HomeMy WebLinkAbout20173076.tiffCOLORADO
Department of Public
Health & Environment
Dedicated to protecting and improving the health and environment of the people of Colorado
Weld County - Clerk to the Board
1150O St
PO Box 758
Greeley, CO 80632
June 30, 2017
Dear Sir or Madam:
RECEIVED
SEP 2 6 2017
WELD COUNTY
COMMISSIONERS
On July 6, 2017, the Air Pollution Control Division will begin a 30 -day public notice period for Kerr-
McGee Oil and Gas Onshore LP - 36146148. A copy of this public notice and the public comment
packet are enclosed.
Thank you for assisting the Division by posting a copy of this public comment packet in your office.
Public copies of these documents are required by Colorado Air Quality Control Commission
regulations. The packet must be available for public inspection for a period of thirty (30) days from
the beginning of the public notice period. Please send any comment regarding this public notice to
the address below.
Colorado Dept. of Public Health Et Environment
APCD-SS-B1
4300 Cherry Creek Drive South
Denver, Colorado 80246-1530
Attention: Clara Gonzales
Regards,
Clara Gonzales
Public Notice Coordinator
Stationary Sources Program
Air Pollution Control Division
Enclosure
Plot is
tot 0/ i 7
4300 Cherry Creek Drive S., Denver, CO 80246-1530 P 303-692-2000 www.colorado.gov/cdphe
John W. Hickenlooper, Governor I Larry Wolk, MD, MSPH, Executive Director and Chief Medical Officer
pct Pictrim tTP),HLC 7T)
PwC £R/ CP.1/3m t cic)
GU'olCo/ t -1
307Q
Air Pollution Control Division
Notice of a Proposed Project or Activity Warranting Public
Comment
Website Title: Kerr-McGee Oil and Gas Onshore LP - 36146148 - Weld County
Notice Period Begins: July 6, 2017
Notice is hereby given that an application for a proposed project or activity has been submitted to the
Colorado Air Pollution Control Division for the following source of air pollution:
Applicant: Kerr-McGee Oil and Gas Onshore LP
Facility: 36146148
Oil Et Gas Well Production Facility
NWNW Section 17 Ti N R67W
Weld County
The proposed project or activity is as follows: This project permits the operation of a vapor recovery tower
at a well production facility. Other (separately permitted) equipment at this facility are condensate storage
tanks, produced water storage tanks, and liquid loadout to trucks.
The Division has determined that this permitting action is subject to public comment per Colorado
Regulation No. 3, Part B, Section III.C due to the following reason(s):
the source is requesting a federally enforceable limit on the potential to emit in order to avoid other
requirements
The Division has made a preliminary determination of approval of the application.
A copy of the application, the Division's analysis, and a draft of Construction Permit 15WE0643 have been
filed with the Weld County Clerk's office. A copy of the draft permit and the Division's analysis are
available on the Division's website at https://www.colorado.gov/pacific/cdphe/air-permit-public-notices
The Division hereby solicits submission of public comment from any interested person concerning the ability
of the proposed project or activity to comply with the applicable standards and regulations of the
Commission. The Division will receive and consider written public comments for thirty calendar days after
the date of this Notice. Any such comment must be submitted in writing to the following addressee:
Andy Gruel
Colorado Department of Public Health and Environment
4300 Cherry Creek Drive South, APCD-SS-B1
Denver, Colorado 80246-1530
cdphe.commentsapcd@state.co.us
ADO
Colorado Air Permitting Project
Project Details
Review Engineer:
Package #:
Received Date:
Review Start Date:
Section 01- Facility Information
Andy Gruel
328882
4/20/2015
5/12/2017
application was delayed at login
Company Name:
County AIRS ID:
Plant AIRS ID:
Facility Name:
Physical Address/Location:
Type of Facility:
What industry segment?
Kerr-McGee Oil and Gas Onshore LP
123
Weld
Quadrant
Section
Township
Range
N"
17
9C8F
36146148
NWNW quadrant of Section 17, Township 1N, Range 67WW, in Weld County, Colorado
I Pad"
I Gas Produ
Is this facility located in a NAAQS non -attainment area?
If yes, for what pollutant? ❑carbon Monoxide (CO)
Section 02 - Emissions Units In Permit Application
articulate Matter (PM) DOzone (NOx & VOC)
AIRS Point #
Emissions Source Type
Equipment
Name
Emissions
Control?
Permit #
Issuance #
Self Cert
Required?
Action
Engineering
Remarks
005
Vapor Recovery Tower(VRT}
VRT-01
Yes
15WE0643
1
Yes -
Permit Initial
-.` . Issuance
Section 03 - Description of Project
Applicant seeks a permit for venting/ flaring of VRT vapors when VRU is not functioning.
Section 04 - Public Comment Requirements
Is Public Comment Required?
If yes, why?
Requesting
Yes
:f[etle Minor Pert
Section 05 - Ambient Air Impact Analysis Requirements
Was a quantitative modeling analysis required?
If yes, for what pollutants?
If yes, attach a copy of Technical Services Unit modeling results summary.
Section 06 - Facility -Wide Stationary Source Classification
Is this stationary source a true minor?
Is this stationary source a synthetic minor?
If yes, indicate programs and which pollutants;
Prevention of Significant Deterioration (PSD)
Title V Operating Permits (OP)
Non -Attainment New Source Review (NANSR)
NO'
Nr
S02 NOx CO VOC PM2.5 PM10 TSP HAPs
❑ ❑ ❑ ❑ ❑ ❑
❑ ❑ ❑ LI ❑ ❑ ❑ ❑
❑ ❑
Is this stationary source a major source? No
If yes, explain what programs and which pollutants here: 5O2 NOx CO VOC PM2.5 PM10 TSP HAPs
Prevention of Significant Deterioration (PSD) O ❑ ❑ O O ❑
Title V Operating Permits (OP) ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑
Non -Attainment New Source Review (NANSR) ❑ ❑
Venting from vapor recovery tower (VfRT)!
005 are controlled by enclosed combustors.
123-9CBF-005 15WE0643
E0643
Equipment Description
This source vents natural gas from:
Emissions from this source are:
vapor recovery tower
routed to a flare
recovery unit (VRU) is .not available..:: Vented vapors
Natural gas venting from vapor recovery tower. Emissions from this source are routed to a flare.
Calculations
Emission Calculation Method
During normal operation of the facility, the VRT gas is routed to a vapor recovery unit which compresses the gas
and sends it to the sales gas gathering pipeline. This VRT emissions point represents emissions during the times
when gas is directed from the VRT to a group of enclosed combustors.
VRT emissions are calculated based on facility liquid throughput, an emission factor developed through E&P Tank v2.0,
and measuring the time that VRT gas is directed to the enclosed combustors
Applicant collected pressurized liquid samples (at separator pressure 10 psi higher than normal operating pressure
to be conservative) and used an arithmetic mean of the pressurized liquid samples as input to E&P Tank v2.0. Applicant
also samples the stabilized liquid to determine API gravity and RVP.
Total facility condensate throughput
Applicant's estimated % of time the VRT will vent to flare (VRU downtime)
Calculated condensate throughput during VRU downtime
E&P Tank modeled emission factors, based on arithmetic mean of samples
VOC
Benzene
Toluene
Ethylbenzene
Xylenes
n -Hexane
224 -TM P
NOx and CO emission factors, based on March 2005 CDPHE memo:
NOx
CO
Overall Control at enclosed combustors:
Emissions Summary Table
Pollutant
Uncontrolled Emission Factor
Controlled Emission Factor
Uncontrolled Emissions
Controlled Emissions
Source
VOC
8.2665
lb/bbl
0.4133 lb/bbl
285.19 tpy
14.26 tpy
Gas Analysis
N0x
0.031
lb/bbl
0.031 lb/bbl
1.06 tpy
1.06 tpy
CDPHE 2005
CO
0.078
lb/bbl
0.078 lb/bbl
2.68 tpy
2.68 tpy
CDPHE 2005
Benzene
0.073
lb/bbl
0.0037 lb/bbl
5037 lb/yr
252 lb/yr
Gas Analysis
Toluene
0.096
lb/bbl
0.0040 lb/bbl
6624 lb/yr
331 lb/yr
Gas Analysis
Ethylbenzene
0.020
lb/bbl
0,0010 lb/bbl
1380 lb/yr
69 lb/yr
Gas Analysis
Xylenes
0,0620
lb/bbl
0.0031 lb/bbl
4278 lb/yr
214 lb/yr
Gas Analysis
n -Hexane
0.3450
lb/bbl
0.0173 lb/bbl
23805 lb/yr
1190 lb/yr
Gas Analysis
2,2,4-TMP
0.061
lb/bbl
0.0030 lb/bbl
4175 lb/yr
209 lb/yr
Gas Analysis
230000 bbl/yr
30%
69000 bbl/yr
8.2665. lb/bbl
0.073 lb/bbl
0.0961'. lb/bbl
0.020 lb/bbl
0.062 lb/bbl
0.345 Ib/bbl
0.0605 Ib/bbl
0.0037 lb NOx / lb VOC
0.0094 lb CO / lb VOC
95%If.
Regulatory Applicability
AQCC Regulation 1
This source is subject to the opacity requirements for flares in Section II.A.5:'No owner or operator of a smokeless flare or other
flare for the combustion of waste gases shall allow or cause emissions into the atmosphere of any air pollutant which is in
excess of 30% opacity.'
AQCC Regulation 2
Section I.A applies to all emission sources. "No person, wherever located, shall cause or allow the emission of odorous air
contaminants from any single source such as to result in detectable odors which are measured in excess of the following limits:
For areas used predominantly for residential or commercial purposes it is a violation if odors are detected after the odorous air
has been diluted with seven (7) or more volumes of odor free air."
SCC CODING
SCC Code: 31000205
Emission Factors for Permit:
Uncontrolled (lb/bbl) Controlled (lb/bbl) Control Eff.
NOx 0.031 0.031 0%
CO 0.078 0.078 0%
VOC 8.2665 0.4133 95%
Benzene 0.073 0.0037 95%
Toluene 0.0967.
_ __
Etylbenzene0_0200 0:0010 ._._.____..___.__.... 95%
X-ylenes_ 0.0620 0.0031 95%
n -Hexane 0.3450 ...._...___._. 0.0173 __.._. 95%
2,2,4-TMP 4-TMP 0.061 0 0030 95%
15WE0643.CP1.xlsx
CONSTRUCTION PERMIT
Permit number:
Date issued:
Issued to:
15WE0643
Facility Name:
Plant AIRS ID:
Physical Location:
County:
General Description:
Issuance: 1
Kerr-McGee Oil and Gas Onshore LP
36146148
123/9C8F
NWNW Section 17 T1 N R67W
Weld County
Well Production Facility
Equipment or activity subject to this permit:
Facility
Equipment
ID
AIRS
Point
Equipment Description
Emissions Control
Description
VRT-01
005
One (1) vapor recovery tower (VRT) that
processes liquid from the second stage of
separation to create a third stage of
liquid/gas separation. Overhead flash gas
from the VRT collected by vapor recovery
units (VRUs) in a closed -loop process. When
the VRUs are unable to capture the entire
overhead gas stream, flash gas is routed to
enclosed combustors. Emissions from this
point are a function of liquids throughput
while overhead gas is routed to the enclosed
combustors, and permit limits are based on
gas routed to the enclosed combustors 30% of
the time.
Enclosed Combustors
This permit is granted subject to all rules and regulations of the Colorado Air Quality Control
Commission and the Colorado Air Pollution Prevention and Control Act (C.R.S. 25-7-101 et seq), to this
specific general terms and conditions included in this document and the following specific terms and
conditions.
REQUIREMENTS TO SELF -CERTIFY FOR FINAL AUTHORIZATION
1. YOU MUST notify the Air Pollution Control Division (the Division) no later than fifteen days of
the latter of commencement of operation or issuance of this permit, by submitting a Notice of
Startup form to the Division for the equipment covered by this permit. The Notice of Startup
COLORADO
Air Pollution Control Division
Page 1 of 7
form may be download fic/cdphe/other-air-permitting-
notices. Failure to notif i •f s of - per tted source is a violation of Air
Quality Control Commis •C - -n 3, Pa Section III.G.1. and can result
in the revocation of the permit.
2. Within one hundred and eighty days (180) of the latter of commencement of operation or
issuance of thispermit, compliance with the conditions contained in this permit shall be
demonstrated to the Division. It is the owner or operator's responsibility to self -certify
compliance with the conditions. Failure to demonstrate compliance within 180 days may result
in revocation of the permit. A self certification form and guidance on how to self -certify
compliance as required by this permit may be obtained online at
www.colorado.gov/pacific/cdphe/air-permit-self-certification. (Regulation Number 3, Part B,
Section III.G.2.)
3. This permit shall expire if the owner or operator of the source for which this permit was issued:
(i) does not commence construction/modification or operation of this source within 18 months
after either, the date of issuance of this construction permit or the date on which such
construction or activity was scheduled to commence as set forth in the permit application
associated with this permit; (ii) discontinues construction for a period of eighteen months or
more; (iii) does not complete construction within a reasonable time of the estimated
completion date. The Division may grant extensions of the deadline. (Regulation Number 3,
Part B, Section III.F.4.)
F.4. )
4. The operator shall complete all initial compliance testing and sampling as required in this
permit and submit the results to the Division as part of the self -certification process.
(Regulation Number 3, Part B, Section III.E.)
5. The operator shall retain the permit final authorization letter issued by the Division, after
completion of self -certification, with the most current construction permit. This construction
permit alone does not provide final authority for the operation of this source.
EMISSION LIMITATIONS AND RECORDS
6. Emissions of air pollutants shall not exceed the following limitations. (Regulation Number 3,
Part B, Section II.A.4.)
)
Annual Limits:
Facility
Equipment ID
AIRS
Point
Tons per Year
Emission
Type
PM2.5
NO.
VOC
CO
VRT-01
005
---
1.1
14.3
2.7
Point
Note: See "Notes to Permit Holder" for information on emission factors and methods used to calculate
limits.
Facility -wide emissions of each individual hazardous air pollutant shall not exceed 8.0 tons per
year.
Facility -wide emissions of total hazardous air pollutants shall not exceed 20.0 tons per year.
The facility -wide emissions limitation for hazardous air pollutants shall apply to all permitted
emission units at this facility.
Compliance with the annual limits, for both criteria and hazardous air pollutants, shall be
determined on a rolling twelve (12) month total. By the end of each month a new twelve
month total is calculated based on the previous twelve months' data. The permit holder shall
calculate actual emissions each month and keep a compliance record on site or at a local field
office with site responsibility for Division review.
COLORADO
Air Pollution Control Division
x r.:.•pu, Erior.t
Page 2 of 7
7. The emission points in t
control equipment as lis
established in this perm
maintained with the emissions
ess than or equal to the limits
, Se ci III.E.)
Facility
Equipment ID
AIRS
Point
Control Device
Pollutants
Controlled
VRT-01
005
Emissions from the vapor recovery tower are
routed to enclosed combustors (Make: LEED,
model: L30-0010) when Vapor Recovery Unit
(VRU) is unable to recover all vapors.
VOC and HAP
PROCESS LIMITATIONS AND RECORDS
8. This source shall be limited to the following maximum processing rates as listed below. Monthly
records of the actual processing rates shall be maintained by the owner or operator and made
available to the Division for inspection upon request. (Regulation Number 3, Part B, II.A.4.)
Process Limits
Facility
Equipment ID
AIRS
Point
Process Parameter
Annual Limit
VRT-01
005
Liquids Throughput
through VRT while gas is
routed from VRT to
enclosed combustors
69,000 bbl/yr
Compliance with the annual throughput limits shall be determined on a rolling twelve (12)
month total. By the end of each month a new twelve-month total is calculated based on the
previous twelve months' data. The permit holder shall calculate throughput each month and
keep a compliance record on site or at a local field office with site responsibility, for Division
review.
9. The owner or operator shall use VRT liquids throughput records, calculation methods detailed
in the O&M Plan, and the emission factors established in the Notes to Permit Holder to
demonstrate compliance with the process and emissions limits specified in this permit.
STATE AND FEDERAL REGULATORY REQUIREMENTS
10. The permit number and ten digit AIRS ID number assigned by the Division (e.g. 123/4567/001)
shall be marked on the subject equipment for ease of identification. (Regulation Number 3,
Part B, Section III.E.) (State only enforceable)
11. No owner or operator of a smokeless flare or other flare for the combustion of waste gases
shall allow or cause emissions into the atmosphere of any air pollutant which is in excess of 30%
opacity for a period or periods aggregating more than six minutes in any sixty consecutive
minutes. (Regulation Number 1, Section II.A.5.)
12. This source is subject to the odor requirements of Regulation Number 2. (State only
enforceable)
OPERATING Et MAINTENANCE REQUIREMENTS
13. Upon startup of this point, the owner or operator shall follow the most recent operating and
maintenance (OEtM) plan and record keeping format approved by the Division, in order to
demonstrate compliance on an ongoing basis with the requirements of this permit. Revisions to
the OEtM plan are subject to Division approval prior to implementation. (Regulation Number 3,
Part B, Section III.G.7.)
COMPLIANCE TESTING AND SAMPLING
COLORADO
Air Pollution Control Division
Page 3 of 7
Initial Testing Requirem
14. The owner or operator ce wit opacity standards, using EPA
Reference Method 9, 4• . .R. Pa 60, ppen lx , to measure opacity from the flare. The
observation period shall be 1 hour in duration. (Regulation Number 1, Section II.A.5)
Periodic Testing Requirements
15. This source is not required to conduct periodic testing, unless otherwise directed by the
Division or other state or federal requirement.
ADDITIONAL REQUIREMENTS
16. A revised Air Pollutant Emission Notice (APEN) shall be filed: (Regulation Number 3, Part A,
II.C.)
• Annually by April 30th whenever a significant increase in emissions occurs as follows:
For any criteria pollutant:
For sources emitting less than 100 tons per year, a change in actual emissions of five
(5) tons per year or more, above the level reported on the last APEN; or
For volatile organic compounds (VOC) and nitrogen oxides sources (NOr) in ozone
nonattainment areas emitting less than 100 tons of VOC or NO, per year, a change in
annual actual emissions of one (1) ton per year or more or five percent, whichever is
greater, above the level reported on the last APEN; or
For sources emitting 100 tons per year or more, a change in actual emissions of five
percent or 50 tons per year or more, whichever is less, above the level reported on the
last APEN submitted; or
For any non -criteria reportable pollutant:
If the emissions increase by 50% or five (5) tons per year, whichever is less, above the
level reported on the last APEN submitted to the Division.
• Whenever there is a change in the owner or operator of any facility, process, or
activity; or
• Whenever new control equipment is installed, or whenever a different type of control
equipment replaces an existing type of control equipment; or
• Whenever a permit limitation must be modified; or
• No later than 30 days before the existing APEN expires.
17. Federal regulatory program requirements (i.e. PSD, NANSR) shall apply to this source at any
such time that this source becomes major solely by virtue of a relaxation in any permit
condition. Any relaxation that increases the potential to emit above the applicable Federal
program threshold will require a full review of the source as though construction had not yet
commenced on the source. The source shall not exceed the Federal program threshold until a
permit is granted. (Regulation Number 3, Parts C and D).
GENERAL TERMS AND CONDITIONS
18. This permit and any attachments must be retained and made available for inspection upon
request. The permit may be reissued to a new owner by the APCD as provided in AQCC
Regulation Number 3, Part B, Section II.B. upon a request for transfer of ownership and the
submittal of a revised APEN and the required fee.
19. If this permit specifically states that final authorization has been granted, then the remainder
of this condition is not applicable. Otherwise, the issuance of this construction permit does not
provide "final" authority for this activity or operation of this source. Final authorization of the
COLORADO
Air Pollution Control Division
Page 4 of 7
permit must be secured e P in'ng 1 a cord ce with the provisions of 25-7-
114.5(12)(a) C.R.S. and g 'n N 3, a t B, ction III.G. Final authorization
cannot be granted until -ra ' - o it nce has been verified by the APCD
as conforming in all respects with the conditions of the permit. Once self -certification of all
points has been reviewed and approved by the Division, it will provide written documentation
of such final authorization. Details for obtaining final authorization to operate are located in
the Requirements to Self -Certify for Final Authorization section of this permit.
20. This permit is issued in reliance upon the accuracy and completeness of information supplied
by the owner or operator and is conditioned upon conduct of the activity, or construction,
installation and operation of the source, in accordance with this information and with
representations made by the owner or operator or owner or operator's agents. It is valid only
for the equipment and operations or activity specifically identified on the permit.
21. Unless specifically stated otherwise, the general and specific conditions contained in this
permit have been determined by the APCD to be necessary to assure compliance with the
provisions of Section 25-7-114.5(7)(a), C.R.S.
22. Each and every condition of this permit is a material part hereof and is not severable. Any
challenge to or appeal of a condition hereof shall constitute a rejection of the entire permit
and upon such occurrence, this permit shall be deemed denied ab initio. This permit may be
revoked at any time prior to self -certification and final authorization by the Air Pollution
Control Division (APCD) on grounds set forth in the Colorado Air Quality Control Act and
regulations of the Air Quality Control Commission (AQCC), including failure to meet any express
term or condition of the permit. If the Division denies a permit, conditions imposed upon a
permit are contested by the owner or operator, or the Division revokes a permit, the owner or
operator of a source may request a hearing before the AQCC for review of the Division's action.
23. Section 25-7-114.7(2)(a), C.R.S. requires that all sources required to file an Air Pollution
Emission Notice (APEN) must pay an annual fee to cover the costs of inspections and
administration. If a source or activity is to be discontinued, the owner must notify the Division
in writing requesting a cancellation of the permit. Upon notification, annual fee billing will
terminate.
24. Violation of the terms of a permit or of the provisions of the Colorado Air Pollution Prevention
and Control Act or the regulations of the AQCC may result in administrative, civil or criminal
enforcement actions under Sections 25-7-115 (enforcement), -121 (injunctions), -122 (civil
penalties), -122.1 (criminal penalties), C.R.S.
By:
Andy Gruel, P.E.
Permit Engineer
Permit History
Issuance
Date
Description
Issuance 1
This Issuance
Issued to Kerr-McGee Oil and Gas Onshore LP.
COLORADO
Air Pollution Control Division
Page 5 of 7
Notes to Permit Holder at the ti
1) The permit holder is requir= _ e''"•ay = -s = e = _ _- -'ng ti a for this permit. An invoice for
these fees will be issued after the permit is issued. The permit holder shall pay the invoice within
30 days of receipt of the invoice. Failure to pay the invoice will result in revocation of this permit.
(Regulation Number 3, Part A, Section VI.B.)
2) The production or raw material processing limits and emission limits contained in this permit are
based on the consumption rates requested in the permit application. These limits may be revised
upon request of the owner or operator providing there is no exceedance of any specific emission
control regulation or any ambient air quality standard. A revised air pollution emission notice
(APEN) and complete application form must be submitted with a request for a permit revision.
3) This source is subject to the Common Provisions Regulation Part II, Subpart E, Affirmative Defense
Provision for Excess Emissions During Malfunctions. The owner or operator shall notify the Division
of any malfunction condition which causes a violation of any emission limit or limits stated in this
permit as soon as possible, but no later than noon of the next working day, followed by written
notice to the Division addressing all of the criteria set forth in Part II.E.1 of the Common Provisions
Regulation. See: https://www.colorado.gov/pacific/cdphe/aqcc-regs
4) The following emissions of non -criteria reportable air pollutants are estimated based upon the process
limits as indicated in this permit. This information is listed to inform the operator of the Division's
analysis of the specific compounds emitted if the source(s) operate at the permitted limitations.
Facility
Equipment ID
AIRS
Point
Pollutant
CAS #
Uncontrolled
Emissions
(Ib/yr)
Controlled
Emissions
(lb/yr)
VRT-01
005
Benzene
71432
5037
252
Toluene
108883
6624
331
Ethylbenzene
100414
1380
69
Xylenes
1330207
4278
214
n -Hexane
110543
23805
1190
2,2,4-
Trimethylpentane
540841
4175
209
Note: All non -criteria reportable pollutants in the table above with uncontrolled emission rates above 250 pounds
per year (lb/yr) are reportable and may result in annual emission fees based on the most recent Air Pollution
Emission Notice.
5) The emission levels contained in this permit are based on the following emission factors:
Point 005:
CAS #
Pollutant
Uncontrolled
Emission Factors
(lb/bbl)
Controlled
Emission Factors
(lb/bbl)
Source
N0x
0.031
0.031
CDPHE 2005 Memo
CO
0.078
0.078
V0C
8.2665
0.4133
EIfP Tank v2.0 based
on site -specific
pressurized liquids
samples
71432
Benzene
0.073
0.0037
108883
Toluene
0.096
0.0048
100414
Ethylbenzene
0.020
0.0010
1330207
Xylene
0.062
0.0031
110543
n -Hexane
0.345
0.0173
COLORADO
Air Pollution Control Division
Page 6 of 7
CAS #
Pollutant
s 711
I
ontr led
Sion actors
)
Source
(lb
540841
2,
Trimethylpentane
0.061 0.061
0.0030
Note: The controlled emissions factors for this point are based on the enclosed combustor control
efficiency of 95%.
6) In accordance with C.R.S. 25-7-114.1, each Air Pollutant Emission Notice (APEN) associated with
this permit is valid for a term of five years from the date it was received by the Division. A revised
APEN shall be submitted no later than 30 days before the five-year term expires. Please refer to
the most recent annual fee invoice to determine the APEN expiration date for each emissions point
associated with this permit. For any questions regarding a specific expiration date call the Division
at (303)-692-3150.
7) This facility is classified as follows:
Applicable
Requirement
Status
Operating Permit
Synthetic Minor Source of: VOC, n -hexane
NANSR
Synthetic Minor Source of: VOC
8) Full text of the Title 40, Protection of Environment Electronic Code of Federal Regulations can be
found at the website listed below:
http://ecfr.gpoaccess.gov/
Part 60: Standards of Performance for New Stationary Sources
NSPS
60.1 -End
Subpart A - Subpart KKKK
NSPS
Part 60, Appendixes
Appendix A - Appendix I
Part 63: National Emission Standards for Hazardous Air Pollutants for Source Categories
MACT
63.1-63.599
Subpart A - Subpart Z
MACT
63.600-63.1199
Subpart AA - Subpart DDD
MACT
63.1200-63.1439
Subpart EEE - Subpart PPP
MACT
63.1440-63.6175
Subpart QQQ - Subpart YYYY
MACT
63.6580-63.8830
Subpart ZZZZ - Subpart MMMMM
MACT
63.8980 -End
Subpart NNNNN - Subpart XXXXXX
COLORADO
Air Pollution Control Division
Page 7 of 7
U -
co
U
M
N
Emission Source AIRS ID:
[Leave blank unless APCD has already assigned a permit ft & AIRS ID]
Permit Number:
[Provide Facility Equipment ID to identify how this equipment is referenced within your organization.]
Facility Equipment ID:
uested Action (check applicable request boxes)
Section 02 — Re
Section 01 — Administrative Information
M
O.
R
.r
s
w
0
a)
.0
k
u O
L =
7 u
o o
m a,
C
o u
COI .0
E
a)
"0 .E
a) L
O O.
a on
L 1.+ L'
L .17Iy O d a)
C
a)
L r
O L Z
O
O —
COI I. a .W-4 U
.et Wo
Gs7 ' ►-i
E" 44 ne
Ill
a a a
Change company name
0
❑
Transfer of ownership
El O
Change fuel or equipment
Change permit limit
Request to limit HAPs with a Federally enforceable limit on PTE
Request APEN Update
® ❑ ❑ ❑ ❑
O a)
b
U C)
U
zc
Company Name: Kerr-McGee Oil and Gas Onshore LP
Source Name:
Sect. 17 TIN R67W
Source Location:
a)
0 aq
VD U
4J
z
N
oo
U
N
Emissions data must be completed. Blank APENs will not be accepted.
Denver, CO 80217-3779
Requesting individual permit for vapor recovery tower (VRT)
Section 03 — General Information
rct
u
c.)
a)
O
a)
u
0
'O
a)
0
0
U
O
a)
°
N
N
0
0
O
0
0 0.
b
. 0 0
y0 4
- )
0 0. 0.
l... =
u V 'O"
a) oa)
s- 4.
0O
v 0
c a.
O z •0
O U
• 0 0 CA
V
,, "iffd
b
4.1
I.
00 0 U
w z (.7
o a)
o O o
+- oasv,
as
E z a, -Au M M M
C cJ by y
o Y
L Mai C "-'
a. a) .v
=A ca�i''' 4, E y o00
en en en
O OA UC4 W
ea 7
: '' O c° a E1. w
u A Cip 0 U L GQ
O wo u
=vt 3� �x g
c.O >' O a. s ' a) to
w e v5 asa rn °a
C O O L
c o 0 q,4; AL 01 ° g
A '- 4> !I! N '� by Q
R,, .; : o 00 o U
-o o o E p,t O U c
ea s-. O A L O U Of�.
O U a) H '-,� a) V O
O :� Cti O +' O r a6,A V
U N 0. V 'eiJ� °° a~°. 74
U:.Q4.1 a4 w ¢v)
0
U
0
V
0
0
U
Application status: htt
0 O
Q3
❑
O
z
a)
0
G
a
�a
c
0
0
z
b
u
b
U
0 0
.0 0
0
a) O
6.
p,
• U
ment Information & Material Use
Section 04 — Processing/Manufacturin
Description of equipment':
V
0
0
Manufacturer:
0
O
O
N
Q
69,000 bbl/yr
0
a)
.0 0
O
Other Process:
Check box to request copy of draft permit prior to issuance.
Check box to request copy of draft permit prior to public notice.
Form APCD-200 — GeneralAPEN — Ver.02.10.2014.docx
N
0
V
FORM APCD-200
co
W
U
0)
Emission Source AIRS ID:
Permit Number:
d
0.3
.b
a)
b
>
0
CO
a)
CO
Cd
a)
a)
C)
O
C)
a)
0
w
0
N
a)
a)
C)
CC
RS
aJ
CC
U
C
O
R
E
w
O
H
a)
Ira
C�
C.
CO
E
C
O
U
a)
40.0555425
-104.9204957
r
o N
N
•�
Az oo
0 N N
dO
00
G7
(.:
a)
'0 C)
o
c4
o<
w "
aw
H c
❑ Other (Describe):
0
0
C
0
0
Width (inches) =
Other: Length (inches) =
a)
C
I
M
of)
.5
U II
CO
O U
O•
To
J'..
a)a)
❑ g
z
a) UEl
It)
Direction of outlet (check one):
Exhaust Opening Shape & Size (check one):
ment & Fuel Consumption Information
Section 06 — Combustion E
Multiple ECDs
z
)
161
1.44
0
Manufacturer:
N
CO
C
0
a>
w
C
0
CO
V
Z
' N
c/D
N
ti
N
A
L-,
N
a)
C
a)
C-
0
a
CO
O
CID
h0
C
00
U
c
a)
v w
O
o
—al 00
O
F-+
0
w
Natural Gas
•
•
z�
W
V
O CC
C O
O L
a) O c�a
C CC
U
O
•0
I-
o
•
V
Ey
a)
-CO
g
ti
O
E
7
U
O
C.)
U
O
CC
CO w
C) _O
E E
.0 W
et
®
r
t
i
2005 APCD
E&P Tank
CO I I 0.0094 Ib/IbVOC -- 2.68 2005 APCD
Please use the APCD Non -Criteria Reportable Air Pollutant Addendum fnrm to ra..,,, r nnu..f.=.+ .,,,. r.�*ea ► ..
AI
Requested Permitted Emissions
Uncontrolled Controlled
(Tons/Year) (Tons/Year)
VD
14.26
O
.
285.2 I
1J
i:
Actual Calendar Year
Emissions4
Uncontrolled Controlled
(Tons/Year) (Tons/Year)
Emission Factor
Uncontrolled Units
Basis
Ib/IbVOC
N
M
o
8.267 I
O
Control
Efficiency'',
(% Reduction)
O\
Overall
Collection
Efficiency
Control Device Description
Secondary
Primary
Flare
Pollutant
TSP
c
a
N
a
k
O
�
X
z
II VOC
CC
E
a
L
L
•C
Q'
I-
'O
C
C
CO
E
C
O
CC
9
C
L
O
u
u
L
V
c
+r a)
y
O ,C
'C C
Et- o
W
•
o
is
Z
W �
C
O
W •47;
C
'O a)
oA
A az E �3
N
COW
L C
O
u �y
3 �
C
resentative
E
O
u
•
15.
a
ae
a)
l
C Q
E 6 03
OD
O a.)
V) o
C '
tes
Az
.re
.C
b
a)
L'i
•
O
aQ v
co
w>'
a)
u
O
a)
s
licant Certification
Section 08 —A
Person Legally Alit
0
a
Form APCD-200 — GeneralAPEN — Ver.02.10.2014.docx
N
a~
O
N
a)
cat
AIRS ID Number: 123-9C8F-TBD-'0055-
Permit Number:
0-
- J
a)
L
O
z
0
a)
co
a)
a)
U
a)
ai
C
a)
Z
a)
Q
O
O
N-
C
O
00
a)
O
O
a
N
a)
>
O
O
NWNW S17 T1 N R67W
Plant Location:
ca
U)
Cn
a)
U
A
Person to Contact:
Carissa.krey@anadarko.com
E-mail Address:
Controlled Actual
Emissions
(lbs/year)
N
N
e-
CO
CO
Nr
N
0
CO
V-
O)
N
Uncontrolled
Actual Emissions
(lbs/year)
5037
N
VD
CO
1380
CO
CsI
44
23805
4175
Emission Factor
Source
E&P Tank
E&P Tank
E&P Tank
E&P Tank
E&P Tank
E&P Tank
P
1',
Emission Factor
(Include Units)
0.073 lb/bbl
"a
—
co)
-
C
2
-2
0
0 O
"2
in
N
0
O
0.345 lb/bbl
To
-
1-
CO
O
Control Equipment
/ Reduction (%)
rn
95
rn
95
0)
95
Chemical Name
Benzene
Toluene
E -Benzene
Xylene
N -Hexane
224 -TM P
Chemical Abstract
Service (CAS)
Number
U)
C
O
.7)
U)
W
a
a)
U)
a)
a)
v-
a)
a_
a
a)
co
O
To
U
L
U_
L
L
C
a)
O
HSE Representative
C6
a)
O
>,
a_
U)
O
N
O
>,
Ca
0)
a)
J
C
O
U
L
^a)
LL
O a)
(V 0)
CD
(Q v,
cn
Title of Person Legally Authorized to Supply Data
Q
a)
U)
4)
a
Ca
a)
O
>,
0_
0_
O
a)
N
O
t
CQ
0)
a)
cn
C
O
',ET)
C-
O
a)
CII
Z
Form Revision Date: A
Hello