HomeMy WebLinkAbout20161815.tiffCOLORADO
Department of Public
Health & Environment
Dedicated to protecting and improving the health and environment of the people of Colorado
Weld County - Clerk to the Board
1150 0 St
PO Box 758
Greeley, CO 80632
June 8, 2016
Dear Sir or Madam:
RECEIVED
JUN 13 2016
WELD COUNTY
COMMISSIONERS
On June 15, 2016, the Air Pollution Control Division will begin a 30 -day public notice period for PDC
Energy Inc. - Peschel Sec. 20 Pad. A copy of this public notice and the public comment packet are
enclosed.
Thank you for assisting the Division by posting a copy of this public comment packet in your office.
Public copies of these documents are required by Colorado Air Quality Control Commission
regulations. The packet must be available for public inspection for a period of thirty (30) days from
the beginning of the public notice period. Please send any comment regarding this public notice to
the address below.
Colorado Dept. of Public Health Et Environment
APCD-SS-B1
4300 Cherry Creek Drive South
Denver, Colorado 80246-1530
Attention: Clara Gonzales
Regards,
Clara Gonzales
Public Notice Coordinator
Stationary Sources Program
Air Pollution Control Division
Enclosure
2016-1815
4300 Cherry Creek Drive S., Denver, CO 80246-1530 P 303-692-2000 www.colorado.gov/cdpl—
John W. Hickenlooper, Governor Larry Wolk, MD, MSPH, Executive Director and Chief Medical Officer
?i,d9;e., .I.Al4n.J C,C. = PL , (3(A -J, 1 -AL
�'ai -/o -- -1_O
Air Pollution Control Division
Notice of a Proposed Project or Activity Warranting Public
Comment
Website Title: PDC Energy Inc. - Peschel Sec. 20 Pad - Weld County
Notice Period Begins: June 15, 2016
Notice is hereby given that an application for a proposed project or activity has been submitted to the
Colorado Air Pollution Control Division for the following source of air pollution:
Applicant: PDC Energy Inc.
Facility: Peschel Sec. 20 Pad
Oil and gas production facility
SWSW SEC 20 T4N R65W
Weld County
The proposed project or activity is as follows: Applicant will operate loadout of hydrocarbon liquids to
tanker trucks for transportation off -site. Emissions from displaced vapors in tanker trucks are emitted to the
atmosphere.
The Division has determined that this permitting action is subject to public comment per Colorado
Regulation No. 3, Part B, Section III.C due to the following reason(s):
• permitted emissions exceed public notice threshold values in Regulation No. 3, Part B, Section
III.C.1.a (25 tpy in a non -attainment area and/or 50 tpy in an attainment area)
The Division has made a preliminary determination of approval of the application.
A copy of the application, the Division's analysis, and a draft of Construction Permit 16WE0581 have been
filed with the Weld County Clerk's office. A copy of the draft permit and the Division's analysis are
available on the Division's website at https://www.colorado.gov/pacific/cdphe/air-permit-public-notices
The Division hereby solicits submission of public comment from any interested person concerning the ability
of the proposed project or activity to comply with the applicable standards and regulations of the
Commission. The Division will receive and consider written public comments for thirty calendar days after
the date of this Notice. Any such comment must be submitted in writing to the following addressee:
Bradley Eades
Colorado Department of Public Health and Environment
4300 Cherry Creek Drive South, APCD-SS-B1
Denver, Colorado 80246-1530
cdphe.commentsapcd@state.co.us
STATE OF COLORADO
LORADO D PStRT N F PUB IC HEALTH AND ENVIRONMENT
Vr
AIR POLLUTION CONTROL DIVISION
TELEPHONE: (303) 692-3150
CONSTRUCTION PERMIT
PERMIT NO:
DATE ISSUED:
ISSUED TO:
16WE0581
PDC Energy, Inc.
Issuance 1
THE SOURCE TO WHICH THIS PERMIT APPLIES IS DESCRIBED AND LOCATED AS FOLLOWS:
Oil and gas exploration and production facility known as the Peschel Sec. 20 Pad
located in the SWSW Section 20, Township 4N, Range 65W, Weld County, Colorado.
THE SPECIFIC EQUIPMENT OR ACTIVITY SUBJECT TO THIS PERMIT INCLUDES THE FOLLOWING:
Facility
Equipment
ID
AIRS
Point
Description
LOAD -1
002
Truck loadout of condensate. Emissions from the loadout are not
controlled.
THIS PERMIT IS GRANTED SUBJECT TO ALL RULES AND REGULATIONS OF THE COLORADO
AIR QUALITY CONTROL COMMISSION AND THE COLORADO AIR POLLUTION PREVENTION AND
CONTROL ACT C.R.S. (25-7-101 et seq), TO THOSE GENERAL TERMS AND CONDITIONS
INCLUDED IN THIS DOCUMENT AND THE FOLLOWING SPECIFIC TERMS AND CONDITIONS:
REQUIREMENTS TO SELF -CERTIFY FOR FINAL AUTHORIZATION
1. Within one hundred and eighty days (180) after commencement of operation or issuance
of this permit, whichever comes later, compliance with the conditions contained in this
permit shall be demonstrated to the Division. It is the owner or operator's responsibility to
self -certify compliance with the conditions. Failure to demonstrate compliance within 180
days may result in revocation of the permit. (Reference: Regulation No. 3, Part B,
III.G.2).
2. This permit shall expire if the owner or operator of the source for which this permit was
issued: (i) does not commence construction/modification or operation of this source
within 18 months after either, the date of issuance of this construction permit or the date
on which such construction or activity was scheduled to commence as set forth in the
permit application associated with this permit; (ii) discontinues construction for a period
of eighteen months or more; (iii) does not complete construction within a reasonable
time of the estimated completion date. The Division may grant extensions of the
deadline per Regulation No. 3, Part B, III.F.4.b. (Reference: Regulation No. 3, Part B,
III.F.4.)
AIRS ID: 123/4248 Page 1 of 7
Health and Environment
it Pollution Control Division
3. The operator PI .. I i EP .ame ,>-,ting mpling as required in this
permit and submit the results to the Division as part of the self -certification process.
(Reference: Regulation No. 3, Part B, Section III.E.)
4. The operator shall retain the permit final authorization letter issued by the Division, after
completion of self -certification, with the most current construction permit. This
construction permit alone does not provide final authority for the operation of this source.
EMISSION LIMITATIONS AND RECORDS
5. Emissions of air pollutants shall not exceed the following limitations (as calculated in the
Division's preliminary analysis). (Reference: Regulation No. 3, Part B, Section II.A.4)
Annual Limits:
Facility
Equipment ID
AIRS
Point
Tons per Year
Emission Type
NO x
VOC
CO
LOAD -1
002
---
42.3
---
Point
See "Notes to Permit Holder" for information on emission factors and methods used to calculate
limits.
Compliance with the annual limits shall be determined by recording the facility's annual
criteria pollutant emissions, (including all HAPs above the de-minimis reporting level)
from each emission unit, on a rolling twelve (12) month total. By the end of each month
a new twelve-month total shall be calculated based on the previous twelve months' data.
The permit holder shall calculate emissions each month and keep a compliance record
on site or at a local field office with site responsibility, for Division review. This rolling
twelve-month total shall apply to all permitted emission units, requiring an APEN, at this
facility.
PROCESS LIMITATIONS AND RECORDS
6. This source shall be limited to the following maximum processing rates as listed below.
Monthly records of the actual processing rates shall be maintained by the owner or
operator and made available to the Division for inspection upon request. (Reference:
Regulation 3, Part B, II.A.4)
Process/Consumption Limits
Facility
Equipment
ID
AIRS
Point
Process Parameter
Annual Limit
LOAD -1
002
Condensate Loaded
355,000 BBL
Compliance with the annual throughput limits shall be determined on a rolling twelve (12)
month total. By the end of each month a new twelve-month total is calculated based on
the previous twelve months' data. The permit holder shall calculate throughput each
month and keep a compliance record on site or at a local field office with site
responsibility, for Division review.
STATE AND FEDERAL REGULATORY REQUIREMENTS
7. Visible emissions shall not exceed twenty percent (20%) opacity during normal operation
of the source. During periods of startup, process modification, or adjustment of control
AIRS ID: 123/4248
Page 2 of 7
Health and Environment
it Pollution Control Division
equipment visitge-nAsicash x opacit los more than six minutes in
any sixty consecutive minutes. Emission control devices subject to Regulation 7,
Sections XII.C.1.d or XVII.B.2.b shall have no visible emissions. (Reference: Regulation
No. 1, Section II.A.1. & 4.)
8. This source is subject to the odor requirements of Regulation No. 2. (State only
enforceable)
9. This source is located in an ozone non -attainment or attainment -maintenance area and
is subject to the Reasonably Available Control Technology (RACT) requirements of
Regulation Number 3, Part B, III.D.2.a. Condensate loading to truck tanks shall be
conducted by submerged fill. (Reference: Regulation 3, Part B, III.E)
10. The owner or operator shall follow loading procedures that minimize the leakage of
VOCs to the atmosphere including, but not limited to (Reference: Regulation 3, Part B,
III.E):
a. Hoses, couplings, and valves shall be maintained to prevent dripping, leaking, or
other liquid or vapor loss during loading and unloading.
b. All compartment hatches (including thief hatches) shall be closed and latched at
all times when loading operations are not active, except for periods of
maintenance, gauging, or safety of personnel and equipment.
c. The owner or operator shall inspect loading equipment and operations on site at
the time of the inspection to ensure compliance with the conditions (a) and (b)
above. The inspections shall occur at least monthly. Each inspection shall be
documented in a log available to the Division on request.
11. All hydrocarbon liquid loading operations, regardless of size, shall be designed, operated
and maintained so as to minimize leakage of volatile organic compounds to the
atmosphere to the maximum extent practicable.
OPERATING & MAINTENANCE REQUIREMENTS
12. This source is not required to follow a Division -approved operating and maintenance
plan.
COMPLIANCE TESTING AND SAMPLING
13. This source is not required to follow a Division -approved operating and maintenance
plan.
ADDITIONAL REQUIREMENTS
14. A revised Air Pollutant Emission Notice (APEN) shall be filed: (Reference: Regulation
No. 3, Part A, II.C)
a. Annually by April 30th whenever a significant increase in emissions occurs as
follows:
For any criteria pollutant:
For sources emitting less than 100 tons per year, a change in actual emissions
of five (5) tons per year or more, above the level reported on the last APEN; or
AIRS ID: 123/4248 Page 3 of 7
i Health and Environment
r Pollution Control Division
For v• "'""'""`a `. s (;: ,..-,-,s;. nitr :.;a oxides sources (NO„) in
ozone nonattainment areas emitting less than 100 tons of VOC or NO, per
year, a change in annual actual emissions of one (1) ton per year or more or five
percent, whichever is greater, above the level reported on the last APEN; or
For sources emitting 100 tons per year or more, a change in actual emissions
of five percent or 50 tons per year or more, whichever is less, above the level
reported on the last APEN submitted; or
For any non -criteria reportable pollutant:
If the emissions increase by 50% or five (5) tons per year, whichever is less,
above the level reported on the last APEN submitted to the Division.
b. Whenever there is a change in the owner or operator of any facility, process, or
activity; or
c. Whenever new control equipment is installed, or whenever a different type of
control equipment replaces an existing type of control equipment; or
d. Whenever a permit limitation must be modified; or
e. No later than 30 days before the existing APEN expires.
15. Federal regulatory program requirements (i.e. PSD, NANSR or Title V Operating Permit)
shall apply to this source at any such time that this source becomes major solely by
virtue of a relaxation in any permit condition. Any relaxation that increases the potential
to emit above the applicable Federal program threshold will require a full review of the
source as though construction had not yet commenced on the source. The source shall
not exceed the Federal program threshold until a permit is granted. (Regulation No. 3
Part D).
GENERAL TERMS AND CONDITIONS
16. This permit and any attachments must be retained and made available for inspection
upon request. The permit may be reissued to a new owner by the APCD as provided in
AQCC Regulation No. 3, Part B, Section II.E3 upon a request for transfer of ownership
and the submittal of a revised APEN and the required fee.
17. If this permit specifically states that final authorization has been granted, then the
remainder of this condition is not applicable. Otherwise, the issuance of this construction
permit does not provide "final" authority for this activity or operation of this source. Final
authorization of the permit must be secured from the APCD in writing in accordance with
the provisions of 25-7-114.5(12)(a) C.R.S. and AQCC Regulation No. 3, Part B, Section
III.G. Final authorization cannot be granted until the operation or activity commences
and has been verified by the APCD as conforming in all respects with the conditions of
the permit. Once self -certification of all points has been reviewed and approved by the
Division, it will provide written documentation of such final authorization. Details for
obtaining final authorization to operate are located in the Requirements to Self -
Certify for Final Authorization section of this permit.
18. This permit is issued in reliance upon the accuracy and completeness of information
supplied by the owner or operator and is conditioned upon conduct of the activity, or
construction, installation and operation of the source, in accordance with this information
and with representations made by the owner or operator or owner or operator's agents.
AIRS ID: 123/4248 Page 4 of 7
Health and Environment
it Pollution Control Division
It is valid onl ege�9 Apr-5rt• �o activ ecifically identified on the
permit.
19. Unless specifically stated otherwise, the general and specific conditions contained in this
permit have been determined by the APCD to be necessary to assure compliance with
the provisions of Section 25-7-114.5(7)(a), C.R.S.
20. Each and every condition of this permit is a material part hereof and is not severable.
Any challenge to or appeal of a condition hereof shall constitute a rejection of the entire
permit and upon such occurrence, this permit shall be deemed denied ab initio. This
permit may be revoked at any time prior to self -certification and final authorization by the
Air Pollution Control Division (APCD) on grounds set forth in the Colorado Air Quality
Control Act and regulations of the Air Quality Control Commission (AQCC), including
failure to meet any express term or condition of the permit. If the Division denies a
permit, conditions imposed upon a permit are contested by the owner or operator, or the
Division revokes a permit, the owner or operator of a source may request a hearing
before the AQCC for review of the Division's action.
21. Section 25-7-114.7(2)(a), C.R.S. requires that all sources required to file an Air Pollution
Emission Notice (APEN) must pay an annual fee to cover the costs of inspections and
administration. If a source or activity is to be discontinued, the owner must notify the
Division in writing requesting a cancellation of the permit. Upon notification, annual fee
billing will terminate.
22. Violation of the terms of a permit or of the provisions of the Colorado Air Pollution
Prevention and Control Act or the regulations of the AQCC may result in administrative,
civil or criminal enforcement actions under Sections 25-7-115 (enforcement), -121
(injunctions), -122 (civil penalties), -122.1 (criminal penalties), C.R.S.
By:
Bradley Eades
Permit Engineer
Permit Histo
Issuance
Date
Description
Issuance 1
This Issuance
Issued to PDC Energy, Inc.
AIRS ID: 123/4248
Page 5 of 7
olor 4:Depa en
Notes to Permit Holder " '"me o .e'"" "`"" a
1) The permit holder is required to pay fees for the processing time for this permit. An invoice for these
fees will be issued after the permit is issued. The permit holder shall pay the invoice within 30 days of
receipt of the invoice. Failure to pay the invoice will result in revocation of this permit (Reference:
Regulation No. 3, Part A, Section VI.B.)
Health and Environment
it Pollution Control Division
2) The production or raw material processing limits and emission limits contained in this permit are
based on the consumption rates requested in the permit application. These limits may be revised
upon request of the owner or operator providing there is no exceedance of any specific emission
control regulation or any ambient air quality standard. A revised air pollution emission notice (APEN)
and complete application form must be submitted with a request for a permit revision.
3) This source is subject to the Common Provisions Regulation Part II, Subpart E, Affirmative Defense
Provision for Excess Emissions During Malfunctions. The owner or operator shall notify the Division
of any malfunction condition which causes a violation of any emission limit or limits stated in this
permit as soon as possible, but no later than noon of the next working day, followed by written notice
to the Division addressing all of the criteria set forth in Part II.E.1 of the Common Provisions
Regulation. See: http://www.colorado.gov/cs/Satellite?c=Document C&childpagename=CDPHE-
Main%2FDocument C%2FCBONAddLinkView&cid=1251599389641&pagename=CBONWrapper
4) The following emissions of non -criteria reportable air pollutants are estimated based upon the process
limits as indicated in this permit. This information is listed to inform the operator of the Division's analysis
of the specific compounds emitted if the source(s) operate at the permitted limitations.
AIRS
Point
Pollutant
CAS #
Uncontrolled
Emission
Rate
(Ib/yr)
Are the
emissions
reportable?
Controlled
Emission Rate
(Ib/yr)
002
Benzene
71432
266
Yes
266
n -Hexane
110543
2387
Yes
2387
Toluene
108883
350
Yes
350
5) The emission levels contained in this permit are based on the following emission factors:
Point 002:
Pollutant
Emission Factors
Uncontrolled
lb/BBL loaded
-
Source
VOC
0.2383
AP -42
Benzene
0.0007
AP -42
n -Hexane
0.0056
AP -42
Toluene
0.0010
AP -42
The uncontrolled VOC emission factor was calculated using AP -42, Chapter 5.2, Equation 1
(version 1/95) using the following values:
L = 12.46*S*P*M/T
S = 0.6 (Submerged loading: dedicated normal service)
P (true vapor pressure) = 7.32 psia
M (vapor molecular weight) = 53.53 Ib/Ib-mol
AIRS ID: 123/4248
Page 6 of 7
lir,olorallaDepa
T (tempat0tr�o,of li �pa1;~�� 16.v;
lic Health and Environment
it Pollution Control Division
The uncontrolled non -criteria reportable air pollutant (NCRP) emission factors were calculated by
multiplying the estimated mass fraction of each NCRP in the vapors by the VOC emission factor.
6) In accordance with C.R.S. 25-7-114.1, each Air Pollutant Emission Notice (APEN) associated with
this permit is valid for a term of five years from the date it was received by the Division. A revised
APEN shall be submitted no later than 30 days before the five-year term expires. Please refer to the
most recent annual fee invoice to determine the APEN expiration date for each emissions point
associated with this permit. For any questions regarding a specific expiration date call the Division at
(303)-692-3150.
7) This facility is classified as follows:
Applicable
Requirement
Status
Operating Permit
Synthetic Minor Source of:
VOC
NANSR
Synthetic Minor/Major Source of:
VOC
MACT HH
Major Source Requirements: Not Applicable
Area Source Requirements: Not Applicable
8) Full text of the Title 40, Protection of Environment Electronic Code of Federal Regulations can be
found at the website listed below:
http://ecfr. gpoaccess. q ov/
Part 60: Standards of Performance for New Stationary Sources
NSPS
60.1 -End
Subpart A — Subpart KKKK
NSPS
Part 60, Appendixes
Appendix A — Appendix I
Part 63: National Emission Standards for Hazardous Air Pollutants for Source Categories
MACT
63.1-63.599
Subpart A — Subpart Z
MACT
63.600-63.1199
Subpart AA — Subpart DDD
MACT
63.1200-63.1439
Subpart EEE — Subpart PPP
MACT
63.1440-63.6175
Subpart QQQ — Subpart YYYY
MACT
63.6580-63.8830
Subpart ZZZZ — Subpart MMMMM
MACT
63.8980 -End
Subpart NNNNN — Subpart XXXXXX
9) A self certification form and guidance on how to self -certify compliance as required by this permit may
be obtained online at: http://www.colorado.gov/pacific/cdphe/air-permit-self-certification
AIRS ID: 123/4248
Page 7 of 7
Colorado Air Permitting Project
Version No. 1.00
Project Details
Review Engineer:
Package #:
Received Date:
Review Start Date:
Section 01- Facility Information
Bradley Eades
345966
3/29/2016
6/3/2016
Company Name:
County AIRS ID:
Plant AIRS ID:
Facility Name:
Physical Address/Location:
Type of Facility:
What industry segment?
Is this facility located in a NAAQS non -attainment area? Yes
If yes, for what pollutant? ['Carbon Monoxide (CO) ❑ Particulate Matter (PM)
PDC Energy Inc.
123
4248
Peschel Sec 20 Pad
SWSW Sec 20 T4N R65W
Exploration & Production Well Pad
Oil & Natural Gas Production & Processing
Section 02 - Emissions Units In Permit Application
(] Ozone (NOx & VOC)
AIRS Point #
Emissions Source Type
Emissions
Control?
Permit N
Issuance tt
Self Cert
Required?
Action
Engineering Remarks
002
Hydrocarbon Liquid Loading
No
151/VE0581
1
Yes
Permit Initial
Issuance
Section 03 - Description of Project
This facilty was recently modified to receive production from nine (9} newly -drilled wells. Concurrently with this permit service, PDC is requesting
updates to GP01 to update througput and new GP02 registrations for engines to be used for gas compression. This permit is for condensate loadout,
which is uncontrolled.
Section 04 - Public Comment Requirments
Is Public Comment Required? Yes
If yes, why?' Greater than 25 tons per year in Non -Attainment Area
Section 05 - Ambient Air Impact Analysis Requirements
Was a quantitative modeling analysis required?2 No
If yes, for what pollutants?
If yes, attach a copy of Technical Services Unit modeling results summary.
Section 06 - Facility -Wide Stationary Source Classification
Is this stationary source a true minor'
Is this stationary source a synthetic minor?
If yes, explain what programs and which pollutants here:
Prevention of Significant Deterioration (PSD): NA
Title V Operating Permits (OP) : VOC
Non -Attainment New Source Review (NANSR): VOC
Is this stationary source a major source?
If yes, explain what programs and which pollutants here:
Prevention of Significant Deterioration (PSD): NA
Title V Operating Permits (OP) : NA
Non -Attainment New Source Review (NANSR): NA
No
Yes
No
Section 01- Adminstrative Information
Facility AIRs ID: in
County
4248 002
Plant Point
Section 02 - Equipment Description Details
Detailed
Emissions Unit
Description:
Loadout of hydrocarbon liquid to tank trucks.
Emission Control Ho. Control
Device
Description:
Control Efficiency %:
Section 02 - Emissions Inventory Analysis
AP -42: Chapter 5.2
Equation 1
L = 12.46'SP'M/T
L = loading losses in lb per 1000 gallons loaded
S = Saturation Factor
P = true vapor pressure of liquid loaded [pia]
M = molecular weight of vapors Ilb/Ib-mole]
T = temperature of bulk liquid loaded [deg. RI
1 degree Fahrenheit = 460.67 degree Rankine
Criteria Pollutants
Variables
S
P
M
0.6 Submerged loading: dedicated normal service
7.32 psia
53.53 lb/lb-mole
T 516.461 deg. R
L
5.67
2.38E-01
Annual requested Throughput
Annual requested VOC emissions
lb/10A3 gal
lb/bbl
355,000 bbVyr
4.910,000 Gallons per Year
4.57 Pounds per Year
422 Tons VOC per Year
Non -Criteria Reportable Air Pollutants/Hazardous Air Pollutants
lb VOC/lb Gas 1
Mass Ratio Uncontrolled
(pounds Emission Emissions Are Emissions
Com onent HAP/ ound VOC Factor lb/bbl lb Reportable?
Benzene 0.315% 0.00075 265.98 Yes
n -hexane 2.822% 0.0067 2386.93 Yes
Toluene 0.414% 0.0010 350.43 Yes
Ethylbenzene 0.004% 0.0000 2.97 No
Xylenes 0.095% 0.0002 81.33 No
2,2,4-TMP 0.068% 0.0002 57.82 No
Section 03 - Regulatory Considerations
Is this site considered an exploration and production location (e.g. well pad)? Yes
If yes, review the following two exemptions for applicability:
Does the operator unload less than 10,000 gallons (238 BBLs) of crude oil per day on an annual average basis?
If yes, this emissions point is categorically exempt from permit requirements per Regulation 3, Part B, Section 11,O.1.I
Does this operator unload less than 6,750 bbls per year of condensate via splash fill or
16,308 bbls per year of condensate via submerged fill procedure? No
If yes, this emissions point is categorically exempt from permit requirements per Regulation 3, Part B, Section II.D.1.1
Is this site located in an ozone non -attainment area? Yes
If yes, this source is subject to Reasonably Available Control Technology (RACT) requirements under Regulation 3, Part B
Section III.D.2.a. This requirement may be met using "submerged fill" and/or vapor balance with emissions routed to an
emissions control device.
Is this facility classified as a major source of HAPs? No
If yes, evaluate if 40 CFR. Part 63, Subpart EEEE "Organic Liquids Distribution" MACT provisions apply
Does this facility involve the loading of refined crude/condensate in the form of "gasoline"?
If yes, proceed to evaluate the following:
Is this facility classified as a "Terminal" as defined per Regulation 7, Section VI.C.2.a?
If yes, the provisions of Regulation 7, Section VI.C.2 may apply
No
Is this facility classified as a "Bulk Plant" as defined per Regulation 7, Section VI.C.3.a? No
If yes, the provisions of Regulation 7, Section VI.C.3 may apply
No
Technical Analysis Notes:
"Emissions calculated for HAPs are more conservative than when calculated using the W&B composition and 1.00% VOC, therefore the
generic compositional values used by applicant are being used to calculate HAP emissions (as represented in the table above.
'A copy of the NOS was submitted via email on 6/8/16 and PDC requested removal of condition I requiring NOS be submitted within 15
days os permit issuance. Requirement I was removed and a copy of the NOS was placed in package.
Section 04 - SCC Coding
Emissions Factor
Pollutant (lb/1,000 gallons)
VOC 5.67 lb/1.000 gallons
Benzene 0.02 lb/1,000 gallons
n -hexane 0.16 lb/1,000 gallons
Toluene 0.02 Ib/1, 000 gallons
40600132: Crude Oil: Submerged Loading (Normal Service) Use d S = 0.6
40600137' Crude Oil: Splash loading (normal Service) Use if S = 1 45
40600142: Crude Oil: Submerged Loading (balanced Service) Use if S = 1.00
40600145. Crude Oil: Splash loading (Balanced Service) Use S = 1.00 and splash loading
40600148: Crude Oil: Submerged Loading (Clean tanks) Use if S = 0.5
Please select one SCC codes above based on the design and operation of your site. For these codes"Crude
Oil" is a generic term that includes both condensate and crude oils. Delete SCC codes not used.
No
COLORADO DEPARTMENT OF PUBLIC HEALTH AND ENVIRONMENT
AIR POWmON CONTROL DIVISION
FACILITY EMISSION SUMMARY
Company Name
County AIRS ID
Plant AIRS ID
Facility Name
P00 Enerm. Inc
113
4218
Pe0MI Sec 30 Pad
History File Edit Date
Ozone Status
8012118
No -Attainment
EMISSIONS - Uncontrolled (tons per year)
EMISSIONS nth Controls (tons per year)
POINT
AIRS
0
PERMIT
Description
PM10
PM2.5
H28
SO2
Not
VOL
Fug
VOC
CO
Total
HAP,
PM10
PM35
825
SO2
NOt
VOC
Fog
VOC
CO
Total
HAPs
REMARKS
Premou FACILITY TOTAL
00
00
00
00
00
00
00
00
00
00
00
00
00
00
00
00
00
00
Prem. Penn/lied FacdtyfdaI
00
00
00
00
00
00
00
00
00
00
00
00
00
00
00
00
00
00
001
GP0I
Condensate tanksi¢5006d
3000
T4
1.2
39.0
24
04
002
16WE05R1
Condensateloasout
42.3
t5
423
15
003
GP02
ENG-1 pm vpdec 921hp
118
03
17
0.1
09
04
1]
01
004
GP02
ENG-2amwaist 920e
118
04
17
00
09
08
1]
01
0.0
00
0 0
0a
00
00
00
00
00
00
0.0
00
00
00
00
00
FACILITY TOTAL
0.0
0.0
5.0
0.0
23.8
343.5
00
3.4
90
0.0
00
0.0
0.0
3.0
82.5
0.0
1.8
2.1
VOL) Syn Minor IPSOMANSR and OP)
NO,: Minor (PSDMANSR and OP)
CO: Minor(PS0 and OP)
HAPS: Minor B. T. S. HCHO a Total
HH: Minor a affected Area
MIL Minor
Pumned Fealty Ts el
0.0
00
00
00
236
3435
00
34
90
00
00
00
00
30
825
00
5.8
21
Exclude units exempt from perm4yAPENs
(d)COa ge in Permitted miymns
00
00
00
00
30
825
00
5.8
Pubcom B modeling (not) required based on (0
change emissions)
Nate
Total VOC Feallry Emssors l point and 1+011 el
i3l Chenoe in Total Pe nutted VOC emissions (pa land I Itvel
82.5
Facility is eligde for 0042 because< 50 toy
Propel emissions less than 2640 tM
82.5
PermO 161/VE0581 will go To putllc notice since permitted emissions are 9154101 than 25tuy in a non -attainment area
Note2
Page 4015
Printed 6/8/2016
COLORADO DEPARTMENT OF PUBLIC HEALTH AND ENVIRONMENT
AIR POLLUTION DIVISION
FACILITY EMISSION SUMMARY- HAPs
Company Name PDC Energy, Inc
County AIRS ID 123
Plant AIRS ID 4248
Facility Name Peschel Sec 20 Pad
Emissions - uncontrolled (Ibs per year
POINT PERMIT Description
Formaldehyde
Acetaldehyde
Acrolein
Benzene
Toluene
Etcylbenzene
Xylenes
n -Hexane
McOH
220 -VP
H2S
TOTAL 0PID
Previous FACILITY TOTAL
0
0
0
0
0
0
0
0
0
0
0
0
0.0
C01
GP01
Condensate tanks 19-50Cbbl
1420
1900
17
476
10579
396
7.4
002
16WE0581
Condensate loadout
266
350
2387
1.5
003
GP02
ENG-1 gm vortec 92hp
133
18
7
10
2C
0.I
004
GP02
ENG-2 gm vonec 92hp
0.0
00
0.0
0.0
0.0
0.0
0.0
0.0
0.0
TOTAL Itpyl
0.1
0.0
0.0
0.8
1.1
0.0
0.2
6.5
0.0
0.2
0.0
0.0
90
`Total Reportable = all HAPs where uncontrolled emissions t de minlmus values
Red Texuncontrolled emissions c de minimus
Emissions with controls (Ibs per year
POINT PERMIT
Description
Formaldenyde
Acetaldehyde
Acrolein
Benzene
Toluene
ethylbenzene
Xylenes
n -Hexane
MCOH
224 TMP
H2S
TOTAL (tpy)
Previous FACILITY TOTAL
0
0
0
0
0
0
0
0
0
0
0
0
0.0
001
GP01
Condensate tanks 19-500bbl
71
95
085
23.8
528.95
C
19.8
0.4
002
16WE0581
Condensate loadout
266
350
2387
1.5
003
GP02
ENG-1 qm vonec 92hp I
133
18
17
10
20
0-1
004
GP02
ENG-2 gm vonec 92hp
133
18
17
10
20
0 I
00
0.0
0.0
0.0
00
0.0
0.0
0.0
TOTAL hpy)
0.1
0.0
0.0
0.2
0.2
0.0
0.0
1.5
0.0
0.0
0.0
0.0
2.1
5
16W E0581. CF1.xlsm
5/8/2016
uid Loadin
drocarbon Li
fV
J
CO
CO
N
Permit Number:
Provide Facility Equipment ID to identify how this equipment is referenced within your organization.]
Facility Equipment ID:
nested Action (Check applicable request boxes)
Section 02 — Re
Section 01 — Administrative Information
General Permit GPIl7
Individual Permit
PDC Energy, Inc.
E
C'
F
6
0
V J
d
t aS a
a
N u
h
a '`
° t
Nd
E c z
d ❑
• on 7
R 'J
0 as -
d c ^
L V
T 6-
.7: O
off
E C
z
ww�
Z c�
cc cc u
c c C c u U
d d d
CC L a O
S ❑ ❑ ❑ ❑
SWSW Sec 20 T4N R65W
Source Location
CO
Co)
1775 Sherman Street,
d
2
3r
c
O
U
0
a)
i—
L
E
a
R
C
Cd
Ld
L
9
C'
Cd
CO
0
O
co
d
U
N
Z
L
G
R
V
G
d
C
F
c
cc
E
v7
O
ad.
R
7 9
Cd
J L
Cd
w
0. C
Gd
o
Cd 3
Elizabeth,Duncan@pdce.com
E-mail Address:
Addl. Info. & Notes:
Section 03 — General Information
N
S
d
d
i
'0
r
r
F
e
Normal flours of Source Operation:
CO
0
N
Co
0
Don't know
Don't know
Z Z Z Z Z
ID ID EDE
< < C
O U d
>- ? Y Y 'r
Cd
Cd
n
d
v
'0
F
U
0
v
F • C _
Tar.
• a
≤7.
d d
z
C G
F c o0
O L
< �d
o =
V.
'0 • 3
• C C
o e c
V a a
n 'J O .t^..
F a ..r 0' ^ l
co C 7 - o
F o .d. -
C O d o
S O C <S. .
0 C M c< r.
C
• o -=;'...
5- n Z Fr.'
ecc - -
R' 0 F cc,v ..-. .t C
F. 0 ` - 0 0C
Ln R R O y d C6
_ E
V ^_ 'J V C 7
V V d ..' .d is a
T L
V c - r R n ._
"` . F O d 0 as a ..
n "0 m d F
0 0 - a,
0. -
o
d C = o
1^ • G ` ' L U o. C -- r)
O - = d -
• C N 0 T'v O
h
r
O )
d
`o 7: o
3 a 0 _L U
ale and federal rules.
O
O
O
N
CO
L
O
pU V
0 a Y
3 C
o
'^
d 0
Cie Cd
C u n
Q E
v
L
L A
• U rn
o : U
01 C C
-
E m
o H
• 0
0
❑
R Ln G
a 'rm'
r
O
U
-J O I
O 9
V V b
e E
O Cd
d d
F co
cc c • _ J o
z
w
a
a ^ 0
S V
5 A
'J - ^
C_
L A <
0.1
c c
3
0
CdCD
— ▪ m
d
c t
c
r:
N
-
O
L. —
d
c
U
p.
`
O
z
e
O y a
..
E U
d >
2.,• <
J
Cd
'O
d
cc
L
a0.
V
0 • O
O
cc 0
C'
V_
t
0
d j
LL.
Cd
d U.
Co
CO
`O
Ct
d
n
❑
0
on
7L-3.
re)
F
n
N
C-
True Vapor Pressure:
S
- `
• J
Y
G
E
c
Ez
>
o 'v
K
C C
FORM APCD-208
N
0
d
cn
a
uid Loadin
N
C
O3
N
tvu
5
0
w
0
-J
F
L
C
CO
0
O
R
0
0
cei
E
O
O
C
C)
CO
O
rn
O
CO
0
Ct
N
0
C)
cip
0
✓
m
0
5V
2 o `O
▪ N ry
COGCC Website
4)
CD
M
m
0
-104.69314
op
r>n
❑
u 0
O
>-
y• �
3 U
y¢
E• °
CO
1/• a“
an
O 1 O
�s o
Direction of stack outlet (check one):
Section 08 — Emissions Inventory Information
CZ CC
L L
M
0 0
C) V
CC
CO CO
X X
C) V
X
CO O
cc
p cc
x
—
o
0 0
c
O O
V
N
C
0Z 0
L
R ]]▪ �
i _CO 0
re
YE
O
ON0
O O
0
w U �O0
ii
t R
o
y C b
C
E o i-
U U
R
I
N
03
C
0
O
V)
C
a
OX
0
3
C
e
E
C
R
C
m
R
R
C
R
O
Emission Factor Documentation attached (If using site specific emission factor)
Estimation
Method or
Emission
Factor Source
CIS
O
2'
a
CO
2 O
a
CO
O
a
Please use the APCD Non -Criteria Reportable Air Pollutant Addendum form to report pollutants not listed above.
Requested Permitted
Emissions
Controlled
(Tons/Year)
O
265.98 lb/yr
2386.93 lb/yr
(h
Ni
Uncontrolled
(Tons/Year)
42.30
265.98 lb/yr
2386.93 lb/yr
Actual Calendar Year Emissions5
Controlled
(Tons/Year)
_T
2386.93 lb/yr
O
Cr)
CO
N
0)
-sr
Lri
CD
N
Uncontrolled
(Tons/Year)
O
265.98 lb/yr
2386.93 lb/yr
M
Ni
V
Emission Factor
w
_0
s
a
Uncontrolled Basis
CO
CD
O
O
LI)
CO
Co
N
O
O
O
O
O
Control Efficiency
((VD Reduction)
Identify in Section 07
Control Device Description
Secondary
CO
b
N_
❑
=
0
z
O
>
;,
C0
_
C.
C
R
L
u
R
V
L
✓
C
v pa
E
L
C C
E
C
C
u
C
O
m C
b O
O.
R C
• O
▪ Ca
707 - R
b
3 s
CIS
-J
EHS Professional
Elizabeth Duncan
CJ
Name of Legally Authorized Person (Please print)
O b
C R
R W
C L
b O
L y
�_
tr a
C
R M`
CR
t
M• \.
E • N
▪ L
CO _
d `
Ca C
Z L 0 _ R
O R _
t` y R t CO
V CO
Z N.a 0
0
v
c
CL
0
E)
U
0
N
C)
cL
CO
2
O
z
w
O
0
O
w
U_
z
O
f/)
w
✓
r
J
J
0
0
w
J
CO
0
I-
a.
cL
cL
w
li
U
z
O
z
(\; co -o
N, U
M
N N
I
CD
E
z
N
cn
.7t
c
O
O
Permit Number•
Company Name:
Plant Location:
c0
co
c)
LU
c0
O
r)
Fax Number:
Elizabeth.Duncan@pdce.com
E-mail Address:
Controlled Actual
Emissions
(lbs/year)
350.43
Uncontrolled
Actual Emissions
(lbs/year)
Co
0
u)
M
Emission Factor
Source
ProMax
Emission Factor
(include Units)
0.0010 lb/bbl
-Control: Equipment
/ Reduction (%)
0
Chemical Name -
a)
C
(1)
O
H
1 Chemical Abstract
Service (CAS)
Number
co
Co
co
0
-
r
co
O
N
Calendar Year for which Actual Data Applie
M a)
a)
O
EHS Professional
a)
O
>
Q
Q
Cr)
O
a)
N
O
4
cn
O)
a)
c
O
a) Eaa_c)
m o
c
N
W
Title of Person Legally Authorized to Supply Data
Name of Person Legally Authorized to Supply Data (Please print)
Form Revision Date: A
Hello