepted) ED ED Saddle Butte Rockies Storage & Terminals, LLC M Lucerne Crude Oil Terminal N N ECCC W A z Z C O a = E n U N u J. O co m Mailing Address: 858 Main Avenue, Suite 301 0 U O m 0 Person To Contact: Trent Miller E-mail Address: TMiller@sbpipeline.com CC c4 a 4 z Section 03 — General Information Co 0 N For new or reconstructed sources, the projected startup date For existing sources, operation began on: N. O = o z O a O N E zccm a c Q m ti z C, a U y v W E C E_pc yom L = = W O C 0 N 3 E • E o u ^� • = 3 �. a T O W J y w c U F c m°c m u TO .6 c E a N �.C F et u U S u_ _ .=a W 4 s 3O M m= av o E d Q w L V N E c U m CazCa W n .W_Uoi O W O O oc en � v c-- m M M N N N rnrna 'C CO'O m c O O o z at 2 z c- < N E GC E ° a. > • oy t y S C Q Ea) p � d g N a m co c. W < U. APEN forms: httn://wi> 7 Application status: htm_ 0 OOOO Don't know Don't know Don't know z z z z▪ DEES ❑� Information O W Section 04 — Re Ca > OOOO n C. C x o x x c P w c A c c L L N O O O b U O P. O. cn N w w ▪ 0 0 c v v V) pp P. C. r z z O 0 C U U J N N N S �_ L m .• __ c ▪ E E E F C. c c O •= .E O. 0- u u Ca L • S S Is this equipment subject to NESHAP 40 CFR Part 63, Subpart HH? Section 05 - Stream Constituents Identify the VOC & IIAP weight % content of each applicable stream. Ce F ; N Ae i 3 0 v X 3 0 0 o° > O O 0 O L On Heavy Oil (or Heavy Liquid) Light Oil (or Light Liquid) C W Check box to request copy of draft permit prior to public notice or issu S Form APCD-203-Fugiti veComponentLeaksAPEN-V er. I I-13-20:4 N 0 00 U O CIS Wtrgl a N a 0 c y 0 m c U CO ^ ` I Ager a M b0 n FORM APCD-203 onent Leak Emissions! AIR POLLUTANT EMISSION NOTICE (APEN) & Application for Construction Pe Permit Number: Section 07 —Leak Detection & Repair (LDAR) & Control Information Section 06 — Location Information (Provide Datum and either Lat/Long or UTM) O O 0 N U, > C O Vi a) ❑ O ❑ O E 2 ft 00 V] O G0 Q Q Z a a v o A E m o u ve i$ 0 O O _Le; 0 o� 0 C W W 0 N O U, O O N o, co 0 n Estimates a O C N C '1 C N O v 0 E 3 o E c C C d m [i F o ❑ OL da o` ar oC E N U a • o a ❑� I Water/Oil Units II L LL rC C U u Light Oil (or Light Liquid) Units 2 c C N N 2 E cc U to - r a ,- Heavy Oil (or Heavy Liquid) I Units U. Count' C [z. W rvC U Equipment Type Connectors Flanges Open -Ended Lines I. Pump Seals Valves 2 o C u E >' U A G O ≤- 9E v • o - .2 • ri L C c U 0 E C .- I C C O E :7 4 W 0- E C. E a t C IT t• o O C � ' O O p U L7 Estimation Method or Emission Factor Source EPA Leak Protocol EPA Leak Protocol EPA Leak Protocol EPA Leak Protocol EPA Leak Protocol EPA Leak Protocol Please use the APCD Non -Criteria Reportable Air Pollutant Addendum form to report pollutants not listed above. Requested Permitted Emissions5 Controlled I (Tons/Year) Uncontrolled (Tons/Year) \ \ \ \ \ N - 0N r C N O O O O O Actual Calendar Year Emissions° 1 Controlled (Tons/Year) Uncontrolled (Tons/Year) Emission Factor Units Identify in Section 08 Uncontrolled Basis Control Efficiency (% Reduction) Identify in Section 07 Control Device Description 0 te cr i Pollutant C N U u C v c x > ca0 -8 F i] X Z C O • a 2 O • .4- O O ▪ 42 W "0 y • 0_ d Q N E j a ▪ N E a• Ni C ... .0C ▪ •E U • § O C cc a L F O E a cC • � W • 2 ~L' c O • o W E E g L — W C 0 W N W E o F W L 0 C CIJ U T y v i 6 - j 1 6 Q-EO- i C N ` v O Le m C tia° o G' Q m N E T 0 s c.; E F C 4_� v W m m < 6 C W C O ▪ Ego T U E E C E o C C • C C CA C CO C 4 N 0 0 O1 - O C Q C0 O z Form APCD-2O3-FugitiveComponentLeaksAPEN-V er. 11-13-2014 O to C. FORM APCD-203 m C) on `o g0"' a G_ Q • Z N • U C N O C O • cr o_ C C 9 GJ L Section 01 — Administrative Information (check boxes below) _ z — y L 3 a ®❑❑ r. ❑ Transfer of ownership U U ❑ ❑ •O 7 c C' APEN Submittal for Permit Exempt/Grandfathered source ❑ ❑ O en W F C v C c 'C %(..i! J N V N NW/SW, See 26, T6N, R65W Source Location 858 Main Avenue, Suite 301 Durango, CO (303) 446-7532 z O a —General Information 0) 113 tr N 3Tzzz C CO ®❑® V .--c >. Z.) >C > 'C - Normal Hours or Source Operation: Are Flash Lmis c = d E o O V < v u 7 • C 72 C F G ❑ Y va Cn C ._ C S n, v c - 'N " y G L _G G a >...0 O L yt z F V an R C '> w0 C G O °...'1] u = = o < L, e 9 L �,o y L. v -7: c �.C ` O Gv, v > E a L L G V C C 4' L R F_ I1J : tVi VI `�N r- EH ... y C V E c r C 00 y _ ll N V V `J v 0 L J C .. u` V 'J .. CO _ '-n C N C 3-,O T _ _ .stiV L a -- C GO C L C v > N E `e `° ccp=34! R o E 7 e o C'< L O= CO :� E 4.. N Q 0.=c✓i v 4=F cCm E'O c 5 t C OO O E Ea. E V i m O U LJ c ?a _ter _a -b .ECUaI' E C W ^V i y C G O� v Q ` C v .y. .5: �. C..; Q Q C G < CO t- 0 W vl th fl M 01 N m v P C't C't z _ L. D inMM < C) C C C r C C C c Information Section 04 — Stora R -O N Requested Permit Limit: v L V, e, o N O on G v, = p o F O L. o v 7 O ` R U y 0 u 3v j g Q 1 T 2 C O .71 ❑ Q Ci J C C you _ X L m < C c ▪ cU 1 lJ • v 4 < z On Y = N U i T Z ia Name of Well API Number Form APCD-210-Cr O v L FORM APCn-2010 G' U L L C a O O U E C C G G F-4 F O E E C h..• E. a L C For Midstrea Section 05 -Stack Information 2 3U ¢ .0 L s. Y C tz 55 O a L N CD U s C L F an v o e 0 C. FtH C 0 0 N a= = E. o r N ee > O 2 Ili, C F 2.4 G E&P Sites Onl Information aration Technolo ea ection 08 — Gas/Lie Y C➢ C) G1 E. m o 2 a C) v E c ' C v 3 > o o rz N n Ta G h C C C C — O u J G L U J L CD -C r m m a 0 e. L Fes. Ci O 0 col E O E L CC L C v C L'1 C O s T. C y Emission Factor Data Source o 4 z `z H TANKS 4.0 o CC z z H TANKS 4.0 TANKS 4.0 -..1-- TANKS 4.0 Please use the APCD Non -Criteria Reportable Air Pollutant Addendum form to report pollutants not listed above. Requested Permitted Emissions Controlled (Tons/Year) Uncontrolled (Pons/Year) C \ O 0= I N 1 r 0 \ N 0 1 N O 0 A N O 0 Actual Calendar Year Emission Controlled (Tons/Year) Uncontrolled (Tons/Year) Emission Factor _ L s L z L 1 L 1 .O .0.0 L Uncontrolled Basis it O o O - o O O N C o G o C - C O g O C N = o O O O C= O C O= O N O _ — c Z -. > , � N 6 C J O - Ethylbenzenc U C > X C x ^ G T :�. C C N r. L w a„; 0 u O t C' U R .C N 1 L 94:Y y y __ J e. O O V L. F E y C R E C y C �w c 'O C F C T O C L L C _ 0 u — C�\ CO C C. O C) F C 0, N a. Q C ° E ti v A. 2 N CD Ec .. 1.G. C a 2 ) T A = C C '48 C E - � G Z II c 0 L N CC) _ a. v G o v. G Z m L-1 b ! Q .= v E L p„., G 6 — Ci ..N m -O W. •GL C y C O O 0 C a o O d v He.' ti — _ ll O � 0-, O y r 0- C U G O C C Te C C C 0 0 C O C F L" Q 0 c m C Y 0 C 0 E 0 Form APCD-210-CmdeTankAPEN 30,000-10,000 doc 0 et FORM APUD-2010 0 Cr to C L U;' a E , J C F 0 CO 0 V Cdr Ct G 0 04 z 1 z z O z �ll Q [Leave blank unless APCD has already assigned a permit # & AIRS !DI ithin your organization_1 0 E 0 0 J 0 .0 Y ❑ v A. y'. _ _G G — k C v. T D a Y U G O V C 0 Ci 8 O Q Y cla r, _ C R r5 It u 0. a'0. =❑❑ 0 L N = u G et t z C v U D C7 g En, �i L 0 C u o = F E Q z eo "' s .O cv v v F .- L E. L Y 0 Q G G G L C 61 G I. v U U 0 _ - C. . (j= El ❑ N 0 U ® ❑ ❑ ct Section 01 — Administrative Information m Saddle Butte Rockies Storage & Terminals, LLC Ce 7 ti C U Lucerne Crude Oil Terminal 7_ Ce NW/SW, Sec 26, T6N, 1465W 0) Ce L APEN Submittal for Permit Exempt/Grandfathered source APEN Submittal for update only (Please note blank APEN's will not he accepted) ❑ ❑ 858 Main Avenue, Suite 301 C z C J L oF Trent Miller Person To Contact Section 03 — General Information For existing sources, operation began on: -63 3T777 ®❑® v x >.>>7+ `C "] i IEEE _ T 0 Y N v c c o m L n c c • U F U C F F F 72 z A c n z s c r o. 3aJ A; .. .v. o c o -2gN 2 z j . F 'u Ce c >. ® ® E T N i _o .5 5 -161 s F 8 = &C Tr Ce G c c O a °c .c 0 F r F v f v U 0 ¢ N i z > G C C c ❑ G o re «CC N F ..2,3 C O F A, n' r Ce 11 C - v © `0 000 T O_ = . M M M > j el ei el - U7,,,,c: 'Z 4 C 0, C L1 Z r Eo., o Lz c t . F = m o a Q a ko ,-7,-::,c-, C 0 0 0 s c "SC,' �. .0 c '.- U CA c a W _ sic 0 nJ e G N . _ 3 F o v, L N 'b LU G G 4 3 C.J.2 F ..5 r C O N O C U n C ^ ,� ,..;.'6.\-).c.1 u C- Ce u z �' Jn p G c ti "L" L �^. C U F O C 9 D ' a y O .=' GO = GC = 42Cr" > i c co " o j e •n, .. ., c 7 R E N O c< d c a'- . 3 5 L. Z2 a- _ c s c U = m = N U .6! = ..n .5 a = m 18 = 00 s 4. c> c z E V 2 i G C- Lu e - Z �_ Cr Q L rC G'a '' �.% Q �' CO < C#t Q Q Information 3 C) Section 04 — Sto•a c U >. O 0 e Requested Permit Limit: J -C u> O 0 0 N = X c Ce O 000 F: 5 N Q z u L " 0 0 e E — u "> c zz 0 u 0 03 3 L 0 C 'n 0 M x L P. = F N c C.: Wells Serviced by this Storage Tank or Tank Battery (E&P Sites Only) Newly Reported Well El O O in 3 z API Number Form APCD-210-CnidetankAPFN 400. C\: CD ^Ct Cat wit FORM APUn_2010 0 Permit Number: For Midstream sites on Section 05 —Stack Information C.L 2 5 z o - C' Vertical with obstructing raincap cular: Inner Diameter (inches) = J 0 k outlet (check one): Direction of C Ca W O I- Y a u C L C at Y C Ca Z oc C O `c U 00 S Ca s v N y o m Ca v -t a m 0 o. CC/i v > 7 y - G j ll Ca o. J N rs o N P. C C Ca a 0 C U C Gib C L a sai Y ala CC i N C C �—C Cr 0 C C 0 C E S z Emission Factor Data Source AP42 Tbl 13.5-1 Y Ca AP42 Tbl 13.5-1 Tanks 4.0 Tanks 4.0 Tanks 4.0 Tanks 4.0 Tanks 4.0 Please use the APCD Non -Criteria Reportable Air Pollutant Addendum form to report pollutants not listed above. I� Requested Permitted Emissions Controlled (Pons/Year) I V' r N \ O^ v \ � \ O v \ C � \ 0= O v \ % v Uncontrolled (Tons/Year) \ M \ C1 C 0 \ in 0 \ 'C 0 \ -, N 0 \ b O 0 \ N 0 0 Actual Calendar Year Emission Uncontrolled (Tons/Year) I Controlled (Tons/Year) Emission Factor Uncontrolled Basis I Units C L llC C L a L=.0 a a a L a L a \\\\\\\\, GC L T O Sc M in O_ S V: O. .. NI-- 0 S 1-- 0 S N 0 C C r 0 C o C Z > `i Benzene N C F Ca y- y _ L N v T x N CC " 5. 2,2,4 Trimethylpentanej Ca i C V t C C. Ca i U U _ C. u G G C 9 at E C h C O C E a C C Y r C C. C1/4i•N R Y C C C L Ca N Ca C C Ca Y G C C C N 9 Y P. con Ca m t U C N H 0 Check box to rec 0 C 0 0 G 7, C 0 CO S m 0 0 a Ca E m 0 0 z C. C L C- Form APCD-210-Cmde'tankAPEN 400. doe 0 CI CO G4 FORM APCD-2010 [Leave blank unless APCD has already assigned a permit d & AIRS ID] [Provide Facility Equipment ID to identify how this equipment is referenced within your organization.] Section 01 — Administrative Information ❑❑❑ 0 L J] C UU Zv u z F U V 00 N Transfer of ownership Change permit limit ❑ ❑ v C NW/SW, Sec 26, T6N, 1265W APEN Submittal for Permit Exempt/Grandfathered source APEN Submittal for update only (Please note blank APEN's will not be accepted) ❑ ❑ 0 00 858 Main Avenue, Suite 301 IrjE r a S N Trent Miller Person To Conta R -mail Addres Section 03 —General Information CO y 0 t7.1 0 'or new or reconstructed so operation began on: Y p 777 N C C 0 p v 0 E z c .23 ®❑® Are Flash Emissions anticipated at z O U U a F C- F L c y - = 7 ca c c a i C C. r r V O U 2 V .4 U c O c S t u ._ `o — E O c cti _ ' y C c O E J N < < 0 o a; x z > . u c. E ❑ vcx ;cr. AI .c C v L Y c0 O C O -o • C f - It d = o E. ♦ ♦ ° 3 e o o E d e: ea E n r. N a C a O a p L V r4 -, y V^ V C v v M^ V c ' cy, y E '''� O L ' -J O (7). N C 4:..,a• E L: U Cl .- CC '_--, O CCi _ V in L z = G 0. u ,, LN s ¢ O °=E 2y" . 69. o :n 0. e� G . Y E C O _ E' u V '� z in L Y O V a O i t 0-5=r-' --5 C. ° = c o _ .i. < E a R c n U, .C Or 0. O M —U ._ n .Cd O% O O V >_ VC i C c W E 3 .O. ti E; b m y c R a E Ca Z o t = C 5 L N a C G c c.e'O c E I 7 Ev..vmOU.,�3C- e l s s; - a .E .o Z t cot v �. o. 0- t m o c v c t0 �- 4: ug a c L 0? E. > m m a. 0. 0 c O E E O t a0in a_= --- T O- .O L CO CO CO Z cs 4 V P. z o c Information Y C Section 04 — Stort It O 0 O 0 e N Requested Permit Limit: VI O y ❑ 0 0 .11 Q 00 < 00 4-4 C v � a ra O E Ohm °z S _ „o C i o ' 00 0 L O o Total Volume of Storage Tank (bbl) 0 VI :L M L C - C. r N ci, v Wells Serviced by this Storage 'tank or Tank Battery (E&P Sites Only) I Newly Reported Well ❑ ❑ ❑ ❑ Name of Well E Z e Form APCD-210-Crud:TankAPEN Polisl 0 0 FORM APCT)-2010 C Cr U Cu A CC y_ C., 2 41 L+ • O c C U • .C N o C.- E C R 021 U C z z 0 MI z F F.4 C Permit Number: Section 06 —Stack (Source, if no combustion) Location (Datum & either Let/Long or VIM) H 0 0 N c-i c :7 oce M M 2v C 5 3. C Cu C C.i Vertical with obstructing raincap Section 07 — Control Device Information E&P Sites Onl Information aration Technolo Section 08 —Gas/Lionids Se C C E CC 0 C 0 U c C E L C C. E L Y O C O Cu 0 O O 7 '754! 71. C Emission Factor Data Source AP -42 Tbl 13.5-1 TANKS 4.0.9d AP -42 Tbl 13.5-2 t C 0 V CA 77 G -o a 0 4 Cr. Y < H TANKS 4.0.9d S a 0 V < _ TANKS 4.0.9d TANKS 4.0.9d Please use the APCD Non -Criteria Reportable Air Pollutant Addendum form to report pollutants not listed above. Requested Permitted Emissions Controlled (Tons/Year) v O \. O v C a , •e e . e e e C . O C . e a C Uncontrolled (Tons/Year) \ e 6 \ etn e o \ W e 0 \ en C 0 \ N 0 \ en O o \ — O c Actual Calendar Year Emission Controlled (Tons/Year) Uncontrolled (Tons/Year) Emission Factor 2L -, a Cu - s = a aa L Uncontrolled Basis ac e a t\ — e- a , ., i e; e ecr„ a e \ c cC e 0 en e e a 0.00001 0.000003 o e = c g a p c_ z> u c `j E E c a C H U L s U v C T x z T 0 - U N G -. G H v N ith this application is complete, true and correct. E c 0 C. E O 'C c c S 'C Cu _ E u co _J N E-_ R L L d U L v ti C U v d t U 0 O C O O F r Cu 0 V N 1 0 G 0 c 0 C c O C c C CLI v GP FORM APCI)-2010 Leave blank unless APCD has already assigned a per Y 0. O c L 0 0. 0. = z = O m E L in c. 24 U U z - ' a 8 z ❑ c ❑ ❑ Ce C.) U, Section 01 —Administrative Information era o 0 s8 uU zs Lucerne Crude Oil Terminal NW/SW, Sec 26, TEN, 1465W 0 Z 0 '2 an 0 C '.l Durango, CO APEN Submittal for update only (Please note blank APEN's will not be accepted) (303) 446-7532 Trent Miller E Y G Section 03 —General Information v ;Tzzzzz ❑EZED v }'?Y? Ca N'®❑❑❑® T �• N 7 L v G C G ric aa N C C) c` c L= • Normal hours of Source Op Y U _0 0 A I 0 F N Ca 0 C C c I-' n`j C L G _ C " J j 0 L` L E > e"'C m oc c m 0 o. c c u L O O N N C'- 7 m GL_; u 4: C. `_' U C L L 9 0... N OcE C'❑ oC) N u u N O E `2.61 C._ C R r ^.l v. J Z CO Oe Ell U L Ca .0 0 C- rCJ a r+ G .n ¢ : T Ca > v 9 E v. C N � 7 4 'L. c E m E C C O L R U G C c O _ L o v o ._ UQ U C L M 17 y z s q E '° 0c L 0 N Q C C 4 t a o E s E ,V " C q U L a aL E o �.� N�G7 rG �JQaC .,v C 0. C.. v ¢ G Information CC C v Section 04 — Stor a a. T L C N 40 0 33 .12 L E Fixed Roof: El 0 u C 4 '.' a• Ca O .+ y E o O 'n LCa .5 R _ O Ca C C 0 C GO L 0 E- U, N 0. Cr. C n 9- T Ca w O an Ca an '0 0 T z C E z E z G )-207-ProducedWalerTank-APEN doe 0.I O v 0. FORM APCD-207 Water Stora F on O Co y can Section 05 — Stack Infot oration n C P. 0 U ❑ C -22 C. .21 Cr X 000 O y t c v 2 c0 m o 0 0 U 0 c A co C o G > N > 3 C L Co0No nO c c 0 0 U a .r, i V C O o. Co C c O O Co E -y L C E L Co L C 0 c u Cr L Estimation Method or Emission Factor SourLe AP -42 I bl 13 5-1 PioMax Model AP -42 lbl 13 5-1 ProMax Model ProMax Model ProMax Model ProMux Model ProMax Model _ 1 ProMax Model Please use the %PCD Non-Crttena Reportable Air Pollutant Addendum form to report pollutants not listed above. Requested Permitted Emissions Controlled (ions/Year) O \ T O " 0 O \ G O N O C \ — 0 O C. N 0 cc \ .y O \ H O ,O Uncontrolled (Ions/Year) \ 'Co \: x \ - a c \ C O c \ L. o k m OO c== \ m "- M O Actual Calendar Year Emission' Controlled (Cons 'Year) Uncontrolled ( Pons/Year) Emission Factor - lh/NESIhtu . Co L �_ L L .0 .0 L L_ Uncontrolled Basis x \O - _ ..-0 e O o C ,-, en c o a g 0.000002 - M o c O t- r O o 0 o 0 O m o O 0 0 Pollutant ^ _ Z \tit - y C = Elh}Ibenrene 1 2 ESX U x 2. 2_,2_,1-1 runethylpenlane L 7 2 on Ci - E L u L C. L L J C 7 CC Co J ^. L V R E u E `c e C S o !- L ;o R C cd 6 u S r L L L_ 3>a - c R E u2' C E L Coda E L c A e — L ; 91n c ' Od) - c o = u A L 1020 T x O aC: _ L c Co u c A C < C L v C Ryan Cheese Es 5 v c A L ¢ 72 -E. O U G�— > U - 0 z - L'1 Co C U C O Y < .00 C C Co F G C 2 2 R 0 C T T C C 0 y Y J E O E '-Co M C E 0 n AP form- APCD-2u7-PmduLedWalerl ank-APEN Jou (21 112, O 2 a Boiler APEN - Form APCD-220 Air Pollutant Emission Notice (APEN) and Application for Construction Permit All sections of this APEN and application must be completed for both new and existing facilities, including APEN updates. An application with missing information may be determined incomplete and may be returned or result in longer application processing times. You may be charged an additional APEN fee if the APEN is filled out incorrectly or is missing information and requires re -submittal. This APEN is to be used for boilers, hot oil heaters, process heaters, and similar equipment. If your emission unit does not fall into one of these categories, there may be a more specific APEN for your source (e.g. paint booths, mining operations, engines, etc.). In addition, the General APEN (Form APCD-200) is available if the specialty APEN options will not satisfy your reporting needs. A list of all available APEN forms can be found on the Air Pollution Control Division (APCD) website at: www.colorado.gov/cdphe/apcd. Do not complete this form for the following source categories: - Heaters or boilers with a design capacity less than or equal to 5 MMBtu/hour that are fueled solely by natural gas or liquid petroleum gas (LPG). Heaters or boilers with a design capacity less than or equal to 10 MMBtu/hour used solely for heating buildings for personal comfort that is fueled solely by natural gas or liquid petroleum gas (LPG). More information can be found in the APEN exempt/permit exempt checklist: fifths,/ /www.colorado.coy/pacific/cdphe/apen-or-air-permit-exemptions. This emission notice is valid for five (5) years. Submission of a revised APEN is required 30 days prior to expiration of the five-year term, or when a reportable change is made (significant emissions increase, increase production, new equipment, change in fuel type, etc). See Regulation No. 3, Part A, II.C. for revised APEN requirements. Permit Number: sac S/ZJ /(G ( E¢F>CI,X� AIRS ID Number: [Leave blank unless APCD has already assigned a permit A and AIRS ID] Section 1 - Administrative Information Company Name': Saddle Butte Storage & Terminals, LLC Site Name: Lucerne Crude Oil Terminal Site Location: NW/SW Sec 26 T6N R65W Mailing Address: (Include Zip Code) 858 Main Avenue, Suite 301 Durango, CO 81301 E -Mail Address: TMiller@sbpipeline.com Site Location County: Weld NAICS or SIC Code: 1311 Permit Contact: Trent Miller Phone Number: 303-446-7532 'Please use the full, legal company name registered with the Colorado Secretary of State. This is the company name that will appear on all documents issued by the APCD. Any changes will require additional paperwork. 342965 Permit Number: AIRS ID Number: [Leave blank unless APCD has already assigned a permit € and AIRS ID] Section 2- Requested Action NEW permit OR newly -reported emission source -OR - ❑ MODIFICATION to existing permit (check each box below that applies) { ❑ Change fuel or equipment ❑ Change permit limit ❑ Change company name ❑ Transfer of ownership -OR - ❑ Add point to existing permit ❑ Other (describe below) ❑ APEN submittal for update only (Please note blank APENs will not be accepted) - ADDITIONAL PERMIT ACTIONS - ❑ Limit Hazardous Air Pollutants (HAPs) with a federally -enforceable limit on Potential To Emit (PTE) ❑ APEN submittal for permit exempt/grandfathered source Additional Info a Notes: Heaters are APEN Required/Permit Exempt because they are natural gas fired and have a heat input of 10 MMBtu/hr each 2 For transfer of ownership, a completed Transfer of Ownership Certification Form (Form APCD-104) must be submitted. Section 3 - General Boiler Information General description of equipment and purpose: Two (2) Natural Gas Fired Heater Treater for Oil Polishing Manufacturer: TBD Model No.: TBD Serial No.: TBD Company equipment Identification No. (optional): For existing sources, operation began on: For new, modified, or reconstructed sources, the projected start-up date is: 3/1/2016 ❑ Check this box if operating hours are 8,760 hours per year; if fewer, fill out the fields below: Normal Hours of Source Operation: hours/day Seasonal use percentage: Dec -Feb: Mar -May: days/week weeks/year June -Aug: Sept -Nov: Are you reporting multiple identical boilers on this APEN? EYes No If yes, please describe how the fuel usage will be measured for each boiler (i.e., one meter for all boilers or separate meters for each unit): Each heater is assumed to operate 8,760 hours at their maximum heat input rate. Form APCD-220 - Boiler APEN - Revision 8/2015 2 I®Y COLORADO aloe nn.n.r.n Permit Number: AIRS ID Number: [Leave blank unless APCD has already assigned a permit A and AIRS 101 Section 4 - Stack Information Geographical Coordinates (Latitude/Longitude or UTM) JFLl O erat S0St&tr1tT! a ietght i d Cevel! i xwN"s a �`�4�t� F'.. t i:;". t a"�'y Tm"�� "v`� t�prt FJ., Li-+ z(�,r}.` Fa.4+I. t q"Enu b =w3§ &c•it 'Y"f,,k +u'{ HT1 & HT2 TBD 500 26,974 max TBD Indicate the direction of the stack outlet: (check one) E Upward ❑ Horizontal ❑ Downward ❑ Other (describe): Indicate the stack opening and size: (check one) ❑ Circular ❑ Square/rectangle ❑ Other (describe): Interior stack diameter (inches): Interior stack width (inches): ❑ Upward with obstructing raincap TBD Interior stack depth (inches): Section 5 - Fuel Consumption Information Design Input Rate (MMBTU/hr) Actual Annual Fuel Use3 (Specify Units) Requested Annual Permit Limit° (Specify Units) 10 each N/A 35 MMscf/yr each From what year is the actual annual fuel use data? Fuel consumption values entered above are for: E Each Boiler ❑ All Boilers ❑ N/A Indicate the type(s) of fuel useds: ❑ Pipeline Natural Gas (assumed fuel heating value of 1,020 BTU/SCF) ❑� Field Natural Gas Heating value: 2500 BTU/SCF ❑ Ultra Low Sulfur Diesel (assumed fuel heating value of 138,000 BTU/gallon) ❑ Propane (assumed fuel heating value of 2,300 BTUISCF) ❑ Coal Heating value: BTU/lb Ash Content: Sulfur Content: ❑ Other (describe): Heating value (give units): 'If you are reporting multiple identical boilers on one APEN, be sure to clarify if the values in this section are on an individual boiler basis, or if the values represent total fuel usage for multiple boilers. °Requested values will become permit limitations. Requested limit(s) should consider future process growth. 51f fuel heating value is different than the listed assumed value, please provide this information in the "Other" field. Form APCD-220 - Boiler APEN - Revision 8/2015 3 ®� COLORADO Permit Number: AIRS ID Number: [Leave blank sinless APCD has already assigned a permit P and AIRS ID] Section 6- Criteria Pollutant Emissions Information Attach all emission calculations and emission factor documentation to this APEN form. Is any emission control equipment or practice used to reduce emissions? ❑ Yes ❑r No If yes, please describe the control equipment AND state the overall control efficiency (% reduction): Pollutant Control Equipment Description Overall Control Efficiency (% reduction in emissions) TSP (PM) PMto PM25 SO„ NO„ CO VOC Other: From what year is the following reported actual annual emissions data? Use the following table to report the criteria pollutant emissions from source: (Use the data reported in Section 5 to calculate these emissions.) Pollutant Uncontrolled Emission (Specify Units) Factor Source (AP -42, Mfg. etc) �'Actuat'Annual Emissions '-, a.�a x F .� ,s� ;: sm.. equestedAnnual Permit >:', t -A- s �, . , :,,. �.�,.r.. Emission Limrt(s) ` 'rFactor Uncontrolled (Tons/year) Controlled° (Tons/year) Uncontrolled (Tons/year) Controlled (Tons/year) TSP (PM) 7.6 Ib/MMscf AP -42 0.27 PM10 7.6 Ib/MMscf AP -42 0.27 PM2,5 7.6 Ib/MMscf AP -42 0.27 SO„ 0.6 Ib/MMscf AP -42 0.00 NO„ 100.0 Ib/MMsc AP -42 3.50 CO 84.0Ib/MMscf AP -42 2.94 VOC 5.5Ib/MMscf AP -42 0.19 Other: ° Requested values wit become permit limitations. Requested limits) should consider future process growth. 6Annual emission fees will be based on actual controlled emissions reported. If source has not yet started operating, leave blank. Form APCD-220 - Boiler APEN Revision 8/2015 ®y F... Da Permit Number: AIRS ID Number: [Leave blank unless APCD has already assigned a permit d and AIRS ID] Section 7 - Non -Criteria Pollutant Emissions Information Does the emissions source have any uncontrolled actual emissions of non -criteria pollutants (e.g. HAP- hazardous air pollutant) equal to or greater than 250 lbs/year? 0 Yes ❑✓ No If yes, use the following table to report the non -criteria pollutant (HAP) emissions from source: CAS Number Chemical Name Overall Control Efficiency Uncontrolled Emission Factor (specify units) Emission Factor Source (AP -42, Mfg. etc) Uncontrolled Actual Emissions (lbs/year) Controlled Actual Emissions` (Ibs/year) °Annual emission fees will be based on actual controlled emissions reported. If source has not yet started operating, leave blank. Section 8 - Applicant Certification I hereby certify that all information contained herein and information submitted with this application is complete, true and correct. l Signatur,4'of Legally Authorized Person (not a vendor or consultant) Ryan Cheese Name (please print) IRJ)S Date Vice President of Operations Title Check the appropriate box if you want: ❑ Copy of the Preliminary Analysis conducted by the Division ❑ Draft permit prior to public notice ❑ Draft of the permit prior to issuance (Checking any of these boxes may result in an increased fee and/or processing time) This notice is valid for five (5) years unless a significant change is made, such as an increased production, new equipment, change in fuel type, etc. A revised APEN shall be filed no less than 30 days prior to the expiration date of this APEN form. Send this form along with 5152.90 to: Colorado Department of Public Health and Environment Air Pollution Control Division APCD-SS-B1 4300 Cherry Creek Drive South Denver, CO 80246-1530 Telephone: (303) 692-3150 Form APCD-220 - Boiler APEN - Revision 8/2015 For more information or assistance call: Small Business Assistance Program (303) 692-3175 or (303) 692-3148 Or visit the APCD website at: https://www.colorado.pov/cdphe/apcd ®CVSI W COLORADO 5 .agle:.XI.. Hello