HomeMy WebLinkAbout20194720.tiffCOLORADO
Department of Public
Health & Environment
Weld County - Clerk to the Board
1150 O St
PO Box 758
Greeley, CO 80632
October 30, 2019
Dear Sir or Madam:
On October 31, 2019, the Air Pollution Control Division will begin a 30 -day public notice period for
HighPoint Operating Corporation - RSU Anschutz Fed 4-62-11_12 SE10 Pad. A copy of this public
notice and the public comment packet are enclosed.
Thank you for assisting the Division by posting a copy of this public comment packet in your office.
Public copies of these documents are required by Colorado Air Quality Control Commission
regulations. The packet must be available for public inspection for a period of thirty (30) days from
the beginning of the public notice period. Please send any comment regarding this public notice to
the address below.
Colorado Dept. of Public Health a Environment
APCD-SS-B1
4300 Cherry Creek Drive South
Denver, Colorado 80246-1530
Attention: Clara Gonzales
Regards,
Clara Gonzales
Public Notice Coordinator
Stationary Sources Program
Air Pollution Control Division
Enclosure
4300 Cherry Creek Drive S., Denver, CO 80246-1530 P 303-692-2000 www.cotorado.gov/cdphe
Jared Polls, Governor I Jilt Hunsaker Ryan, MPH, Executive Director
Pv61 : G k2\/': G(") CC: FL_ (TO, HL(Lk) PW(sr/ER/cH/c&),
11 /13/19 OG(3m)
Air Pollution Control Division
Notice of a Proposed Project or Activity Warranting Public
Comment
Website Title: HighPoint Operating Corporation - RSU Anschutz Fed 4-62-11_12 SE10 Pad - Weld County
Notice Period Begins: October 31, 2019
Notice is hereby given that an application for a proposed project or activity has been submitted to the
Colorado Air Pollution Control Division for the following source of air pollution:
Applicant: HighPoint Operating Corporation
Facility: RSU Anschutz Fed 4-62-11_12 SE10 Pad
Oil and natural gas production facility
NESE Sec10, T4N, R62W
Weld County
The proposed project or activity is as follows: Applicant proposes to operate a new well production facility
servicing seven (7) new wells. Applicant is requesting synthetic minor limits for ten (10) condensate storage
vessels.
The Division has determined that this permitting action is subject to public comment per Colorado
Regulation No. 3, Part B, Section III.C due to the following reason(s):
• the source is requesting a federally enforceable limit on the potential to emit in order to avoid other
requirements
The Division has made a preliminary determination of approval of the application.
A copy of the application, the Division's analysis, and a draft of Construction Permit 19WE0730 have been
filed with the Weld County Clerk's office. A copy of the draft permit and the Division's analysis are
available on the Division's website at https://www.colorado.gov/pacific/cdphe/air-permit-public-notices
The Division hereby solicits submission of public comment from any interested person concerning the ability
of the proposed project or activity to comply with the applicable standards and regulations of the
Commission. The Division will receive and consider written public comments for thirty calendar days after
the date of this Notice. Comments may be submitted using the following options:
• Use the web form at https://www.colorado.gov/pacific/cdphe/air-permit-public-notices. This page
also includes guidance for public participation
• Send an email to cdphe.commentsapcd@state.co.us
• Send comments to our mailing address:
Bradley Eades
Colorado Department of Public Health and Environment
4300 Cherry Creek Drive South, APCD-SS-B1
Denver, Colorado 80246-1530
fig
COLORADO
Department of Public
Health & Environment
COLORADO
Air Pollution Control Division
Department of Pubtc Health & Environment
Dedicated to protecting and improving the health and environment of the people of Colorado
Permit number:
Date issued:
Issued to:
CONSTRUCTION PERMIT
19WE0730 Issuance: 1
Facility Name:
Plant AIRS ID:
Physical Location:
County:
Description:
HighPoint Operating Corporation
RSU Anschutz Fed 4-62-11_12 SE10 Pad
123/A03C
NESE Sec 10, T4N, R62W
Weld County
Well Production Facility
Equipment or activity subject to this permit:
Facility
Equipment
ID
AIRS
Point
Equipment Description
Emissions Control
Description
Cond. Tanks
002
Ten (10) 400 barrel fixed roof storage
vessels used to . store condensate
Enclosed Combustor
This permit is granted subject to all rules and regulations of the Colorado Air Quality Control
Commission and the Colorado Air Pollution Prevention and Control Act (C.R.S. 25-7-101 et seq), to the
specific general terms and conditions included in this document and the following specific terms and
conditions.
REQUIREMENTS TO SELF -CERTIFY FOR FINAL AUTHORIZATION
1. YOU MUST notify the Air Pollution Control Division (the Division) no later than fifteen days of
the latter of commencement of operation or issuance of this permit, by submitting a Notice of
Startup form to the Division for the equipment covered by this permit. The Notice of Startup
form may be downloaded online at www.colorado.gov/cdphe/air/manage-permit. Failure to
notify the Division of startup of the permitted source is a violation of Air Quality Control
Commission (AQCC) Regulation Number 3, Part B, Section III.G.1. and can result in the
revocation of the permit.
2. Within one hundred and eighty days (180) of the latter of commencement of operation or
issuance of this permit, compliance with the conditions contained in this permit must be
demonstrated to the Division. It is the owner or operator's responsibility to self -certify
compliance with the conditions. Failure to demonstrate compliance within 180 days may result
in revocation of the permit. A self certification form and guidance on how to self -certify
Page 1 of 9
COLORADO
Air Pollution Control Division
Department of Public Health & Environment
Dedicated to protecting and improving the health and environment of the people of Colorado
compliance as required by this permit may be obtained online at www.colorado.gov/cdphe/air-
permit-self-certification. (Regulation Number 3, Part B, Section III.G.2.)
3. This permit must expire if the owner or operator of the source for which this permit was issued:
(i) does not commence construction/modification or operation of this source within 18 months
after either, the date of issuance of this construction permit or the date on which such
construction or activity was scheduled to commence as set forth in the permit application
associated with this permit; (ii) discontinues construction for a period of eighteen months or
more; (iii) does not complete construction within a reasonable time of the estimated
completion date. The Division may grant extensions of the deadline. (Regulation Number 3,
Part B, Section III.F.4.)
4. The operator must complete all initial compliance testing and sampling as required in this
permit and submit the results to the Division as part of the self -certification process.
(Regulation Number 3, Part B, Section III.E.)
5. The operator must retain the permit final authorization letter issued by the Division, after
completion of self -certification, with the most current construction permit. This construction
permit alone does not provide final authority for the operation of this source.
EMISSION LIMITATIONS AND RECORDS
6. Emissions of air pollutants must not exceed the following limitations. (Regulation Number 3,
Part B, Section II.A.4.)
Annual Limits:
Facility
Equipment ID
AIRS
Point
Tons per Year
Emission
Type
PM2.5
NO,
VOC
CO
Cond. Tanks
002
---
-
11.5
1.7
Point
Note: See "Notes to Permit Holder" for information on emission factors and methods used to calculate limits.
Compliance with the annual limits must be determined on a rolling twelve (12) month total. By
the end of each month ,a new twelve month total is calculated based on the previous twelve
months' data. The permit holder must calculate actual emissions each month and keep a
compliance record on site or at a local field office with site responsibility for Division review.
7. The owner or operator must use the emission factors found in "Notes to Permit Holder" to
calculate emissions and show compliance with the limits. The owner or operator must submit
an Air Pollutant Emission Notice (APEN) and receive a modified permit prior to the use of any
other method of calculating emissions.
8. The emission points in the table below must be operated and maintained with the emissions
control equipment as listed in order to reduce emissions to less than or equal to the limits
established in this permit. (Regulation Number 3, Part B, Section III.E.)
Page 2 of 9
COLORADO
Air Pollution Control Division
Department of Public Health & Environment
Dedicated to protecting and improving the health and environment of the people of Colorado
Facility
Equipment
ID
AIRS
Point
Control Device
Pollutants
Controlled
Cond. Tanks
002
Enclosed Combustor
VOC and HAP
PROCESS LIMITATIONS AND RECORDS
9. This source must be limited to the following maximum processing rates as listed below. Monthly
records of the actual processing rates must be maintained by the owner or operator and made
available to the Division for inspection upon request. (Regulation Number 3, Part B, II.A.4.)
Process Limits
Facility
Equipment
ID
AIRS
Point
Process Parameter
Annual Limit
Cond. Tanks
002
Condensate throughput
50.4,840 barrels
The owner or operator must monitor monthly process rates based on the calendar month.
Compliance with the annual throughput limits must be determined on a rolling twelve (12)
month total. By the end of each month a new twelve-month total is calculated based on the
previous twelve months' data. The permit holder must calculate throughput each month and
keep a compliance record on site or at a local field office with site responsibility, for Division
review.
STATE AND FEDERAL REGULATORY REQUIREMENTS
10. The permit number and ten digit AIRS ID number assigned by the Division (e.g. 123/4567/001)
must be marked on the subject equipment for ease of identification. (Regulation Number 3,
Part B, Section III.E.) (State only enforceable)
11. This source is subject to the odor requirements of Regulation Number 2. (State only
enforceable)
12. This source is subject to Regulation Number 7, Section XII. The operator must comply with all
applicable requirements of Section XII and, specifically, must:
• Comply with the recordkeeping, monitoring, reporting and emission control
requirements for condensate storage tanks; and
• Ensure that the combustion device controlling emissions from this storage tank be
enclosed, have no visible emissions, and be designed so that an observer can, by means
of visual observation from the outside of the enclosed combustion device, or by other
means approved by the Division, determine whether it is operating properly. (Regulation
Number 7, Section XII.C.) (State only enforceable)
13. The combustion device covered by this permit is subject to Regulation Number 7, Section
XVII.B.2. General Provisions (State only enforceable). If a flare or other combustion device is
used to control emissions of volatile organic compounds to comply with Section XVII, it must be
Page 3 of 9
COLORADO
Air Pollution Control Division
Department of Public Health & Environment
Dedicated to protecting and improving the health and environment of the people of Colorado
enclosed; have no visible emissions during normal operations, as defined under Regulation
Number 7, XVII.A.16; and be designed so that an observer can, by means of visual observation
from the outside of the enclosed flare or combustion device, or by other convenient means
approved by the Division, determine whether it is operating properly. This flare must be
equipped with an operational auto -igniter.
14. The storage tank covered by this permit is subject to the emission control requirements in
Regulation Number 7, Section XVII.C.1. The owner or operator must install and operate air
pollution control equipment that achieves an average hydrocarbon control efficiency of 95%. If
a combustion device is used, it must have a design destruction efficiency of at least 98% for
hydrocarbons except where the combustion device has been authorized by permit prior to May
1, 2014. The source must follow the inspection requirements of Regulation Number 7, Section
XVII.C.1.d. and maintain records of the inspections for a period of two years, made available
to the Division upon request. This control requirement must be met within 90 days of the date
that the storage tank commences operation.
15. The storage tanks covered by this permit are subject to the venting and Storage Tank Emission
Management System ("STEM") requirements of Regulation Number 7, Section XVII.C.2.
OPERATING & MAINTENANCE REQUIREMENTS
16. Upon startup of these points, the owner or operator must follow the most recent operating and
maintenance (0>M) plan and record keeping format approved by the Division, in order to
demonstrate compliance on an ongoing basis with the requirements of this permit. Revisions to
the OEtM plan are subject to Division approval prior to implementation. (Regulation Number 3,
Part B, Section III.G.7.)"
..............
COMPLIANCE TESTING AND SAMPLING
Initial Testing Requirements
17. The owner or operator must demonstrate compliance with opacity standards, using EPA
Reference Method 22, 40 C.F.R. Part 60, Appendix A, to determine the presence or absence of
visible emissions. "Visible Emissions" means observations of smoke for any period or periods of
duration greater than or equal to one minute in any fifteen -minute period during normal
operation. (Regulation Number 7, Sections XII.C, XVII.B.2. and XVII.A.16)
Periodic Testing Requirements
18. This source is not required to conduct periodic testing, unless otherwise directed by the Division
or other state or federal requirement.
ADDITIONAL REQUIREMENTS
19. A revised Air Pollutant Emission Notice (APEN) must be filed: (Regulation Number 3, Part A,
II.C.)
• Annually by April 30th whenever a significant increase in emissions occurs as follows:
For any criteria pollutant:
For sources emitting less than 100 tons per year, a change in actual emissions of five
(5) tons per year or more, above the level reported on the last APEN; or
Page 4 of 9
COLORADO
Air Pollution Control Division
Department of Public Health 8 Environment
Dedicated to protecting and improving the health and environment of the people of Colorado
For volatile organic compounds (VOC) and nitrogen oxides sources (NO.) in ozone
nonattainment areas emitting less than 100 tons of V0C or NO. per year, a change in
annual actual emissions of one (1) ton per year or more or five percent, whichever is
greater, above the level reported on the last APEN; or
For sources emitting 100 tons per year or more, a change in actual emissions of five
percent or 50 tons per year or more, whichever is less, above the level reported on the
last APEN submitted; or
For any non -criteria reportable pollutant:
If the emissions increase by 50% or five (5) tons per year, whichever is less, above the
level reported on the last APEN submitted to the Division.
• Whenever there is a change in the owner or operator of any facility, process, or activity;
or
• Whenever new control equipment is installed, or whenever a different type of control
equipment replaces an existing type of control equipment; or
• Whenever a permit limitation must be modified; or
• No later than 30 days before the existing APEN expires.
20. The requirements of Colorado Regulation No. 3, Part :D must apply at such time that any
stationary source or modification becomes a major stationary source or major modification
solely by virtue of a relaxation in any enforceable limitation that was established after August
7, 1980, on the capacity of the source or modification to otherwise emit a pollutant such as a
restriction on hours of operation (Reference: Regulation Number 3, Part D, V.A.7.B).
GENERAL TERMS AND CONDITIONS
21. This permit and any attachments must be retained and made available for inspection upon
request. The permit may be reissued to a new owner by the APCD as provided in AQCC
Regulation Number 3, Part B, Section II.B. upon a request for transfer of ownership and the
submittal of a revised APEN and the required fee.
22. If this permit specifically states that final authorization has been granted, then the remainder
of this condition is not applicable. Otherwise, the issuance of this construction permit does not
provide "final" authority for this activity or operation of this source. Final authorization of the
permit must be secured from the -APCD in writing in accordance with the provisions of 25-7-
114.5(12)(a) C.R.S. and AQCC Regulation Number 3, Part B, Section III.G. Final authorization
cannot be granted until the operation or activity commences and has been verified by the APCD
as conforming in all respects with the conditions of the permit. Once self -certification of all
points has been reviewed and approved by the Division, it will provide written documentation
of such final authorization. Details for obtaining final authorization to operate are located
in the Requirements to Self -Certify for Final Authorization section of this permit.
23. This permit is issued in reliance upon the accuracy and completeness of information supplied
by the owner or operator and is conditioned upon conduct of the activity, or construction,
installation and operation of the source, in accordance with this information and with
representations made by the owner or operator or owner or operator's agents. It is valid only
for the equipment and operations or activity specifically identified on the permit.
Page 5 of 9
40
COLORADO
Air Pollution Control Division
Department of Public Health & Environment
Dedicated to protecting and improving the health and environment of the people of Colorado
24. Unless specifically stated otherwise, the general and specific conditions contained in this
permit have been determined by the APCD to be necessary to assure compliance with the
provisions of Section 25-7-114.5(7)(a), C.R.S.
25. Each and every condition of this permit is a material part hereof and is not severable. Any
challenge to or appeal of a condition hereof must constitute a rejection of the entire permit
and upon such occurrence, this permit must be deemed denied ab initio. This permit may be
revoked at any time prior to self -certification and final authorization by the Air Pollution
Control Division (APCD) on grounds set forth in the Colorado Air Quality Control Act and
regulations of the Air Quality Control Commission (AQCC), including failure to meet any express
term or condition of the permit. If the Division denies a permit, conditions imposed upon a
permit are contested by the owner or operator, or the Division revokes a permit, the owner or
operator of a source may request a hearing before the AQCCfor review of the Division's action.
26. Section 25-7-114.7(2)(a), C.R.S. requires that all sources required to file an Air Pollution
Emission Notice (APEN) must pay an annual fee to cover the costs of inspections and
administration. If a source or activity is to be discontinued, the owner must notify the Division
in writing requesting a cancellation of the permit. Upon notification, annual fee billing will
terminate.
27. Violation of the terms of a permit or of the provisions of the Colorado Air Pollution Prevention
and Control Act or the regulations of the AQCC may result in administrative, civil or criminal
enforcement actions under Sections 25-7-115 (enforcement), -121 (injunctions), -122 (civil
penalties), -122.1 (criminal penalties), C.R.S.
By:
Bradley Eades
Permit Engineer
Permit Histo
Issuance
Date
Description
Issuance 1
This Issuance
Issued to HighPoint Operating Corporation
New synthetic minor permit.
Page 6 of 9
COLORADO
Air Pollution Control Division
Department of Public Health 8 Erenronment
Dedicated to protecting and improving the health and environment of the people of Colorado
Notes to Permit Holder at the time of this permit issuance:
1) The permit holder is required to pay fees for the processing time for this permit. An invoice for
these fees will be issued after the permit is issued. The permit holder must pay the invoice within
30 days of receipt of the invoice. Failure to pay the invoice will result in revocation of this permit.
(Regulation Number 3, Part A, Section VI.B.)
2) The production or raw material processing limits and emission limits contained in this permit are
based on the consumption rates requested in the permit application. These limits may be revised
upon request of the owner or operator providing there is no exceedance of any specific emission
control regulation or any ambient air quality standard. A revised air pollution emission notice
(APEN) and complete application form must be submitted with a request for a permit revision.
3) This source is subject to the Common Provisions Regulation Part II, Subpart E, Affirmative Defense
Provision for Excess Emissions During Malfunctions. The owner or operator must notify the Division
of any malfunction condition which causes a violation of any emission limit or limits stated in this
permit as soon as possible, but no later than noon of the next working day, followed by written
notice to the Division addressing all of the criteria set forth in Part II.E.1 of the Common Provisions
Regulation. See: https://www.colorado.gov/pacific/cdphe/aqcc-regs
4) The following emissions of non -criteria reportable air pollutants are estimated based upon the
process limits as indicated in this permit. This information is listed to inform the operator of the
Division's analysis of the specific compounds emitted if the source(s) operate at the permitted
limitations.
AIRS
Point
Pollutant
CAS #
Uncontrolled
Emissions
(lb/yr)
Controlled
Emissions
(lb/yr)
Benzene
71432
1,516
76
Toluene
108883
1,172
59
Ethylbenzene
100414
148
7
002
Xylenes
1330207
324
16
n -Hexane
110543
11,082
554
2,2,4-
Trimethytpentane
540841
37
2
Note: All non -criteria reportable pollutants in the table above with uncontrolled emission rates above 250 pounds per year
( b/yr) are reportable and may result in annual emission fees based on the most recent Air Pollution Emission Notice.
5) The emission levels contained in this permit are based on the following emission factors:
CAS #
Pollutant
Uncontrolled
Emission Factors
lb/bbl
Controlled
Emission Factors
lb/bbl
Source
CO
0.0067
0.0067
AP -42 Chapter
13.5
VOC
0.9112
0.0456
ProMax and site -
specific
71432
Benzene
0.0030
1.50E-04
Page 7 of 9
COLORADO
Air Pollution Control Division
Department of Public Health & Environment
Dedicated to protecting and improving the health and environment of the people of Colorado
CAS #
Pollutant
Uncontrolled
Emission Factors
lb/bbl
Controlled
Emission Factors
lb/bbl
Source
pressurized
liquid analysis
108883
Toluene
0.0023
1.16E-04
1330207
Xylene
0.0006
3.21E-05
110543
n -Hexane
0.0220
1.10E-03
Note: The controlled emissions factors for this point are based on a control efficiency of 95%.
6) In accordance with C.R.S. 25-7-114.1, each Air Pollutant Emission Notice (APEN) associated with
this permit is valid for a term of five years from the date it was received by the Division. A
revised APEN must be submitted no later than 30 days before the five-year term expires. Please
refer to the most recent annual fee invoice to determine the APEN expiration date for each
emissions point associated with this permit. For any questions regarding a specific expiration date
call the Division at (303)-692-3150.
7) This permit fulfills the requirement to hold a valid permit reflecting the storage tank and associated
control device per the Colorado Oil and Gas Conservation Commission rule 805b(2)(A) when
applicable.
8) This facility is classified as follows:
Applicable
Requirement
Status
Operating Permit
Synthetic Minor Source of: VOC, NOx
NANSR
Synthetic Minor Source of: VOC, NOx
MACT HH
Area Source Requirements: Not Applicable
9) Full text of the Title 40, Protection of Environment Electronic Code of Federal Regulations can be
found at the website listed below:
http: //www.ecfr.gov/
Part 60: Standards of Performance for New Stationary Sources
NSPS
60.1 -End
Subpart A - Subpart UUUU
NSPS
Part 60, Appendixes
Appendix A - Appendix I
Part 63: National Emission Standards for Hazardous Air Pollutants for Source
Categories
MACT
63.1-63.599
Subpart A - Subpart Z
MACT
63.600-63.1199
Subpart AA - Subpart DDD
MACT
63.1200-63.1439
Subpart EEE - Subpart PPP
MACT
63.1440-63.6175
Subpart QQQ - Subpart YYYY
MACT
63.6580-63.8830
Subpart ZZZZ - Subpart MMMMM
MACT
63.8980 -End
Subpart NNNNN - Subpart XXXXXX
Page 8 of 9
COLORADO
Air Pollution Control Division
Department of Public Health & Environment
Dedicated to protecting and improving the health and environment of the people of Colorado
Page 9 of 9
Colorado Air Permitting Project
Plant AIRS ID:
Facility Name:
Physical
Address/Location:
County:
Type of Facility: xpiomticns&P tductton
What industry segment? .till" & Nattirai txk_Pttrducttan aPes
Is this facility located in a NAAQS non -attainment area? :Yes
If yes, for what pollutant? Carbon Monoxide (CO)
PRELIMINARY ANALYSIS - PROJECT SUMMARY
Project Details
Review Engineer: Bradley Eades
Package #: 401906
Received Date: 7/3/2019
Review Start Date: 9/25/2019
Section 01- Facility Information
Company Name: HighPoint Operating Corporation
County AIRS ID: 123
AMC
RSLI Anschutz Fed 4-62-11_12 SE10 Pad
NESE quadrant of Section 10, Township 4N, Range 62W
Weld County
Section 02 - Emissions Units In Permit Application
11
Pad
171
Particulate Matter (PM)
Quadrant
Section
Township
Range
NESE
62
Ozone (NOx & VOC)
AIRs Point #
Emissions Source Type
Equipment Name
Emissions
Control?
Permit#
Issuance #
Self Cert
Required?
Action
Engineering
Remarks
002
Condensate Tank ,.
Cond. Tanks
.Yes
19WE0730
1
Yes
Per o Initial
tsstt3stee a
`
003
LiquidLoadng .;'. '�
Condensate Loading
Yes is
19WE0731Issuance
004
. Producecfi:l atepTank- :
0 r
PW Tank
F yes
OPUS
GP
5". NO ....
INi....47.. MA *.:. ^
GP08.
Section 03 - Description of Project
Applicant is requesting construction permits to authorize condensate storage tanks and condensate truck loadout at a new well production facility. Th e faciltiy processes
production from seven (7) new wells that began production April 5, 2019:
Section 04 - Public Comment Requirements
Is Public Comment Required?
If yes, why? RequestingSynthetie Ills
Section 05 -Ambient Air Impact Analysis Requirement:
Was a quantitative modeling analysis required? No
If yes, for what pollutants?
If yes, attach a copy of Technical Services Unit modeling results summary.
Section 06 - Facility -Wide Stationary Source Classification
Is this stationary source a true minor?
Is this stationary source a synthetic minor?
If yes, indicate programs and which pollutants:
Prevention of Significant Deterioration (PSD)
Title V Operating Permits (OP)
Non -Attainment New Source Review (NANSR)
SO2 NOx
Is this stationary source a major source?
If yes, explain what programs and which pollutants here 502
Prevention of Significant Deterioration (P5D)
Title V Operating Permits (OP)
Non -Attainment New Source Review (NANSR)
.f
NOx
CO VOC PM2.5 PM10 TSP HAPs
CO VOC
❑ ❑
PM2.5 PM10 TSP HAPs
❑ ❑
Condensate Storage Tanks) Cons.€
Sardbn 01 rIdnintctrative Information
Fen. Ants ID, WRSCai
Com,'
BeatIonO2 •Equipmem Description Delon.
Dotalied :unit
Emission rodp Control Device
Orqu
xdonm-Pmemeine Rate Information tarunations Eatimstes
anaa
Ca ndant., mrougitpet. ;=;a6'.
mughaut=
net, m Emit(PTO Condensate
Throughput.
waion and.
Heatcontent of waste 605.
Volume va¢e gas emitted per Bator
tqunis produced.)y 7:; fool 003690375Actual ha
Ren netted heat ton lent or waste nos ro a ed m combustion denim.
'Barrels ObbIt per ear
<Barrels per veer el) ted Atorahlynrougnoutc
Barrels OA per year
0999884 modeled sel/Der
ae3mt Barrels lbbll permonm
Paandai m Emit (PTE) h eaaonen t orwste gm routed m mmbuton device -
Control Devito
9,0142 WARM per tear
1.0.5 CRAM, per tear
1041,0 NARA0itl per year
Radian D4-EmWlons Facton& Methodologies
WS] nb storage 8493 unit9 9Iemasip030
Po Mont
NIEMEN
[Waste es
co 1 Aeon
(laden,.[.
mno 6 Pop
fmCtsion Factor Source
Pollutant
EMME
cam near
(Patna
Enlist,. Factor sou.
Seaton C6 - Emissions Inventory
02234931318 10/bbl rash (oar
013309061 mromWhe0(total)
• 0.302754069
0.234021.749 tctr.6
0.09567956 MSC
0.06474093 vrtlt
2212496383 wtrd
0.00737601S tun{
005105,1
Regd.. 7,3aCtlen D E. F
Peculation 7,Settlon 1.111.9 C.1, C.3
Vtorodatontirtunmetroncenirdion,SectFor,dR.C.2
eguladon 6, PartP, NEPs5ubpart
o00M000c
¢uladnn 8 Porte, Nn0Subpartx6
(9..nwlaaN '00 II, billy 000doln..0 tot ewoll.4 .oalnl)
20,6
Condensate Storage 7aak(s; Ennenions eventora
Section. Inttal end PedodfcSempllngand Testing Requirements
Does the company use the sa@ d efault emIssiom factorsm estim I've, Ple orrequested fons estmated On greater 'Tan or equal BO tons L per year? P,M,rno
byes, Ole per. lull colntal, annled als tla Compliance. �lsamonn roi.remen=dvelop a sire spec rtmcemlasmnamIazmrtased on...fines In oFoi.m
Does the companyuse a site specific emissions rector to esemate emtssionsiYeh
Ryes and If there are faze emasans, are the emissions factors based one press%ed liquid sample drawn..
facility being permftedi This sample shouldbe considered representative whmn generally means almspeclfic and
one year of the appkation received dam. However, If thefanlnyhm not been modified (e.g., no
new wells inel, then it may be olderpetlfk sample.
If no, theperminual con. an 'Initial mmpl adre.trsti g requlremer[m develop a dtespenfic emasais factor hazed on guldellnes In P5 Memo osog.
Does,. company Iles, the perramdll moues. cntain acontrol
Initial compliance test co tllbon m demonstrate the deroucdon efficiency ofthe combustion nevi a basetl on Inlet and outlet concentration samoling
,dc fngapre �vmpk', onswete is of
3 ', g ng mull esmmgemnkh.... tedm ng E.
MRS Polntg
section.- Inventory seeEmtegand Emissions faders
"1.7" 1EVIzzamagmmenningasescasse
Uncontrolled
Emluiona
% en030wmmcnndensamthroughput
10,00 pillar. condeneatethmughput
bn..Dgallons condensate throughput
VOL I2/1.000gellons condenarethmugheet
CO 0 4/1.000 gallons condensate thmughpu c
ut
Toluene 13/1..0 voomwndensa5throughout
Nylbehsene b/I,DeD plans condensate throughput
xw=ne n/>..n gallons condensate
b/t.Doo eoghne
MINT13It,.D�uon: onagnaeremrpnghwt
x:\PA\nrss\9wEanucnl.okm
cunden.. Tank xagalamry Anal,* Workehret
colonao wei s„b.,ouln..:..enn..nen.ra::o.,. ounce e°uir.menn
1. Are Lintomreued&dual eml++:omtrom any c.d.. pollutantshernMalndMmuel uure ester than3lPl lPe¢umtlonn, Port A,seetbnllo.l.ali
2, ate (serviceaab prior 13004�ani not medal. ameni/36pm3 (seers memo 06o1uennaleml.n andl.1andse.en von additional ¢manna on grandfather appntanxmR
3. Are inulaciliy uncontrolled VOL emissions greater than 517,/,140.4greater than wTw or. CO emissions greaterMn1,7/ weFnmlan 3. Pat B. Section n.D.3)3
I Y., ea,rrnmrolw,fi3:,aen:-,1,21 n-s:ri:,.rne,rti
1. Are uncontrolled emiwonsfrom anvolteria pollutants lmm this inabdwal source greater man 1 TA, (PhiuiatIon3.Pan A.sectinil.0.ialt
ate laemladatal prior t.W3afG�amnot moo daltor,i/31afl3(see F5 Memo 3501De6nkln+1.nandv4amSeen,leracin.nm wwa332en ganmabern3imwhyit
S. Amtmal facility uncontrolled we emt.anneater than ]Tw.xOv greater than 5tpvered emissions. greater limn 10 TP/ lAeeumtmn 3 Pan B,5mna.B.31t
Ia.dq Pegu mbn 3, s.exar,ILE-F
1 IsMisslonge tank loatetl line.r mane control area orany ozone eon,riainmentarta mndmalenamearta?
Mils�nfi oapeaden.natra ganmmatarn.bn or natural taaddPataNant
3. d
IRm
San gal Pegnlremem.brurMI.., Control Equipment-Pre,.mtrenwt awte
section -Emissions [envoi Requirements
Saba ISLE -Monitoring
sectbny.ILF-ReLordimeeing and Rep. -tine
Cebrade P.umbn3.seemn bg0
1. lath's storage tankpated In the 8-hrcrane control armor any ozone en.anammenarea orammmentmtamtenaneeareal
3. ['cull. raget ,e.g. storing nnmaah'laednnamtemadenaand have uncontrolled actual dmbabna[realer Man or equal M3 Iona peryarvoa
Sect. 16I.C.1 -General liegUirements for senlan.lr,1-emi.len eatlmatbn,e.ed6me Con CentralFgmpmna-Pr.venen elLedage
gulmbnt,smrbn %tni
1. lathistanklocred eta transmission/storage Malty?
YIeated annxand gas eapbratwn and preduobn operation ,well production faelllty..n.ral gas cempreuerssiere er natural w+ promxdna planet3. MIAs condensate stomp tank a fixed roof sloragetan.
Sawa lieglilms an VEX.. to the nertquestion
Gate next
P.eeu Strul, permn
Continue -Vex, haw Md.. Me etc arramment status enthe proket ;• t.«^ r. Canna, minue.u
indicated the bailey type nUmpmjectmMmw a a :seer. .
r.a Jyaage vkla otsubjemtlnadndlxvatalmm�t,al.G.Vo heIndlonmma,v+hat.
Tank b 5,m subjectto xwlm ion t, stetmn 5,1.0 - rat a have nairnea IxI Bty Noe on project summary elan.
gy`+erM
�Rnrv6o un,ttaubn...m PewlaNui... see.t.. k.11. e,..ta.3
Section xVILG3.Aea.keeing Aequinments
Smmonxmbez•Gptureaed Nonnnnefor nm¢eTanla fitted udm nn Pollution Control Equpment
40 UP Part60.5Oeart 1. Is the Individual ay« ara¢e vessel equal. 5T cubic meters (m)2'02 BOLA,
petathe weasel bua anip cape, lets than Dr equal. m'110,0368l used ate sw.2.#1332 2mn,ree p.2 oemmy tm,mda defined in 611.11.107
3. ...MN condensate storage OA masted, rmnarwd,ermmmed(recedexhw:s.CFA,60.314 rt1,433,lsutnd.n
Continue -You have...Atha source otegory on Me nefect airman/sheet.
Do lathe nett guest. -Vou haw Melon. fxlury type on projectsumma, sheet.
Sourcelast:Nett to pans al Peguhtbn3.5ealons YUII.B®G Go tothe nett questlan
I'J5 rce ism.= a p:ewmn+ of Beguumn3.seobn m, bae.on+eee
,F71 -
Wax
5. Coes the zterage 'ousel stem a 'wig,. em. leuld N:l as
6. B eaempnvn:l�
a. la the ...Min.( era..
epmrteie ml0asw, Vas.'t land *Maul mnlssbns.,. nmaphae(60.1(ah(dilil43:or
b. Ifiedasien aadryh8,3 man art.,'(0ssl m'(4sm MUM Term algmawln a maunum true raper pressure.lea n5GB.11B3I9IR:or
c. The design caw., n gmeatin or equal',SM.['nzSKI but lesethan151 ma(-vaeetlana dosage.... mamum.e wrermum essman]5D.$0.11.0W,
2 Bees eaemptbn'tmm control rnuiremeeM.
ap•mvnsgreater r equal to m'[re50 BBL]and stores aqud.. a maximum (Neva, pressure greater than or equal to 3.swa n:tlmuan5zwat an
Ile capacity is ear, atex Maor equal tolsq']-gn Bey but less than 151 ei',950 anti and storm aliquid with a mavlmum true weer-measure®eatermn oreeual 15.11 icon but leolhanns WO
1_.amm, ..i,nbn:,..I,gd..,5,P. a.. I
40CP, Pan 60,wbwrt 0000/0000a, 5anda:aa of performance far Crude on and Natural Gn Production, Transmission and Distribution
1. enedeniate facility In Me ensneaeB and natural pa pmauctlen segment, natural, prew+ingsegment or natural gas tanrmlaen and ston=e segment or the Indust,
1. Was tfle condensate storageves.1 constructed,rem,mnctm,or modiM(scaexnlmns40CFA,60..x]between August 33, 3015,
4. 3. Waathis n modified tree Dal eon September]& x015,
5, Doeathlacondensate meet the rierfnitbn of"sterage Vase,'50.5460/60.6430a,
6. lathe wblect to Vessel
ntMminaa®raaawrcb iqu emsfer ssmaw+selslnaaefn wnaoaboan Kb or nCFapart 635utmrt x143
Rnraao.sum x ax.2.13/2toau.t00,wa
]Note: Ha se ragntaal lawetbr3eMedie aw.vate 115s3o00o/oaooa duets eMe+ba+ahw6tn+ pertearwe on the app¢obmy determination dne.asharN remain vpea to lops DODO/0000a per
5o5365103]/GD.s3G5NeN3lw32223 n pmembiwe.m'u+an+a:opbeb,astanperyael
Subpart MAR N N. rag and Gas Pv4caien Faca.
1. la le Q =nee tank mratedx n Wand natural gas ,mdmtbnnaerythat meeaertner afore followne atterb:
a. Madill, Con womsa, Upgrades custom hydrocarbon ile ds'Iai.3BIXa1kIL OR
oat umi wirierw po t... natural oaentera natural w tansmlae= len and stomp low. a=wry or tl.ma ton final end Later' i6.3601u11'311P
3. Isle tank loaaamawlnythat major'br Rant u+',..' Renee Tank is net suhleamnRSeX-Them are 5,e ms>=Txx M...n. faranln.lam.aurm
Storage Tank is not salec.5P5 0000 -Go ta not question to continue determination N5P5 0000a applini.v.
Storage Tank is n« beget NSP50000a.
4, [Martha lank meal Me definition of 'Vora. vessel with the potential ler flash emlisions.' per 63,617
�'l�xkdr
463.3GB. Emmlona cntrol Star..
963.'713-Menitorine
4B3.i3A-Aemrakevpne
463.773-pepenlne
Ma Ream
PACI,Anw moulred fleimiatien deee not apply AND Fl Me tan. In the nee-altarnmantama. II the tank mt. lx,th criterSa,Men rev.ultAR requirements.
Disclaimer
�rm applia+ain bayot6requirementsdbe eleanuraa rmimplementissranwana:a,atdna0rarty eneaCommissionawctccume5lxrct
mpm le.4 a�6t+ml.rstmsammaymtw lappy to aparwss.mn eased Ipso the im'vei.lreds anti ha aw. -tic itve dcc orre,rtes+rragvyamw iatinna In iyaw,rwwetia,,
cr Mer*al bimtareq.emm 1st gory mbmee. In tietruce,tdurntnrrli'cirlsMna,li. language db.dcl3 3.2233yivageameneanavac, ib implemntlngN.J ,
and Due2I',emba r3 'smlaywwiw, arbeatentan blgn Wim,ha, rheas. rnaruerd3M iengape arch as'm•.'-+—may. shouH"md.cen. it to
desvilm tavprelam:a ae re-arurwawnvac krybavmbiyv2ch as'must am'reµieeare WaiWlmdmoibe con.. naryinamsra, to r.. berm abMeivn A4 MI end00
ou.ilyCo.ICommis* rmalataa. bmla d<wre0damnot =baehkya2binding ,wiemnb 2,022804381
COLORADO DEPARTMENT OF PUBLIC HEALTH AND ENVIRONMENT
- AIR POLLUTION CONTROL DIVISION
FACILITY EMISSION SUMMARY
Company Name
County AIRS ID
Plant AIRS ID
Facility Name
HlphPoint Operating Corporation
123
AO3C
RSU Anschutz Fed 4-62-11 12 SE10
History File Edit Date
614/2019
Ozone Status
Non -Attainment
EMISSIONS - Uncontrolled (tons per year
EMISSIONS With Controls (tons per year
POINT
AIRS
ID
PERMIT
Description
PM10
PM2.5
H2S
SO2
NOx
VOC
Fug
VOC
CO
Total
HAPs
PM10
PM2.5
H2S
SO2
NOx
VOC
Fug
VOC
CO
Total
HAPs
REMARKS
Previous FACILITY TOTAL
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
New Facility - No Previous Total (previous history file
was completed for GP02 app received prior to points
002-004 but represent the same project (wells DOFP
4/5119)
Previous Permitted Facility total
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
001
GP02
Caterpillar G3408TA, 400 hp, SN:
6N800484
101.4
2.7
7.7
0.8
3.9
2.7
7.7
0.3
no change
002
19WE0730
Condensate tanks
0.4
230.0
1.7
7.1
0.4
11.5
1.7
0.4
New CP
003
19WE0731
Condensate Loadout
0.1
36.9
0.3
1.1
0.1
1.9
0.3
0.1
New CP
004
GP08
Produced water tanks
50.6
4.1
5.9
0.2
New CP
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
XA
External Combustion sources
0.200
0.200
0.200
3.1
0.20
-
2.6
0.0
0.200
0.200
0.200
3.1
0.20
2.8
0.0
XA
Fugitives
0.6
0.0
0.6
0.0
0.0
0.0
FACILITY TOTAL
0.2
0.2
0.2
0.0
104.9
320.4
0.6
12.3
13.2
0.2
0.2
0.2
0.0
7.4
22.2
0.6
12.3
0.9
VOC: Syn Minor (NANSR and OP)
NOx: Syn Minor (NANSR and OP)
CO: True Minor (PSD and OP)
HAPS: True Minor
HH: True Minor + no TEG dehy
ZZZZ: True Minor
Permitted Facility Total
0.0
0.0
0.0
0.0
101.8
320.2
0.0
9.7
13.2
0.0
0.0
0.0
0.0
4.3
22.0
0.0
9.7
0.9
Excludes units exempt from permits/APENs
(A) Change in Permitted Emissions
0.0
0.0
0.0
0.0
4.3
22.0
0.0
9.7
Pubconl required based on new synthetic minor
limits for VOC (NANSR)
Note 1
Total VOC Facility Emissions (point and fugitive)
(r1) Change in Total Permitted VOC emissions (point and fug rive)
22.8
Facility is eligible for GP02 because < 90 tpy
Modeling not required based on project emissions.
22.0
Note 2
Page 5 of 6
Printed 10/15/2019
COLORADO DEPARTMENT OF PUBLIC HEALTH AND ENVIRONMENT
AIR POLLUTION DIVISION
FACILITY EMISSION SUMMARY - HAPs
Company Name HighPoint Operating Corporation
County AIRS ID 123
Plant AIRS ID
Facility Name
AO3C
RSU Anschutz Fed 4-62-11_12 SE10
Emissions - uncontrolled (Ibs per year
POINT
PERMIT Description
Formaldehyde
Acetaldehyde
Acrolein
Benzene
Toluene
Ethylbenzene
Xylenes
n -Hexane
McOH
224 TMP
H2S
TOTAL (tpy)
Previous FACILITY TOTAL
0
0
0
0
0
•
0
0
0
0
0
0
0.0
001
GP02
Caterpillar G3408TA, 400 hp, SN: 6NB00484
1468
69
65
39
14
1
5
28
0.8
002
19WE0730
Condensate tanks
1516
1172
148
324
11082
37
7.1
003
19WE0731
Condensate Loadout
243
188
24
52
1776
6
1.1
004
GPO8
Produced water tanks
1823
1105
141
353
4700
4.1
0.0
0.0
0.0
0.0
0.0
XA
External Combustion sources
0.0
XA
Fugitives
0.0
0.0
TOTAL (tpy)
0.7
0.0
0.0
1.8
1.2
02
0.4
8.8
0.0
0.0
0.0
0.0
13.2
'Total Reportable = all HAPs where uncontrolled emissions > de minimus values
Red Text: uncontrolled emissions < de minimus
Emissions with controls (Ibs per year
POINT PERMIT Description
Formaldehyde
Acetaldehyde
Acrolein
Benzene
Toluene
Ethylbenzene
Xylenes
n -Hexane
McOH
224 TMP
H2S
TOTAL (tpy)
Previous FACILITY TOTAL
0
0
0
0
0
0
0
0
0
0
0
0
0.0
001
GP02
Caterpillar G3408TA, 400 hp, SN: 6NB00484
352
69
65
39
14
1
5
28
0.3
002
19WE0730
Condensate tanks
76
59
7
16
554
2
0.4
003
19WE0731
Condensate Loadout
12
9
1
3
89
0.3
0.1
004
GP08
Produced water tanks
91
55
7
18
235
0.2
0.0
0.0
0.0
- 0.0
0.0
XA
External Combustion sources
0.0
XA
Fugitives
0.0
0.0
TOTAL (tpy)
0.2
0.0
0.0
0.1
0.1
0.0
0.0
0.5
0.0
0.0
0.0
0.0
0.9
6
19WE0730.CP1.xlsm 10/15/2019
Condensate Storage Tank(s) APEN
Form APCD-205
Air Pollutant Emission Notice (APEN) and
Application for Construction Permit
All sections of this APEN and application must be completed for both new and existing facilities, including APEN
updates. Incomplete APENs will be rejected and will require re -submittal. Your APEN will be rejected if it is
filled out incorrectly, is missing information, or lacks payment for the filing fee. The re -submittal will require
payment for a new filing fee.
This APEN is to be used for tanks that store condensate associated with oil and gas industry operations. If your
emission source does not fall into this category, there may be a more specific APEN available for your source (e.g.
crude oil storage tanks, produced water storage tanks, hydrocarbon liquid loading, etc.). In addition, the General
APEN (Form APCD-200) is available if the specialty APEN options will not satisfy your reporting needs. A list of all
available APEN forms and associated addendum forms can be found on the Air Pollution Control Division (APCD)
website at: www.colorado.gov/pacific/cdphe/air-permits.
This emission notice is valid for five (5) years. Submission of a revised APEN is required 30 days prior to expiration
of the five-year term, or when a reportable change is made (significant emissions increase, increase production,
new equipment, change in fuel type, etc.). See Regulation No. 3, Part A, II.C. for revised APEN requirements.
Permit Number:
f // WE 0 730 AIRS ID Number: 1 23 / A03CD62,
[Leave -blank untess_APCD has already assigned a permit #and AIRS ID]
Section 1 Administrative Information
Company Name': HighPoint Operating Corporation
Site Name: RSU Anschutz Fed 4-62-11_12 SE10 Pad
Site Location: NESE SEC10 T4N R62W
Mailing Address:
(Include Zip Code) 555 17th St., Suite 3700
Denver, CO 80202
Site Location
County: Weld
NAICS or SIC Code: 211111
Contact Person:
Phone Number:
E -Mail Address2:
Marsha Sonderfan
(303) 312-8524
CDPHE_Corr@hpres.com
1 Use the full, legal company name registered with the Colorado Secretary of State. This is the company name that will appear
on all documents issued by the APCD. Any changes will require additional paperwork.
2 Permits, exemption letters, and any processing invoices will be issued by the APCD via e-mail to the address provided.
Form APCD-205 - Condensate Storage Tank(s) APEN - Revision 3/2019 1 I AV
401902
COLORADO
ifl.,.
N�?4h E €nrtb+!mem
Permit Number:
AIRS ID Number: 123 /A03Ct
[Leave blank unless APCD has already assigned a permit # and AIRS ID]
Section 2 - Requested Action
❑Q NEW permit OR newly -reported emission source
❑✓ Request coverage under traditional construction permit
❑ Request coverage under a General Permit
❑ GP01 0 GP08
If General Permit coverage is requested, the General Permit registration fee of $312.50 must be
submitted along with the APEN filing fee.
=OR-
❑ MODIFICATION to existing permit (check each box below that applies)
O Change in equipment 0 Change company name3
❑ Change permit limit ❑ Transfer of ownership' 0 Other (describe below)
-OR
❑ APEN submittal for update only (Note blank APENs will not be accepted)
ADDITIONAL PERMIT ACTIONS -
❑ APEN submittal for permit exempt/grandfathered source
❑ ' Limit Hazardous Air Pollutants (HAPs) with a federally -enforceable limit on Potential To Emit (PTE)
Additional Info & Notes:
3 For company name change, a completed Company Name Change Certification Form (Form APCD-106) must be submitted.
4 For transfer of ownership, a completed Transfer of Ownership Certification Form (Form APCD-104) must be submitted.
Section 3 - General Information
General description of equipment and purpose: ` Ten (10) 400 bbl condensate storage tanks
Company equipment Identification No. (optional):
For existing sources, operation began on:
For new or reconstructed sources, the projected start-up date is: 04/05/2019
Normal Hours of Source Operation: 24
Storage tank(s) located at:
hours/day 7 days/week 52
❑� Exploration & Production (EEtP) site
weeks/year
❑ Midstream or Downstream (non E&P) site
Will this equipment be operated in any NAAQS nonattainment area?
GI
Yes
•
No
Are Flash Emissions anticipated from these storage tanks?
El
Yes
■
No
Is the actual annual average hydrocarbon liquid throughput ≥ 500 bbl/day?
SI
Yes
■
No
If "yes", identify the stock tank gas -to -oil ratio:
0.001142
m3/liter
Are these storage tanks subject to Colorado Oil and Gas Conservation Commission (COGCC)
805 series rules? If so, submit Form APCD-105.
Yes
No
■
D
Are you requesting ≥ 6 ton/yr VOC emissions (per storage tank), or are uncontrolled actual
emissions ≥ 6 ton/yr (per storage tank)?
Yes
No
0
■
Form APCD-205 - Condensate Storage Tank(s) APEN - Revision 3/2019
COLORADO
2 Ay
Permit Number:
AIRS ID Number: 123 /A03C/
[Leave blank unless APCD has already assigned a permit # and AIRS ID]
Section 4 Storage Tank(s) Information
Actual Annual Amount
(bbl/year)
Requested Annual Permit Limits
(bbl/year)
I Condensate Throughput:
420,700
From what year is the actual annual amount?
Average API gravity of sales oil: 43.5 degrees
Tank design: 0 Fixed roof ❑ Internal floating roof
2019
504,840
RVP of sales oil: 6.1
❑ External floating roof
Storage
Tank ID
# of Liquid Manifold Storage
Vessels in Storage Tank
Total Volume of
Storage Tank
(bbl)
Installation Date of Most
Recent Storage Vessel in
Storage Tank (month/year)
Date of First
Production'
(month/year)
Cond. Tks
10
4,000
08/2018
04/2019
API Number
_- Wells Serviced by this Storage Tank or Tank Battery6 (E&P Sites On y)
Name of Well
Newly Reported Well
Please see Addendum
5 Requested values will become permit limitations. Requested limits) should consider future growth.
6 The L&P Storage Tank APEN Addendum (Form APCD-212) should be completed and attached when additional space is needed to
report all wells that are serviced by the equipment reported on this APEN form.
Section 5 - Stack Information
Geographical Coordinates
(Latitude/Longitude or UTM)
40.3245 / -104.303494
Operator Stack
ID No.
Discharge Height Above
Ground Level (feet)
Temp.
(°F) _
Flow Rate
(ACFM)
Velocity
(ft/sec);_
ECD
—20
TBD
TBD
TBD
Indicate the direction of the stack outlet: (check one)
❑� Upward O Downward
❑ Horizontal
O Other (describe):
Indicate the stack opening and size: (check one)
[] Circular
❑ Square/rectangle
❑ Other (describe):
O Upward with obstructing raincap
Interior stack diameter (inches): 84
Interior stack width (inches):
Interior stack depth (inches):
Form APCD-205 - Condensate Storage Tank(s) APEN - Revision 3/2019
COLORADO
3 I Aiatt*i. &4
Permit Number:
AIRS ID Number: 123 / A03C /
[Leave blank unless APCD has already assigned a permit # and AIRS ID]
Section 6 - Control Device Information
0 Check this box if no emission control equipment or practices are used to reduce emissions, and skip to the next section.
Vapor
O Recovery
Unit (VRU):
Pollutants Controlled:
Size: Make/Model:
Requested Control Efficiency: %
VRU Downtime or Bypassed (emissions vented):
Combustion
Device:
Pollutants Controlled: VOC, HAPs
Rating: TBD
Type:
ECD
MMBtu/hr
Make/Model Three (3) Cimarron 84" ECDs
Requested Control Efficiency: 95
Manufacturer Guaranteed Control Efficiency: 98 %
Minimum Temperature: N/A Waste Gas Heat Content: ' 2,858 Btu/scf
Constant Pilot Light: ❑✓ Yes 0 No Pilot Burner Rating: 0.23 MMBtu/hr
Description of the -closed loop system:
❑ Closed Loop System
O - Other:
Pollutants Controlled:
Description:
Control Efficiency Requested:
Section 7 - Gas/Liquids Separation Technology Information (EttP Sites Only)
What is the pressure of the final separator vessel prior to discharge to the storage tank(s)? ^-4 psig
Describe the separation process between the well and the storage tanks: The well fluids initially flow
through the seven (7) inlet 3 -phase separators, through the one (1) heated flash gas separator
(heater treater), then through three (3) VRTs, and finally to the condensate- storage tanks.
Form APCD-205 - Condensate Storage Tank(s) APEN - Revision 3/2019
COLORADO
4 I Or1,==
VOC
Permit Number:
AIRS ID Number: 123 /A03C f
[Leave blank unless APCD has already assigned a permit # and AIRS ID]
Section 8- Emissions Inventory Information
Attach all emissions calculations and emission factor documentation to this APEN form.
If multiple emission control methods were identified in Section 6, the following table can be used to state the
overall (or combined) control efficiency (% reduction):
Descriptionof Control Method(s)
Overall Requested Control
Efficiency
(% reduction in emissions)
ECD
95
NOx
CO
HAPs
Other:
ECD
95
From what year is the following reported actual annual emissions data?
2019
Criteria -Pollutant -Emissions Inventory
Pollutant
Emission Factor
Controlled
Emissions8
(tons/year)
Requested Annual Permit
Emission Limit(s)5
Uncontrolled
Basis
Units
Source -
(AP -42,
Mfg., etc.)
Uncontrolled
Emissions
(tons/year)
Uncontrolled
Emissions
(tons/year)
Controlled
Emissions
(tons/year)
VOC
0.9112
lb/bbl
Eng. Est.
191.67
9.58
230.00
11.50
NOx
0:068
lb/MMBtu
AP -42
0.31
0 37
CO
0.31
Ib/MMBtu
AP -42
1.40
1.68
on Criteria-Reportable.:Pollutant.EmissionsInventory _
Chemical Name
Chemical
Abstract
Service (CAS)
Number
Emission Factor'
Actual Annual Emissions
Uncontrolled
Basis
Units
Source
(AP -42,
Mfg., etc.)
Uncontrolled
Emissions
(pounds/year)
Controlled
Emissions8
(pounds/year)
Benzene
71432
0.0030
lb/bbl
Eng. Est.
1,264
63
Toluene
108883
0.0023
lb/bbl
Eng. Est.
977
49
Ethylbenzene
100414
Xylene
1330207
0.0006
lb/bbl
Eng. Est.
270
14
n -Hexane
110543
0.0220
lb/bbl
Eng. Est.
9,235
462
2,2,4-
Trimethylpentane
540841
5 Requested values will become permit limitations. Requested limit(s) should consider future growth.
7 Attach condensate liquid laboratory analysis, stack test results, and associated emissions calculations if you are requesting site
specific emissions factors according to the guidance in PS Memo 14-03.
8 Annual emissions fees will be based on actual controlled emissions reported. If source has not yet started operating, leave
blank.
Form APCD-205 - Condensate Storage Tank(s) APEN - Revision 3/2019
COLORADO
5j ��
a x�x� s € a�em
Permit Number:
AIRS ID Number: 123 /A03C /
[Leave blank unless APCD has already assigned a permit # and AIRS ID]
Section 9 - Applicant Certification
I hereby certify that all information contained herein and information submitted with this application is complete,
true, and correct. If this is a registration for coverage under General Permit GP01 or GP08, I further certify that
this source is and will be operated in full compliance with each condition of the applicable General Permit.
JAffikeditk tA
Signature of Legally Authorize erson (not a vendor or consultant) Date
Marsha Sonderfan Senior EHS Specialist
Name (print) Title
Check the appropriate box to request a copy of the:
✓❑ Draft permit prior to issuance
ID Draft permit prior to public notice
(Checking any of these boxes may result in an increased fee and/or processing time)
This emission notice is valid for five (5) years. Submission of a revised APEN is required 30 days prior to expiration
of the five-year term, or when a reportable change is made (significant emissions increase, increase production,
new equipment, change in fuel type, etc.). See Regulation No. 3, Part A, II.C. for revised APEN requirements.
Send this form along with $191.13 and the General Permit
registration fee of $312.50, if applicable, to:
Colorado Department of Public Health and Environment
Air Pollution Control Division
APCD-SS-B 1
4300 Cherry Creek Drive South
Denver, CO 80246-1530
Make check payable to:
Colorado Department of Public Health and Environment
For more information or assistance call:
Small Business Assistance Program
(303) 692-3175 or (303) 692-3148
APCD Main Phone Number
(303)692=3150
Or visit the APCD website at:
https://www.colorado.Qov/cdphe/apcd
Form APCD-205 - Condensate Storage Tank(s) APEN - Revision 3/2019
COLORADO
0.x......m N Pub.
FM?nTFEnvrtP�rneM
Hello