HomeMy WebLinkAbout20133097.tiffSTATE OF COLORADO
John W. Hickenlooper, Governor
Larry Wolk, MD, MSPH
Executive Director and Chief Medical Officer
Dedicated to protecting and improving the health and environment of the people of Colorado
4300 Cherry Creek Dr. S.
Denver, Colorado 80246-1530
Phone (303) 692-2000
Located in Glendale, Colorado
www.colorado.gov/cdphe
Weld County Clerk & Recorder
1402 N 17th Ave
Greeley, CO 80631
October 29, 2013
Dear Sir or Madam:
Laboratory Services Division
8100 Lowry Blvd.
Denver, Colorado 80230-6928
(303) 692-3090
RECEIVED
f.;r:' t
WELD COUNTY
COMMISSIONERS
Colorado Department
of Public Health
and Environment
On November 1, 2013, the Air Pollution Control Division will publish a public notice for EOG Resources, Inc
— Critter Creek 20-24H, in the The Greeley Tribune. A copy of this public notice and the public comment
packet are enclosed.
Thank you for assisting the Division by posting a copy of this public comment packet in your office. Public
copies of these documents are required by Colorado Air Quality Control Commission regulations. The packet
must be available for public inspection for a period of thirty (30) days from the date the public notice is
published. Please send any comment regarding this public notice to the address below.
Colorado Dept. of Public Health & Environment
APCD-SS-B 1
4300 Cherry Creek Drive South
Denver, Colorado 80246-1530
Attention: Clara Gonzales
Regards,
Clara Gonzales
Public Notice Coordinator
Stationary Sources Program
Air Pollution Control Division
Enclosure
&, > c, tft 1 e&
2013-3097
Division will receive and consider written public comments for thirty calendar days after the date of this Notice.
Any such comment must be submitted in writing to the following addressee:
Laura Strohkirch
Colorado Department of Public Health and Environment
4300 Cherry Creek Drive South, APCD-SS-BI
Denver, Colorado 80246-1530
cdphe.commentsapcd@state.co.us
F
STATE OF COLORADO
COLORADO DEPARTMENT OF PUBLIC HEALTH AND ENVIRONMENT
AIR POLLUTION CONTROL DIVISION
TELEPHONE: (303) 692-3150
CONSTRUCTION PERMIT
PERMIT NO:
11WE1834
Issuance 1
DATE ISSUED:
ISSUED TO: EOG Resources, Inc
THE SOURCE TO WHICH THIS PERMIT APPLIES IS DESCRIBED AND LOCATED AS FOLLOWS:
Oil and gas production facility, known as Critter Creek 20-24H, located at NW NW Section
24, Township 11N, Range 63W, in Weld County, Colorado.
THE SPECIFIC EQUIPMENT OR ACTIVITY SUBJECT TO THIS PERMIT INCLUDES THE FOLLOWING:
Facility
Equipment
ID
AIRS
Point
Description
PW Tank
#1
001
One (1) 400 BBL fixed roof storage tank used to store produced
water. Emissions from this tank are controlled by a smokeless
Cimarron Energy Combustor with 95% efficiency.
Crude Oil
Tanks
002
Six (6) 400 BBL fixed roof storage tanks used to store crude oil.
Emissions from these tanks are controlled by a Cimarron
smokeless vapor combustion unit with 95% efficiency.
Flare
003
One (1) Tornado flare (Manufacturer: Tornado, Model No: 40' Flare
Stack, Serial No: 10763-5) used to combust produced gas vented
from a three-phase separator.
ET #4268
004
One (1) 400 BBL well blowdown tank, Manufacturer: Connor,
Model: EOG #4268, SN: 29278 used when the produced gas
cannot be combusted in the flare.
Truck
Loadout
005
Truck loading of crude oil and produced water.
Fugitive
006
Equipment leaks (fugitive VOCs) from a natural gas production
facility.
THIS PERMIT IS GRANTED SUBJECT TO ALL RULES AND REGULATIONS OF THE COLORADO AIR
QUALITY CONTROL COMMISSION AND THE COLORADO AIR POLLUTION PREVENTION AND
CONTROL ACT C.R.S. (25-7-101 et seq), TO THOSE GENERAL TERMS AND CONDITIONS INCLUDED
IN THIS DOCUMENT AND THE FOLLOWING SPECIFIC TERMS AND CONDITIONS:
AIRS ID: 123/9196/999
Page 1 of 14
Condensate Tank Version 2009-1
EOG Resources, In
Permit No. 11WE18
E18
Issuance 1
ment of Public Health and Environment
Air Pollution Control Division
REQUIREMENTS TO SELF -CERTIFY FOR FINAL AUTHORIZATION
1. Within one hundred and eighty days (180) after issuance of this permit, compliance
with the conditions contained on this permit shall be demonstrated to the Division. It is
the permittee's responsibility to self -certify compliance with the conditions. Failure to
demonstrate compliance within 180 days may result in revocation of the permit.
(Reference: Regulation No. 3, Part B, II.G.2).
2. This permit shall expire if the owner or operator of the source for which this permit was
issued: (I) does not commence construction/modification or operation of this source
within 18 months after either, the date of issuance of this construction permit or the date
on which such construction or activity was scheduled to commence as set forth in the
permit application associated with this permit; (ii) discontinues construction for a period
of eighteen months or more; (iii) does not complete construction within a reasonable time
of the estimated completion date. The Division may grant extensions of the deadline per
Regulation No. 3, Part B, III.F.4.b. (Reference: Regulation No. 3, Part B, III.F.4.)
3. The operator shall complete all initial compliance testing and sampling as required in this
permit and submit the results to the Division as part of the self -certification process.
(Reference: Regulation No. 3, Part B, Section III.E.)
4. The operator shall retain the permit final authorization letter issued by the Division, after
completion of self -certification, with the most current construction permit. This
construction permit alone does not provide final authority for the operation of this source.
EMISSION LIMITATIONS AND RECORDS
5. The owner or operator shall track emissions from all insignificant activities at the facility
on an annual basis to demonstrate compliance with the facility emission limitations as
seen below. An inventory of each insignificant activity and associated emission
calculations shall be made available to the Division for inspection upon request. For the
purposes of this condition, insignificant activities shall be defined as any activity or
equipment, which emits any amount but does not require an Air Pollutant Emission
Notice (APEN).
Total emissions from the facility, including permitted emissions and insignificant
activities, shall not exceed:
• 100 tons per year of any criteria pollutant
6. Emissions of air pollutants shall not exceed the following limitations (as calculated in the
Division's preliminary analysis). (Reference: Regulation No. 3, Part B, Section II.A.4)
Annual Limits:
Facility
Equipment ID
AIRS
Point
Tons per Year
Emission Type
NOx
VOC
CO
PW Tank #1
001
-
0.5
-
Point
Crude Oil
Tanks
002
-
0.4
-
Point
AIRS ID: 123/9196/999
Page 2 of 14
EOG Resources, In
Permit No. 11WE18
Issuance 1
FD Dep ment of Public Health and Environment
Air Pollution Control Division
Flare
003
4.8
76.3
26.1
Point
ET #4268
004
-
7.5
-
Point
Truck Loadout
005
-
10.4
-
Point
Fugitive
006
-
2.4
-
Fugitive
See "Notes to Permit Holder #4" for information on emission factors and methods used to calculate
limits.
Facility -wide emissions of each individual hazardous air pollutant shall be less than 8.0 tpy.
Facility -wide emissions of total hazardous air pollutants shall be less than 20.0 tpy.
Compliance with the synthetic minor status of this facility shall be determined by recording
the facility's annual criteria pollutant emissions, (including all HAPs above the de-minimis
reporting level) from each emission unit, on a rolling (12) month total. By the end of each
month a new twelve-month total is calculated based on the previous twelve months' data.
The permit holder shall calculate monthly emissions and keep a compliance record on site or
at a local field office with site responsibility, for Division review. This rolling twelve-month
total shall apply to all emission units, requiring an APEN, at this facility.
7. Emissions Point 001: Emissions from this point shall be routed to an enclosed flare that
reduces emissions of VOC to the emission levels listed in Condition 6. Operating
parameters of the control equipment are identified in the operation and maintenance
plan. (Reference: Regulation No.3, Part B, Section III.E.)
8. Emissions Point 002: Emissions from this point shall be routed to an enclosed vapor
combustion unit (VCU) that reduces uncontrolled emissions of VOC from the crude oil
tanks to the emission levels listed in Condition 6. Operating parameters of the control
equipment are identified in the operation and maintenance plan. (Reference: Regulation
No.3, Part B, Section III.E.)
9. Emissions Point 003: This emissions point is a separator controlled by a 40' flare stack.
The flare shall reduce emissions of VOC to the emission levels listed in Condition 6.
Operating parameters of the control equipment are identified in the operation and
maintenance plan. (Reference: Regulation No.3, Part B, Section III.E.)
10. Point 006: The operator shall calculate actual emissions from this emissions point
based on representative component counts for the facility with the most recent gas and
liquids analyses, as required in the Compliance Testing and Sampling section of this
permit. The operator shall maintain records of the results of component counts and
sampling events used to calculate actual emissions and the dates that these counts and
events were completed. These records shall be provided to the Division upon request.
AIRS ID: 123/9196/999 Page 3 of 14
EOG Resources, In
Permit No. 11 W E18
Issuance 1
ment of Public Health and Environment
Air Pollution Control Division
PROCESS LIMITATIONS AND RECORDS
11. This source shall be limited to the following maximum processing rates as listed below.
Monthly records of the actual processing rates shall be maintained by the applicant and
made available to the Division for inspection upon request. (Reference: Regulation 3,
Part B, II.A.4)
Process/Consumption Limits
Facility
Equipment
ID
AIRS
Point
Process Parameter
Annual Limit
PW Tank
#1
001
Produced water throughput
73,000 BBUyr
Crude Oil
Tanks
002
Crude oil throughput
127,750 BBUyr
Flare
003
Natural gas flaring
91.25 MMscf/yr
ET #4268
004
Natural gas vented to atmosphere via
emergency tank
0.45 MMscf/yr
Truck
Loadout
005
Crude oil and produced water loading
200,750 BBUyr
Compliance with the yearly throughput limits shall be determined on a rolling twelve (12)
month total. By the end of each month a new twelve-month total is calculated based on
the previous twelve months' data. The permit holder shall calculate each actual monthly
process rate and keep a compliance record on site or at a local field office with site
responsibility, for Division review.
12. Point 001: Records shall be kept in either an electronic file or hard copy provided that
they can be promptly supplied to the Division upon request. All records shall be retained
for a consecutive period of three years.
STATE AND FEDERAL REGULATORY REQUIREMENTS
13. The permit number and AIRS ID number shall be marked on the subject equipment for
ease of identification. (Reference: Regulation Number 3, Part B, III.E.) (State only
enforceable)
14. Visible emissions shall not exceed twenty percent (20%) opacity during normal operation
of the source. During periods of startup, process modification, or adjustment of control
equipment visible emissions shall not exceed 30% opacity for more than six minutes in
any sixty consecutive minutes. (Reference: Regulation No. 1, Section II.A.1. & 4.)
15. No owner or operator of a smokeless flare or other flare for the combustion of waste
gases shall allow or cause emissions into the atmosphere of any air pollutant which is in
excess of 30% opacity for a period or periods aggregating more than six minutes in any
sixty consecutive minutes. (Reference: Regulation No. 1, Section II, A. 5.)
16. This source is subject to the odor requirements of Regulation No. 2. (State only
enforceable)
AIRS ID: 123/9196/999 Page 4 of 14
EOG Resources, In
Permit No. 11 W E18
Issuance 1
ment of Public Health and Environment
Air Pollution Control Division
17. Emissions point 005: the loading of crude oil and produced water into truck tanks shall
be conducted by submerged fill. (Reference: Regulation 3, Part B, III.E)
OPERATING & MAINTENANCE REQUIREMENTS
18. Emissions points 002 and 003: Upon startup of these points, the applicant shall follow
the operating and maintenance (O&M) plan and record keeping format approved by the
Division, in order to demonstrate compliance on an ongoing basis with the requirements
of this permit. Revisions to your O&M plan are subject to Division approval prior to
implementation. (Reference: Regulation No. 3, Part B, Section III.G.7.)
19. Emission point 001:
a. Flares shall be enclosed, have no visible emissions, and be designed so that an
observer can, by means of visual observation from the outside of the enclosed flare,
or by other convenient means approved by the Division, determine whether the flare
is operating properly.
b. If a control device is used to comply with the emission limits of this permit, the
following conditions must be met:
(i)
Leakage of VOCs to the atmosphere must be minimized as follows:
1. Thief hatch seals shall be inspected for integrity annually and
replaced as necessary. Thief hatch covers shall be weighted and properly
seated.
2. Pressure relief valves (PRV) shall be inspected for proper
operation annually and replaced as necessary. PRVs shall be set to
release at a pressure that will ensure flashing, working and breathing
losses are routed to the control device under normal operating conditions.
3. Annual inspections of thief hatches and PRV shall be documented
with an indication of status, a description of any problems found, and their
resolution.
(ii) Control devices shall be adequately designed, and operated and
maintained according to manufacturer specifications to achieve a control
efficiency of at least 95%, and to handle reasonably foreseeable
fluctuations in emissions of VOCs. Fluctuations in emissions that occur
when the separator dumps into the tank are reasonably foreseeable.
(iii) The permittee shall monitor and document the proper operation of the
control device. Time intervals between monitoring shall not exceed 14
days. Indications of improper operation for a flare include, but are not
limited to, absence of pilot light, malfunction of electronic ignition, and/or
presence of smoke. A check box is suitable for recording proper
operation. Improper operation of a control device shall be further
documented with a description of the problem and its resolution, the date
range the control was inoperable, and the produced water production
through the battery during the downtime. During control device downtime,
emissions shall be considered to be uncontrolled.
AIRS ID: 123/9196/999 Page 5 of 14
EOG Resources, In
Permit No. 11WE18
E18
Issuance 1
FD Dep ment of Public Health and Environment
Air Pollution Control Division
COMPLIANCE TESTING AND SAMPLING
Initial Testing Requirements
20. Emissions point 002: The operator shall complete site specific sampling including a
compositional analysis of the pre -flash pressurized crude oil routed to these storage
tanks and a sales oil analysis to determine RVP and API gravity. Testing shall be in
accordance with the guidance contained in PS Memo 05-01. Results of testing shall be
used to determine a site -specific emissions factor using Division approved methods.
Results of site -specific sampling and analysis shall be submitted to the Division as part
of the self -certification and used to demonstrate compliance with the emissions factors
chosen for this emissions point.
21. Emissions points 003 and 004: The operator shall complete an initial site specific
extended gas analysis of the natural gas produced at this site that is either routed to the
open flame flare or vented through the emergency blowdown tank in order to verify the
VOC, benzene, toluene, ethylbenzene, xylenes, n -hexane, and 2,2,4-trimethylpentane
content (weight fraction) of this emission stream used in the permit application. Results
of testing shall be used to determine site -specific emission factors using Division
approved methods. Results of site -specific sampling and analysis shall be submitted to
the Division as part of the self -certification and used to demonstrate compliance with the
emissions factors chosen for this emissions point.
For example, the benzene emission factor shall be calculated according to the following
equation using the benzene weight fraction and the natural gas's average molecular
weight determined in the site -specific gas analysis:
lb benaene lb nol. lb led scf
X = i) enze ewt. frac,.
MMzcf X79.3 scf ycs lbmo4 1MMscf,
22. Point 003: The owner or operator shall demonstrate compliance with Condition 15
using EPA Method 9 to measure opacity from the flare. (Reference: Regulation No. 1,
Section II.A.5).
23. Point 006: Within one hundred and eighty days (180) after issuance of permit, the
permittee shall complete the initial extended gas analysis of gas samples and extended
natural gas liquids analysis of liquids that are representative of volatile organic
compound (VOC) and hazardous air pollutants (HAP) that may be released as fugitive
emissions. This extended gas and liquids analyses shall be used in the compliance
demonstration as required in the Emission Limits and Records section of this permit.
The operator shall submit the results of the gas and liquids analyses and emission
calculations to the Division as part of the self -certification process to ensure compliance
with emissions limits.
24. Point 006: Within one hundred and eighty days (180) after issuance of permit, the
operator shall complete a hard count of components at the source and establish the
number of components that are operated in "heavy liquid service", "light liquid service",
"water/oil service" and "gas service". The operator shall submit the results to the
Division as part of the self -certification process to ensure compliance with emissions
limits.
AIRS ID: 123/9196/999 Page 6 of 14
EOG Resources, In
Permit No. 11W E18
Issuance 1
ADDITIONAL REQUIREMENTS
ment of Public Health and Environment
Air Pollution Control Division
25. A revised Air Pollutant Emission Notice (APEN) shall be filed: (Reference: Regulation
No. 3, Part A, II.C)
a. Annually whenever a significant increase in emissions occurs as follows:
For any criteria pollutant:
For sources emitting less than 100 tons per year, a change in actual emissions of
five (5) tons per year or more, above the level reported on the last APEN; or
For sources emitting 100 tons per year or more, a change in actual emissions of
five percent or 50 tons per year or more, whichever is less, above the level reported
on the last APEN submitted; or
For any non -criteria reportable pollutant:
If the emissions increase by 50% or five (5) tons per year, whichever is less, above
the level reported on the last APEN submitted to the Division.
b. Whenever there is a change in the owner or operator of any facility, process, or
activity; or
c. Whenever new control equipment is installed, or whenever a different type of control
equipment replaces an existing type of control equipment; or
d. Whenever a permit limitation must be modified; or
e. No later than 30 days before the existing APEN expires.
26. Federal regulatory program requirements (i.e. PSD, NANSR or Title V Operating Permit)
shall apply to this source at any such time that this source becomes major solely by
virtue of a relaxation in any permit condition. Any relaxation that increases the potential
to emit above the applicable Federal program threshold will require a full review of the
source as though construction had not yet commenced on the source. The source shall
not exceed the Federal program threshold until a permit is granted. (Regulation No. 3
Part D).
GENERAL TERMS AND CONDITIONS
27. This permit and any attachments must be retained and made available for inspection
upon request. The permit may be reissued to a new owner by the APCD as provided in
AQCC Regulation No. 3, Part B, Section II.B upon a request for transfer of ownership
and the submittal of a revised APEN and the required fee.
28. If this permit specifically states that final authorization has been granted, then the
remainder of this condition is not applicable. Otherwise, the issuance of this construction
permit does not provide "final" authority for this activity or operation of this source. Final
authorization of the permit must be secured from the APCD in writing in accordance with
the provisions of 25-7-114.5(12)(a) C.R.S. and AQCC Regulation No. 3, Part B, Section
III.G. Final authorization cannot be granted until the operation or activity commences
and has been verified by the APCD as conforming in all respects with the conditions of
the permit. Once self -certification of all points has been reviewed and approved by the
Division, it will provide written documentation of such final authorization. Details for
AIRS ID: 123/9196/999 Page 7 of 14
EOG Resources, In
Permit No. 11 W E18
Issuance 1
ment of Public Health and Environment
Air Pollution Control Division
obtaining final authorization to operate are located in the Requirements to Self -
Certify for Final Authorization section of this permit.
29. This permit is issued in reliance upon the accuracy and completeness of information
supplied by the applicant and is conditioned upon conduct of the activity, or construction,
installation and operation of the source, in accordance with this information and with
representations made by the applicant or applicant's agents. It is valid only for the
equipment and operations or activity specifically identified on the permit.
30. Unless specifically stated otherwise, the general and specific conditions contained in this
permit have been determined by the APCD to be necessary to assure compliance with
the provisions of Section 25-7-114.5(7)(a), C.R.S.
31. Each and every condition of this permit is a material part hereof and is not severable.
Any challenge to or appeal of a condition hereof shall constitute a rejection of the entire
permit and upon such occurrence, this permit shall be deemed denied ab initio. This
permit may be revoked at any time prior to self -certification and final authorization by the
Air Pollution Control Division (APCD) on grounds set forth in the Colorado Air Quality
Control Act and regulations of the Air Quality Control Commission (AQCC), including
failure to meet any express term or condition of the permit. If the Division denies a
permit, conditions imposed upon a permit are contested by the applicant, or the Division
revokes a permit, the applicant or owner or operator of a source may request a hearing
before the AQCC for review of the Division's action.
32. Section 25-7-114.7(2)(a), C.R.S. requires that all sources required to file an Air Pollution
Emission Notice (APEN) must pay an annual fee to cover the costs of inspections and
administration. If a source or activity is to be discontinued, the owner must notify the
Division in writing requesting a cancellation of the permit. Upon notification, annual fee
billing will terminate.
33. Violation of the terms of a permit or of the provisions of the Colorado Air Pollution
Prevention and Control Act or the regulations of the AQCC may result in administrative,
civil or criminal enforcement actions under Sections 25-7-115 (enforcement), -121
(injunctions), -122 (civil penalties), -122.1 (criminal penalties), C.R.S.
By:
Laura Strohkirch
Permit Engineer
Air Pollution Control Division
Permit Histo
Issuance
Date
Description
Issuance 1
This Issuance
Facility -wide permit for a new E&P facility issued
to EOG Resources, Inc. This permit
encompasses points 001-006. This facility is
synthetic minor for Title V and PSD.
AIRS ID: 123/9196/999
Page 8 of 14
EOG Resources, In
Permit No. 11WE18
E18
Issuance 1
FD Dep ment of Public Health and Environment
Air Pollution Control Division
Notes to Permit Holder:
1) The permit holder is required to pay fees for the processing time for this permit. An invoice for these fees
will be issued after the permit is issued. The permit holder shall pay the invoice within 30 days of receipt of
the invoice. Failure to pay the invoice will result in revocation of this permit (Reference: Regulation No. 3,
Part A, Section VI.B.)
2) The production or raw material processing limits and emission limits contained in this permit are based on
the consumption rates requested in the permit application. These limits may be revised upon request of
the permittee providing there is no exceedance of any specific emission control regulation or any ambient
air quality standard. A revised air pollution emission notice (APEN) and application form must be
submitted with a request for a permit revision.
3) This source is subject to the Common Provisions Regulation Part II, Subpart E, Affirmative Defense
Provision for Excess Emissions During Malfunctions. The permittee shall notify the Division of any
malfunction condition which causes a violation of any emission limit or limits stated in this permit as soon
as possible, but no later than noon of the next working day, followed by written notice to the Division
addressing all of the criteria set forth in Part II.E.1 of the Common Provisions Regulation. See:
http://www.cd phe.state. co. us/requlations/airregs/100102agcccom monprovisionsreq. pdf.
4) The following emissions of non -criteria reportable air pollutants are estimated based upon the process
imits as indicated in this permit. This information is listed to inform the operator of the Division's analysis
of the specific compounds emitted if the source(s) operate at the permitted limitations.
AIRS
Point
Pollutant
CAS #
BIN
Uncontrolled
Emission
Rate
(Ib/yr)
Are the
emissions
reportable?
Controlled
Emission
Rate (lb/yr)
001
Benzene
71432
A
511
Yes
25.6
n -Hexane
110543
C
1,606
Yes
80.3
002
Benzene
71432
A
108
Yes
5.4
n -Hexane
110543
C
726
No
36.3
003
Benzene
71432
A
6,844.5
Yes
342.2
Toluene
108883
C
5,168.1
Yes
258.4
Ethylbenzene
100414
C
868.9
No
43.4
Xylenes
1330207
C
2,146.6
Yes
107.3
n -Hexane
110543
C
41,959.6
No
2,098.0
004
Benzene
71432
A
33.6
No
n/a
n -Hexane
110543
C
206.1
No
206.1
005
Benzene
71432
A
139.65
Yes
n/a
Toluene
108883
C
457.32
No
n/a
Ethylbenzene
100414
C
33.69
No
n/a
Xylenes
1330207
C
609.36
No
n/a
n -Hexane
110543
C
833.63
No
n/a
006
Benzene
71432
A
7.5
No
7.5
AIRS ID: 123/9196/999
Page 9 of 14
EOG Resources, In
Permit No. 11 W E18
Issuance 1
ment of Public Health and Environment
Air Pollution Control Division
Toluene
108883
C
12.2
No
12.2
Ethylbenzene
100414
C
1.7
No
1.7
Xylenes
1130207
C
4.5
No
4.5
n -Hexane
110543
C
252
No
252
5) The emission levels contained in this permit are based on the following emission factors:
Points 001:
CAS #
Pollutant
Emission Factors
Uncontrolled
Emission Factors
Controlled
Source
VOC
0.262 lb/bbl
0.0131 lb/bbl
PS Memo 09-02
71432
Benzene
0.007 lb/bbl
0.0004 lb/bbl
PS Memo 09-02
110543
n -Hexane
0.022 lb/bbl
0.0011 lb/bbl
PS Memo 09-02
Note: The controlled emissions factors for this point are based on the flare control efficiency of 95%.
Point 002:
CAS #
Pollutant
Emission Factors
Uncontrolled
Emission Factors
Controlled
Source
VOC
0.1314 lb/bbl
0.0066 lb/bbl
E&P Tank
71432
Benzene
8.4 x 10' lb/bbl
4.2 x 10' lb/bbl
E&P Tank
110543
n -Hexane
0.0057 Ib/bbl
2.9 x 10' lb/bbl
E&P Tank
Note:
The controlled emissions factors for this point are based on the flare control efficiency of 95%.
These emission factors were developed using sampling from Critter Creek 2-03H well site
and E&P Tank.
Point 003:
CAS #
Pollutant
Natural Gas
Composition
(Weight %)
Emission
Factors
Uncontrolled
lb/MMscf
natural gas
vented
Emission
Factors
Controlled
lb/MMscf
natural gas
vented
Source
NOx
--
105.33
105.33
AP -42, Table
13.5-1, 1549
Btu/scf
CO
--
573.13
573.13
AP -42, Table
13.5-1, 1549
Btu/scf
VOC
46.18
33,464
1,681.7
Eng.
Calculation
71432
Benzene
0.1029
75.008
3.7504
Eng.
Calculation
108883
Toluene
0.0777
56.636
2.8468
Eng.
Calculation
AIRS ID: 123/9196/999
Page 10 of 14
EOG Resources, In
Permit No. 11WE18
E18
Issuance 1
ment of Public Health and Environment
Air Pollution Control Division
CAS #
Pollutant
Natural Gas
Composition
(Weight %)
Emission
Factors
Uncontrolled
lb/MMscf
natural gas
vented
Emission
Factors
Controlled
lb/MMscf
natural gas
vented
Source
100414
Ethylbenzene
0.0131
9.5216
0.4761
Eng.
Calculation
1330207
Xylenes
0.0323
23.5218
1.1762
Eng.
Calculation
110543
n -Hexane
0.6300
459.8
P3
Eng.
Calculation
Note: The uncontrolled VOC and HAP emissions for this point were calculated using the August 10,
2010 analysis of a gas sample collected from the Critter Creek 2-03-H well. The controlled
VOC and HAP emissions factors for point 003 are based on the flare control efficiency of
95%.
Point 004:
CAS #
Pollutant
Weight
Fraction of
Gas
Emission
Factors
Uncontrolled
Emission
Factors
Controlled
Source
VOC
0.4618
33,333 lb/MMscf
natural gas
vented
--
Eng. Calculation
71432
Benzene
0.0010
74.8 lb/MMscf
natural gas
vented
--
Eng. Calculation
110543
n -Hexane
0.0063
458 lb/MMscf
natural gas
vented
--
Eng. Calculation
The emission levels in this permit for this point are based on the use of this tank to b owdown produced
natural gas when the flare used to combust the natural gas is down at three (3) events per year and
twelve (12) hours of venting through this tank per event at a maximum gas flow rate of 12,458.3 scf/hr.
The VOC content of the produced gas used in the application was based on a gas sample from the
Critter Creek 2-03H well (weight percents for VOC and HAP components from this analysis are listed
in the table above).
AIRS ID: 123/9196/999 Page 11 of 14
EOG Resources, In
Permit No. 11 W E18
Issuance 1
FD Dep ment of Public Health and Environment
Air Pollution Control Division
Point 005:
Note: The emission factor below may be used for both crude oil and produced water loading.
CAS #
Pollutant
Emission Factors
Uncontrolled
Emission Factors
Controlled
Source
VOC
0.104 lb/bbl
--
AP -42
71432
Benzene
0.0007 lb/bbl
--
AP -42
108883
Toluene
0.0023 lb/bbl
--
AP -42
1330207
Xylenes
0.0030 lb/bbl
--
AP -42
110543
n -Hexane
0.0041 lb/bbl
--
AP -42
The uncontrolled VOC emission factor was calculated using AP -42, Chapter 5.2, Equation 1 (version
1/95) using the following values:
S = 0.6 (Submerged loading: dedicated normal service)
P (true vapor pressure) = 5.18 psia
M (vapor molecular weight) = 33.43 Ib/Ib-mol
T (temperature of liquid loaded) = 524 °R
The uncontrolled non -criteria reportable air pollutant (NCRP) emission factors were calculated by
multiplying the mass fraction of each NCRP determined in the pressurized oil analysis by the VOC
emission factor.
Point 006:
Component
Gas Service
Heavy Oil
Light Oil
Water/Oil
Service
Connectors
576
---
520
51
Flanges
8
---
24
4
Open -Ended Lines
9
---
7
5
Pump Seals
---
---
2
---
Valves
56
---
72
24
Other
35
---
15
6
VOC Content (wt%)
3.5%
100%
29.2%
100%
Benzene Content (wt%)
0.023%
0.027%
0.12%
Toluene Content (wt%)
0.039%
0.075%
0.032%
Ethylbenzene (wt %)
0.002%
---
0.017%
0.001%
Xylenes Content (wt%)
0.01%
---
0.036%
0.004%
n -hexane Content (wt%)
0.338%
---
2.43%
---
*Other equipment type includes compressors, pressure relief valves, relief valves, diaphragms, drains,
dump arms, hatches, instrument meters, polish rods and vents
TOC Emission Factors (kg/hr-component):
Component
Gas Service
Heavy Oil
Light Oil
Water/Oil
Service
Connectors
2.0E-04
7.5E-06
2.1E-04
1.1E-04
Flanges
3.9E-04
3.9E-07
1.1E-04
2.9E-06
AIRS ID: 123/9196/999
Page 12 of 14
EOG Resources, In
Permit No. 11 W E18
Issuance 1
FD Dep ment of Public Health and Environment
Air Pollution Control Division
Open-ended Lines
2.0E-03
1.4E-04
1.4E-03
2.5E-04
Pump Seals
2.4E-03
NA
1.3E-02
2.4E-05
Valves
4.5E-03
8.4E-06
2.5E-03
9.8E-05
Other
8.8E-03
3.2E-05
7.5E-03
1.4E-02
Source: EPA -453/R95-017
Compliance with emissions limits in this permit will be demonstrated by using the TOC emission factors
listed in the table above with representative component counts, multiplied by the VOC content from the
most recent gas and liquids analyses.
6) In accordance with C.R.S. 25-7-114.1, each Air Pollutant Emission Notice (APEN) associated with this
permit is valid for a term of five years from the date it was received by the Division. A revised APEN
shall be submitted no later than 30 days before the five-year term expires. Please refer to the most
recent annual fee invoice to determine the APEN expiration date for each emissions point associated
with this permit. For any questions regarding a specific expiration date call the Division at (303)-692-
3150.
7) This facility is classified as follows:
Applicable
Requirement
Status
Operating Permit
Synthetic Minor Source of VOC, Synthetic Minor Source of HAP
PSD
Synthetic Minor Source of VOC
MACT HH
Major Source Requirements: Not Applicable (True minor source of HAP
under Subpart HH)
Area Source Requirements: Not Applicable (Area source requirements only
apply to TEG dehydrators)
8) Full text of the Title 40, Protection of Environment Electronic Code of Federal Regulations can be found at
the website listed below:
http://ccfr.gpoacce: s.govi
Part 60: Standards of Performance for New Stationary Sources
NSPS
60.1 -End
SubpartA— SubpartKKKK
NSPS
Part 60, Appendixes
Appendix A — Appendix I
Part 63: National Emission Standards for Hazardous Air Pollutants for Source Categories
MACT
63.1-63.599
Subpart A — Subpart Z
MACT
63.600-63.1199
Subpart AA — Subpart DDD
MACT
63.1200-63.1439
Subpart EEE — Subpart PPP
MACT
63.1440-63.6175
Subpart QQQ — Subpart YYYY
MACT
63.6580-63.8830
Subpart Z777 — Subpart MMMMM
AIRS ID: 123/9196/999
Page 13 of 14
EOG Resources, In
Permit No. 11WE18
E18
Issuance 1
TDep ment of Public Health and Environment
Air Pollution Control Division
MACT
63.8980 -End
Subpart NNNNN — Subpart XXXXXX
9) An Oil and Gas Industry Construction Permit Self -Certification Form is included with this permit packet.
Please use this form to complete the self -certification requirements as specified in the permit conditions.
Further guidance on self -certification can be found on our website at:
http://www.cdphe.state.co.us/ap/oilgaspermitting.html
AIRS ID: 123/9196/999 Page 14 of 14
Construction Permit Application
Preliminary Analysis Summary
Section 1 — Applicant Information
Company Name:
EOG Resources, Inc.
Permit Number:
11WE1834
Source Location:
NWNW Sec 24, T11N, R63W
Source Name:
Critter Creek 20-24H
Equipment Description:
Point 001- One (1) 400 BBL fixed roof produced water storage tank
Point 002- Six (6) 400BBL storage tanks for crude oil
Point 003 -One (1) Tornado Flare
Point 004- One (1) 400 BBL emergency tank
Point 005- Crude oil and produced water truck loadout
Point 006- Fugitive emissions
AIRS ID:
123-9196
Date:
July 16, 2012
Review Engineer:
Laura Strohkirch
Control Engineer:
Carissa Money
Section 2 — Action Completed
Grandfathered
Modification
APEN Required/Permit Exempt
X
CP1
Transfer of Ownership
APEN Exempt/Permit Exempt
Section 3 — Applicant Completeness Review
Was the correct APEN submitted for this source type?
X
Yes
No
Is the APEN signed with an original signature?
X
Yes
No
Was the APEN filled out completely?
X
Yes
No
Did the applicant submit all required paperwork?
X
Yes
No
Did the applicant provide ample information to determine emission rates?
X
Yes
No
If you answered "no" to any of the above, when did you mail an
Information Request letter to the source?
On what date was this application complete?
May 31, 2011 original application
was received. Fugitives were added
to the facility February 12, 2012.
Section 4 — Source Description
AIRS Point
Equipment Description
001
One (1) above ground 400 bbl atmospheric produced water storage tank. Emissions
from this tank are controlled by a smokeless Cimarron Combustor (SN: 1331244)
with a destruction efficiency of 95%.
002
Six (6) above ground 400 bbl atmospheric crude oil storage tank. Emissions from
these tanks are controlled with a Cimarron Smokeless Combustor (VCU) with 95%
control efficiency.
Page 1
003
One (1) Tornado Flare that is controlling a separator. This is a 40' candlestick flare
that is not enclosed and has been granted 95% destruction efficiency.
004
One (1) above ground 400 bbl atmospheric emergency tank. This tank is used when
there is a need to vent the natural gas from blowdowns of the flare rather than put it
into the pipeline. There are no controls for this tank.
005
Crude oil and produced water truck loadout.
006
Fugitive emission leaks.
Is this a portable source?
Yes
X
No
Is this location in a non -attainment area for any criteria
pollutant?
Yes
X
No
If "yes", for what pollutant?
PM10
CO
Ozone
Is this location in an attainment maintenance area for
any criteria pollutant?
Yes
X
No
If "yes", for what pollutant?
(Note: These pollutants are subject to minor source
RACT per Regulation 3, Part B, Section III.D.2)
PM10
CO
Ozone
Is this source located in the 8 -hour ozone non -
attainment region? (Note: If "yes" the provisions of
Regulation 7, Sections XII and XVII.C may apply)
Yes
X
No
Point 001: Is this source claiming exempt status for
this source based on the fraction of oil in the stored
water (less than 1% by volume crude oil on an average
annual basis)?
X
Yes
No
Point 001: Are these produced water tanks located at
a commercial facility that accepts oil production
wastewater for processing?
Yes
X
No
Point 001: Are these produced water tanks subject to
Colorado Oil and Gas Conservation Commission
(COGCC) 805 Rule?
If so, submit Form APCD-105
Yes
X
No
Section 5 — Emission Estimate Information
AIRS Point
Emission Factor Source
001
CDPHE Emission Factors (PS Memo 09-02)
002
Source used E&P Tanks along with site -specific sampling to calculate a site -
specific emission factor
VOC E.F.= 0.1314 lb/bbl
003
Emission Factors for NOx, Sox, CO and PM10 came from AP -42 Tables 13.5-1&2
VOC emissions are based on a VOC weight -fraction
VOC E.F.= 33,464.1 Ib/MMscf
004
Used maximum gas vented to atmosphere along with VOC weight fraction to
determine a site -specific emission factor.
VOC E.F.= 33,333 Ib/MMscf
005
AP -42, Table 5.2-1, equation 1
006
EPA -453/R-95-017, Table 2-4
Did the applicant provide actual process data for the emission inventory? X Yes No
Basis for Potential to Emit IPTE)
Page 2
AIRS Point
Process Consumption/Throughput/Production
001
73,000 BBL
002
153,300 BBL per year (127,750 x 1.2)
003
250,000 scf/day or 91,250,000scf/yr or 91.25 MMscf/yr
004
448,500 scf/yr or 0.45 MMscf/yr
005
200,750 BBLJyr
006
Equipment Type
Gas
Heavy Oil (or
Heavy Liquid)
Light Oil (or
Light Liquid)
Water/Oil
Connectors
576
---
520
51
Flanges
8
---
24
4
Open -Ended Lines
9
---
7
5
Pump Seals
--
--
2
---
Valves
56
--
72
24
Other
35
•--
15
6
Basis for Actual Emissions Reported During this APEN Filing (Reported to Inventory)
AIRS Point
Process Consumption/Throughput/Production
Data Year
001
73,000 BBL
2011
002
127,750 BBL per year while controls are in operation
2011
003
91.25 MMscf/yr
2011
004
448,500 scf/yr or 0.45 MMscf/yr
2011
005
200,750 BBLJyr
2011
006
Equipment Type
Gas
Heavy Oil
(or Heavy
Liquid)
Light Oil
(or Light
Liquid)
Water/Oil
2011
Connectors
576
---
520
51
Flanges
8
---
24
4
Open -Ended
Lines
9
---
7
5
Pump Seals
---
---
2
---
Valves
56
---
72
24
Other
35
--
15
6
Basis for Permitted Emissions (Permit Limitsl
AIRS Point
Process Consumption/Throughput/Production
001
73,000 BBL
002
127,750 BBL
003
91.25 MMscf/yr
004
0.45 MMscf/yr
005
200,750 BBLJyr
006
Equipment Type
Gas
Heavy Oil (or
Heavy Liquid)
Light Oil (or
Light Liquid)
Water/Oil
Connectors
576
---
520
51
Flanges
8
---
24
4
Open -Ended Lines
9
---
7
5
Pump Seals
--
---
2
---
Valves
56
---
72
24
Other
35
---
15
_6
Does this source use a control device?
X
Yes
No
Page 3
AIRS Point
Process
Control Device Description
% Reduction
Granted
001
01
Cimarron Combustor, SN 1331244
95
002
01
Cimarron Smokeless Combustor (VCU)
95
003
01
Tornado, 40' Flare Stack, SN 10763-5
95
Section 6 — Emission Summary (tons per year)
Point
NO,
VOC
CO
Single HAP
Total HAP
PTE:
001
-
9.6
-
0.8 (n -hexane)
1.06
002
0.03
10.1
0.16
003
4.8
1526.8
26.1
21 (n -hexane)
28
004
-
7.5
-
0.1 (n -hexane)
0.14
005
-
10.4
-
0.42 (n -hexane)
1.04
006
-
2.4
-
0.1 (n -hexane)
0.1
Total (TPY) PTE:
4.83
1,577.3
26.27
30.53
Uncontrolled point
source emission rate:
001
-
9.6
-
0.8 (n -hexane)
1.06
002
0.03
8.4
0.16
0.36 (n -hexane)
0.48
003
4.8
1526.8
26.1
21 (n -hexane)
28
004
-
7.5
-
0.1 (n -hexane)
0.14
005
-
10.4
-
0.42 (n -hexane)
1.04
006
-
2.4
-
0.1 (n -hexane)
0.1
Controlled point
source emission rate:
001
-
0.48
-
0.04 (n -hexane)
0.05
002
0.03
0.4
0.16
0.01 (n -hexane)
0.02
003
4.8
76.3
26.1
1 (n -hexane)
1.4
004
-
7.5
-
0.1 (n -hexane)
0.14
005
-
10.4
-
0.42 (n -hexane)
1.04
006
-
2.4
-
0.1 (n -hexane)
0.1
Total APEN Reported
emissions:
4.83
99.06
027.37
2.47 (n -hexane)
2.94
Section 7 — Non -Criteria / Hazardous Air Pollutants
Pollutant
CAS #
BIN
Uncontrolled
Emission Rate
(Ib/yr)
Are the
emissions
reportable?
Controlled Emission
Rate (Ibryr)
POINT 001
Benzene
71432
A
511.0
Yes
25.6
n -Hexane
110543
C
1,606
Yes
80.3
POINT 002
Benzene
71432
A
108
Yes
5.4
Page 4
n -Hexane
110543
C
726
No
36.3
POINT 003
Benzene
71432
A
6,844.5
Yes
342.2
Toluene
108883
C
5,168.1
Yes
258.4
Ethylbenzene
100414
C
868.9
No
43.4
Xylenes
1330207
C
2,146.6
Yes
107.3
n -Hexane
110543
C
41,959.6
Yes
2,098.0
POINT 004
Benzene
71432
A
33.6
No
NA
n -Hexane
110543
C
206.1
Yes
NA
POINT 005
Benzene
71432
A
139.65
Yes
NA
Toluene
108883
C
457.32
No
NA
Ethylbenzene
100414
C
33.69
No
NA
Xylenes
1330207
C
609.39
No
NA
n -Hexane
110543
C
833.63
No
NA
POINT 006
Benzene
71432
A
7.5
No
7.5
Toluene
108883
C
12.2
No
12.2
Ethylbenzene
100414
C
1.7
No
1.7
Xylenes
1130207
C
4.5
No
4.5
n -Hexane
110543
C
252
No
252
Note: Regulation 3, Part A, Section II.B.3.b APEN erasion reporting requirements for non -criteria air
pollutants are based on potential emissions without credit for reductions achieved by control
devices used by the operator.
Section 8 —Testing Requirements
Will testing be required to show compliance with any emission rate or regulatory
standard?
X
Yes
No
If "yes", complete the information listed below
AIRS Point
Process
Pollutant
Regulatory Basis
Test Method
002
of
VOC
CDPHE PS Memo 05-01
Site -specific
sampling
003
of
VOC &
HAP's
State -only requirement
Site -specific gas
analysis
004
01
VOC &
HAP's
State -only requirement
Site -specific gas
analysis
006
01
VOC,
HAPS
State only requirement
Site -specific gas
analysis
006
01
VOC,
HAPS
State only requirement
Hard component
count
Page 5
Section 9 — Source Classification
Is this a new previously un-permitted
source? (Points 001-006)
X
Yes
No
What is this point classification?
True Minor
Synthetic Minor
Major
Point 001: One (1) 400 BBL fixed roof
produced water storage tank
X
Point 002: Six (6) above ground 400
bbl atmospheric crude oil storage
tank
X
Point 003: One (1) Tornado Flare
X
Point 004: One (1) above ground 400
bbl atmospheric emergency tank
X
Point 005: Crude oil and produced
water truck loadout
X
Point 006: Fugitive VOC emissions
X
What is this facility classification?
True
Minor
X
Synthetic
Minor
Major
Classification relates to what
programs?
X
Title V
X
PSD
NA NSR
X
MACT
Is this a modification to an existing
permit?
Yes
X
No
If "yes" what kind of modification?
Minor
Synthetic
Minor
Major
Section 10 — Public Comment
Does this permit require public comment per CAQCC Regulation 3?
X
Yes
No
If "yes", for which pollutants? Why?
For Reg. 3, Part B, III.C.1.a (emissions increase > 25/50 tpy)?
X
Yes
No
For Reg. 3, Part B, III.C.1.c.iii (subject to MACT)?
Yes
X
No
For Reg. 3, Part B, III.C.1.d (synthetic minor emission limits)?
X
Yes
No
Section 11 — Modeling
Is modeling required to demonstrate compliance with National Ambient
Air Quality Standards (NAAQS)?
If "yes", for which pollutants? Why?
Yes X No
Page 6
AIRS Point
Section 12 — Regulatory Review
Regulation 1 - Particulate. Smoke, Carbon Monoxide and Sulfur Dioxide
001-006
Section II.A.1 - Except as provided in paragraphs 2 through 6 below, no owner or operator
of a source shall allow or cause the emission into the atmosphere of any air pollutant
which is in excess of 20% opacity. This standard is based on 24 consecutive opacity
readings taken at 15 -second intervals for six minutes. The approved reference test method
for visible emissions measurement is EPA Method 9 (40 CFR, Part 60, Appendix A (July,
1992)) in all subsections of Section II. A and B of this regulation.
Section II.A.5 - Smokeless Flare or Flares for the Combustion of Waste Gases No owner
or operator of a smokeless flare or other flare for the combustion of waste gases shall
allow or cause emissions into the atmosphere of any air pollutant which is in excess of
30% opacity for a period or periods aggregating more than six minutes in any sixty
consecutive minutes.
Regulation 2 — Odor
001-006
Section LA - No person, wherever located, shall cause or allow the emission of odorous
air contaminants from any single source such as to result in detectable odors which are
measured in excess of the following limits: For areas used predominantly for residential or
commercial purposes it is a violation if odors are detected after the odorous air has been
diluted with seven (7) or more volumes of odor free air.
Regulation 3 - APENs, Construction Permits. Operating Permits, PSD
001-006
Part A-APEN Requirements
Criteria Pollutants: For criteria pollutants, Air Pollutant Emission Notices are required for:
each individual emission point in an attainment area with uncontrolled actual emissions of
two tons per year or more of any individual criteria pollutant (pollutants are not summed)
for which the area is attainment.
(Applicant is required to file an APEN for points 001-006 since emissions exceed 2
tons per year VOC)
001-006
Part B — Construction Permit Exemptions
Applicant is required to obtain a permit for points 001.006 since uncontrolled VOC
emissions from this facility are greater than the 5.0 TPY threshold (Reg. 3, Part B,
Section II.D.3.a)
005
Part B, III.D.2 - RACT requirements for new or modified minor sources
This section of Regulation 3 requires RACT for new or modified minor sources located in
nonattainment or attainment/maintenance areas. This source is located in the attainment
area, therefore, not subject to RACT. However, operator is using 0.6 (submerged,
dedicated normal service) for its saturation factor.
Regulation 6 - New Source Performance Standards
001,002,004
NSPS Kb: for storage vessels greater than 19,800 gallons after 7/23/84.
Is this source greater than 19,800 gallons (471 bbl)? No
Is this source subject to NSPS Kb? No
003,005,
006
none
Regulation 7 — Volatile Organic Compounds
001,002,004
XII. VOLATILE ORGANIC COMPOUND EMISSIONS FROM OIL AND GAS
OPERATIONS
(Applicant is not subject to the emission control requirements for condensate tanks
since it is located in an attainment area.)
XVII.C STATEWIDE CONTROLS FOR OIL AND GAS OPERATIONS...
(Applicant is not currently subject to this since these are not condensate storage
tanks
003,005,
006
None
Regulation 8 — Hazardous Air Pollutants
Page 7
001, 002,
004
MACT EEEE: Organic Liquids Distribution
• This source is not subject to MACT EEEE because it is located at a "production
field facility' as defined in 40 CFR 63.761 (located upstream of the natural gas
processing plant).
002,004
MACT HH
• This source is not subject to MACT HH because it is not located at a major source
of HAP.
003-006
none
Section 13 — Aerometric Information Retrieval System Coding Information
Point
Process
Process Description
Emission Factor
Pollutant /
CAS #
Fugitive
(Y/N)
Emission
Factor Source
Control
(%)
001
01
E&P Produced
Water Storage
Tanks
6.2381 lb/1000 gal
throughput
VOC
No
CDPHE PS
Memo 09-02
95
0.1667 lb/1000 gal
throughput
Benzene
No
CDPHE PS
Memo 09-02
95
0.5238 lb/1000 gal
throughput
n -Hexane
No
CDPHE PS
Memo 09-02
95
SCC
40400315 — Fixed Roof Tank, Produced Water, working+breathing+flashing losses
Point
Process
Process Description
Emission Factor
Pollutant /
CAS #
Fugitive
(Y/N)
Emission
Factor Source
Control
(%)
002
01
E&P Crude Oil
Storage Tanks
3.129 lb/1000 gal
throughput
VOC
No
Site -specific
95
0.02 lb/1000 gal
throughput
Benzene
No
Site -specific
95
SCC
40400312 — Fixed Roof Tank, Crude Oil, working+ breathing + flashing losses
Point
Process
Process Description
Emission Factor
Pollutant /
CAS #
Fugitive
Y/N
Emission
Factor Source
Control
(%
003
01
Tornado Flare
33,464 lb/MMscf
VOC
No
Mass Balance
95
105.3 lb/MMscf
NOx
No
AP -42
NA
573.1 lb/MMscf
CO
No
AP -42
NA
0.57 lb/MMscf
SOx
No
AP -42
NA
75 lb/MMscf
Benzene
No
Mass Balance
95
56.6 lb/MMscf
Toluene
No
Mass Balance
95
23.5 lb/MMscf
Xylenes
No
Mass Balance
95
459.8 lb/MMscf
n -Hexane
No
Mass Balance
95
SCC
31000205 — Flares (at gas production facility)
Point
Process
Process Description
Emission Factor
Pollutant /
CAS #
Fugitive
(Y/N)
Emission
Factor Source
Control
(%)
004
01
Emergency Tank
33,333 lb/MMscf
VOC
No
Mass Balance
NA
74.6 lb/MMscf
Benzene
No
Mass Balance
NA
458 lb/MMscf
n -hexane
No
Mass Balance
NA
SCC
31000299- Natural Gas Production: other, not classified
Page 8
Point
Process
Process Description
Emission Factor
ollutant
P CAS #/
#
Fugitive (YN
(Y/N)
Emission
Factor Source
Control
(%)
005
01
Crude Oil and Produced
Water Tank Truck
Loadout
2.47 lb/1000ga1
VOC
No
AP -42
NA
0.016 lb/1000 gal
Benzene
No
AP -42
NA
0.098 lb/1000 gal
n -Hexane
No
AP -42
NA
SCC
4060132: Crude Oil: Submerged Loading (Normal Service)
Point
Process
Process Description
Pollutant /
CAS #
Fugitive
(YIN)
Emission Factor Source
Control
(%)
006
01
Fugitive VOC Leak
Emission
VOC
Yes
EPA -453/R-95-017, Table 2-4
NA
SCC
31000220: All Equip. Leak Fugitives (Valves, flanges, connections, seals, drains)
Section 14 — Miscellaneous Application Notes
AIRS Point
Operator originally requested this point to be a General Permit; however, having the general permit
emission limit of 39TPY for VOC would have made them a major source so operator requested that the
point be added to the facility -wide construction permit so actual, controlled emissions would be accounted
for instead of the general permit limit.
001
Produced Water Storage Tanks
State -Developed Emission factors in lb/1000 gal are:
County
Produced Water Tank Default
Emission Factors (lb/1000 gal)
VOC
Benzene
n -Hexane
Adams, Arapahoe, Boulder, Broomfield, Denver,
Douglas, Jefferson, Larimer and Weld
6.2381
0.1667
0.5238
The APEN states that the tanks contain less than 1% by volume crude oil on an annual average basis
which qualifies the source for the categorical exemption (Regulation 3, Part B, Section II.D.1.m).
However, this source will be permitted because if it was not contro led, the overall permitted VOC
emissions would be greater than 100 TPY and become a major facility. The operator has requested
synthetic minor status and accepted Federally enforceable controls, so this point will be included to
ensure synthetic minor eligibility.
AIRS Point
These tanks contain oil with an API gravity less than 40 degrees. EOG used E&P Tank to estimate the
flash emissions off this tank battery.
002
Crude Oil Tanks
From E&P Tank- uncontrolled ton/year= 9.7 TPY VOC
VOC=(8.4 TPY)*(2000Ib/ton)/(127,750 bbl/yr)= 0.1314 lb/bbl VOC or 3.129 lb/1000 gallons
Page 9
AIRS Point
003
Tornado Flare
The tornado flare is controlling gas coming off the well since there is no pipeline available in the area at
this time. EOG will continue to flare gas until a pipeline is available.
Emissions were calculated using VOC wt fraction.
(scf/hr)' (Ib/Ib-mol) * (% fraction from sales gas analysis) / (379.4 scf/lb-mol) = lb/hr * (hr/yr) / 2000 lb/T) =
TPY
Emission factors for NOx, CO, and PM10 came from AP -42, table 13.5-1
Emission factor for SOx also came from AP -42 and is based on 100% conversion of sulfur to SO2 at 2000
grains/MMscf
VOC E.F. = (1,526.8 TPY2000 lb/T) / (91.25 mmscf/yr) = 33,464.1 lb/MMscf
HAP's Emission Factors:
Benzene = (6844.5 Ib/yr) / 91.25 MMscf/yr = 75 lb/MMscf
Toluene = (5168.1 Ib/yr) / 91.25 MMscf/yr = 56.6 lb/MMscf
Ethylbenzene= (86839 Ib/yr) / 91.25 MMscf/yr= 9.52 lb/MMscf
Xylenes= (2146.6 Ib/yr) / 91.25 MMscf/yr = 23.5 lb/MMscf
Page 10
AIRS Point
004
Emergency Tank
Gas going to the flare would be routed to this tank in case of a flare outage. The gas is vented to
atmosphere from this tank. The APEN was submitted with worse -case scenario calculations. This
consists of 3 upset conditions in a 12 month period. Each instance of upset conditions was estimated to
be 12 hours in length.
Max gas vented to atmosphere= 12,458.3 scf/hr
Molecular wt. of gas= 27.5 lb/lb-mole
VOC fraction= 0.4606
379.4 scf/lb-mole
VOC= 12,458.3 scf/hr*( 27.5 lb/lb-mole)/(379.4 scf/Ib-mole)'0.4618= 416.6 lb/hr VOC
Using the 3 upset conditions at 12 hrs per condition:
416.6 lb/hr*(12 hr/event)' (3 events/yr) / (2,000lb/ton)= 7.5 tpy VOC
VOC E.F.: 7.5 ton/yr *( 2,000lb/ton)/(0.450 MMscf/yr)= 33,333.33 Ib/MMscf or 33,333 Ib/MMscf
AIRS Point
005
Truck Loadout of Crude Oil and Produced Water
AP -42: Chapter 5.2
Equation 1
L = 12.46*S*P*M/T
L = loading losses in lb per 1000 gallons loaded
S = Saturation Factor
P = true vapor pressure of liquid loaded [psia]
M = molecular weight of vapors [lb/lb-mole]
T = temperature of bulk liquid loaded [deg. R]
S 0.6 Submerged loading: dedicated normal service
P 5.18 psia
M 33.43 lb/lb-mole for gasoline with RVP = 11.5
T 523 deg. R (64 deg. F)
L 2.471b/10^3 gal
Annual requested Throughput 8431500ga1/yr
Annual requested VOC emissions 399561b/yr
10.4tpy
AIRS Point
006
Fugitive VOC emissions
A permit will be issued because the uncontrolled VOC emissions are greater than 2 TPY (APEN
threshold) and the total facility is greater than 5 TPY (permit threshold).
When reviewing calculations for a similar facility in non -attainment, another engineer working on these
sites noticed the fugitive emissions were calculated incorrectly. These errors triggered fugitives in
attainment facilities to be permit -required (increase from 1.5 TPY to 2.4 TPY). EOG submitted APENS
for the fugitive emissions on 2/14/12.
Page 11
Points 001-006: No monthly limits will be put in the permit even though this is a synthetic minor source.
After discussing this source with Chris Laplante 3-8-2011 it was decided that since production at an E&P
site is not steady enough to impose those kinds of limits. Compliance on a monthly limit may not be
possible, while a yearly limit could be.
Page 12
R1
.1'
01
CJ
u
SJ
O
`P
a
0
O
U
I-
O
U
w
a
0
ro
._a
W
U
H
0
z
cip
0
AIR POLLUT
0
0
d -
M
N
Emission Source AIRS ID:
unless APCD has already assigned a permit # & AIRS ID]
J
M
W
c 0
0.
ais
ti ❑
u a
I.
0 4 a)
,2 py ,,f w 0 O a
pL
.
o y^ .0 T Oi
as E .0 g
y d d C0.
A N W
€'iZ d d O O
a on P U
m 0 d w4!U
drI I L
L G L E. ❑ ❑
o. 0m
0
0 U E
d L 'j, y
Ua • I:,4, a
A
o 0 fl Q d on
T UI 9 F O .g
0 a
3 t �[yy
d
U al Q ta pa 0
O.
0 =c1.1 L 0
A N
v lac w U 0
d
0 0
o C) CO
a 0 90 C4 ❑ ❑
3 c, ® ❑
d
m
to
— {J>J
z ZT '
W
F=
o L 0
E
a9'
z
E
Section 01 —Administrative Information
rM1
'e
3
Ca
I
O
ok
`C ❑
N
m
o a c .° o
V (-)
o Pa
2 w N
EOG Resources, Inc.
Sec 24, T11N, R63W
Source Location: NW
600 17th Street, Suite 1000N
Denver, Colorado
emissions for end
Person To Contact:
303-262-9449
0
zx
Section 03 — General Information
2 z z
❑zzz
0 ) C)
NO El
0
en an
N
5 2
o 'E
aIn
w 0
U
3 v
P.
Q
v
C o
A
o S
o g 0
v
8° o o
a L 5
O . 4 0i v 1,-3vi •7 rc iy O 5
d 0. 3 3 c
0. Vy yy
O J O U 8 U tAJ
u ao o v a
w 0 is y o 0 . E 8y
d E Tid 0 z c
p-rZWAA AA
Cd
..
`o E
•P v.
zoo
91 pm d
ro 0
a
ca
0. a €n
A
N O U
d J
E 3 Ed
>` O a
v d F
C. d
3
o t.)
T O
w
y w o
0 q a
o d
q 0
a U
PSJEiLY ✓a ntin 0 n
MAY 3 201;„,;,:
N C O
APE) e e e a o
�iiGflcn' r+ en M o
O O O
vrce...� v 5
O a
w
Z
Pa
Pco < O
0
2 5 N
p 5 C O
ya v0
d
7 O o .> d
�` vM o Q
s �" 3 o y
o `0 o b
Ew m 8. !Tit c oC
E d.z a U� o U
. w d q d
yo Pa 0 Q �' O " o ,c
Q `. 'OD � Z
rJ. r.A U d o�
va L c A
_•p. `•" coo > �u W^,
al "O W = v o 5 E
ww Lw-et 20a w ¢0)
APEN forms:
he.state.co.us/
Application status: hIt
Section 04 — Tank Battery Informations
.0
0
ti
w
o v
L 7
0 0
za
a)
d
a
N
zzz
❑❑z
stat
r i O N i
O
zz❑ a m
a
0
O
oa o
t
m 0 p o
hCy
A p b o 8
co aq o 5 z .o
' -U LV A 0 a'
0 d OC
terM tl
0. d 9 to Y V
O d
P.b a a° t 2
E
0 -o ° 5 % w
0 37 q , til
.d O 5 . 0 O v
d m0. e'p `a o
4: -a, O; 0 & 0..?
k q d
C d q C
C 5 A C° 0 a v
1 m m w0 = c w°
y v d o 3 � o
O E-' a W w
a- d^ IA
O N 0 O
y N 5 E> o E
A `'' 'O
Et to
U T
A P T 'c
u♦
rnCD
qqv
k dt
0
123-9196—001-APEN-2011-05-31-01
FORM APCD-207
Alit, POLLUI'
0
Ca
C
C
;E
F
L
m
^O
v
0
O
a
U
C
O
U
Y-.
co,
O
U
.O
C
O
Y
U
a
a.
'01
U
F
O
z
z
O
a
O
z
a
0
QI
Emission Source AIRS ID:
Section 06 —Stack (Source, if no combustion) Location (Datum & either LatlLong or UTM)
Section 05 — Stack Information (Combustion stacks must be listed here)
w a
0E
m
42
LC ^ N 0
w IS
00
zap
N
m
cn
rn
a
O
Cab
O
H N O
N
In
O
0
CcO
.5
r
O • UC.
t.
0
O
0
U J
C
Section 07 — Control Device Information
O
O
O
a
0
H
O
O
O
U
O
0
0
cif
ki
O
0
CI
e
0
0
co)
00
B
O
0
0
C)
0 v
O
0
O ▪ O
U
CDPHE E.F
CDPHE E.F
P. O
0
�.c
ON
0
Emission Factor Documentation attached
T1
.0
.0
2
L
2
L
O
z
N
0
U
O
O
U
O
d
0
w
0
F
.n
r
W
0
X
C
0
0
0
u
0
w
e
0
0.
C
O.
O
E
4.
E
a
i
It
ce
b
C
0
0.
W
y
U
z
U
0..
u
It
Y
a
0
4-
-
U °
0
U (v'
-0 0
0 N 0.
v �
C
E:
°'
o
o
E 0 • 0
H • 'D
C O
O U
U
Td,
• 3
..C N
U
N ? N
g 3 E• b E
y o , O
o g
✓ • 5
0 y O .)
'•5" CC
d ❑
a _ o ❑
▪ w o
o�p
. o • p g 3
.Nb'
y 5 v
o. h
• Cto U
• C
y
o 0
- U Y
.774 o �yy
NN• p
.5 O .11
C
.0 2 _ U
Te
r
N `0
o�
U
WW 0 9 6 y
vy� O
z�
xf
9 C Y
O
D y N
a
DO
▪ ,-
3 a 4
U❑
▪ U
.3; EL• ) ❑
v N
0
A
� P
I I Q
6n
It
0
U
U,
nvironmental
EOG CC 20-24H FonnAPCD-207-Produced
N
0
N
N
P.
FORM AI'CD-207
Air Pollutant Emission Notice (APEN) — and —Application for Construction Permit
OIL AND GAS EXPLORATION AND PRODUCTION CRUDE OIL STORAGE TANK BATTERY
Current Status (Check all tha''/�apply)
AIRS ID #1: 1Z- 3 pi l G /mm z
Reason for APEN Submittal
(Check all that
only°
to existing source'
for coverage under
request for individual
for or Modification
permit amendment'
apply)
general permit no. GPOI
permit6:
■ APEN update
y New or previously unreported battery
GPO1
11"61839
• Modification
• Previously grandfathered battery'
■ Registration
• Synthetic minor facility
& cancellation
• Located in the 8 -hr Ozone Control Area3
F Application
of an individual permit
■ Registered under general permit no.
• Administrative
• Permitted under individual permit:
❑ Other:
For individual permit applications, check if you wants:
analysis conducted by the Division
of the permit prior to issuance
■ A copy of the preliminary
• To review a draft
Company Names: EOG Resources, Inc. OGCC Operator #: 27742
Mailing Address1°: 600 17`6 Street, Suite 1000N
david_long@eogresour
City: Denver State: CO Zip: 80202 E-mail: ces.com
Contact Name: David Long Phone: 303-262-9448 Fax: 303-262-9449
Tank Battery Name11: Critter Creek 20-24H
Number of tank, :
capacity [bbl]:
2011
6
Location)' (QQ Sec. Twp. Range.): NWNW Sec 24,T11N,R63W County: Weld Total tank
2,400 (400 ea)
Calendar year for which "Actual" data applies":
Control Description": Cimarron Smokeless
2011
Year(s) tank(s) were placed in service)":
combustion unit [VCU]) Control Efficiency":
Combustor (vapor
95%
Condensate Throughput12 [bbl/year] Requested":
Actual20:
Other.equipment at facility22: VCU, flare, heater
127,750 Maximum
for PTE calculation":
While Controls Operational'
emergency blow down
153,300
127,750
127,750
treater, line heater, produced H2O tank,
tank
Comments: Due to the low gravity of the oil, the tanks do not qualify for GPOI coverage. Therefore, an individual permit is being requested.
Estimated emissions at throughputs listed above. Use N/A for requested
throughput/ emission
Check if site -specific
Requested
Uncontrolled"
N/A
values unless
emission factors provided
Emissions"
Controlled"
N/A
requesting an individual
to calculate
Actual Emissions20
Uncontrolled26
8.4
permit
emissions".
Controlled"
0.4
• Check if the Division is to calculate emissions. 0
Emission Factor
Pollutant" [lb/bbl]
VOC [tons/year] 0.1314
Battery
PTE25
10.1
NOx [tons/year] N/A
0.03
0.03
0.03
CO [tons/year] N/A
0.16
0.16
0.16
Benzene [lbs/year]
108.0
5.4
n -Hexane [lbs/year]
726.0
36.3
Wells serviced by this tank or tank battery''
API #: 05-123-31939-00 Name: Critter Creek 20-24H
Well
Well
Well
Well
Well
_
Well :n
Well.,
0 Newly Reported
API #: Name:
■ Newly Reported
09,f2).)?)
API #: Name:
• Newly Reported
API #: Name: .-s 1 ,.' ❑ Newly Reported
API #: Name "'°��%''- .n5Y
■ Newly Reported
.
N
API #: Name: , , .,C 3 w
• Newly Reported
o U
API #: Name: E �. -,0
■ Newly Reported
The signature below indicates that I have knowledge of the facts herein set forth an .tithe same are true, accurate, and complete to the best of
my knowledge and belief. If this is a registration for coverage under general iit GP01, I further certify that this source is and will be operated
oomph e wieach condition of general permit GPOI. / c['
y, "�-b/ T7TY / )cfr i ( rir) S Zi
$Inature of Legally Authorized Person (not a vendor or c Itant) Date 1
David Long Division Environmental Manager e^''
Type or Print Name of Person Signing Above Official Title
Submit this form, along with $152.90 for each Colorado Department of Public Health and Environment For information call:
filing of up to 5 tank battery APENS. Include Air Pollution Control Division, APCD-SS-B1 25 Y 9 e 5 (303) 692-3150
$250 General Permit fee for each new GP 4300 Cherry Creek Drive South J �2
registration to: Denver, CO 80246-1530
FORM APCD-205
Page 1 of 2 EOG CC 20-24H FornAPCD-205-E&PCondensateTankAPEN.docx
0 C
w
O
U_
1-
0
z
z
0
CO
••
w
I
z
La
J
J
0
0 -
CO
I-
0
w
w
I-
0
z
E
0
y
w
C
a)
O.
E
O
U
C
O
a)
U
C
3
70
E
a)
t/)
•
O
Permit Number:
EOG Resources Inc.
Company Name:
N
0
N
CO
-o
0
N
County: Weld
NWNW Sec 24, T11N, R63W
Plant Location:
C)
O
J
a)
O
Person to Contact:
0)
C
N
tO
N
0
Fax Number:
David long@eogresources.com
E-mail Address:
Controlled Actual
Emissions (lbs/year)
N
V"Q M
'ct
LO
N
M
x -
Uncontrolled ual
Emissions (Ibs `ar)
In
Tr
CO
CG
r
to
t1)
tQ
It
T -
N
Emission
Factor Source
Gas Analysis
Gas Analysis
Gas Analysis
Emission Factor
(Include Units)
Wt. Fraction
Wt. Fraction
Wt. Fraction
Control Equipment /
Reduction (%)
00
CT)
Ch
95 %
Reporting
BIN
a
O
O
Chemical Name
Benzene
Toluene
Xylenes
Chemical
Abstract Service
(CAS) Number
71432
th
CO
CO
CO
0
1330207
Calendar Year for which Actual Data Applies:
N
0
N
0
a)
a)
0
C')
0)
0
0
a)
a)
0
0
Signature of Person Legally Authorized to Supply Data
Division Environmental Manager
C)
O
J
ca
O
ro
R
O
>
0
ca,.
(/)
0 •0
a)
N
0
a)
C)
a)
J
a)
0
a)
C
0.
to
a)
C)
CC
c)
a
0_
O.
0
a)
N
0
s
>
f6
O)
a)
J
0
a)
0
9-
0
G)
E
m.
z
Form Revision Date: December 4. 2006
•
M
6
ear -
Emission Source AIRS ID:
[Leave blank unless APCD has already assigned a permit # & MRS ID]
II WE 1839
Permit Number:
amr
R
Facility Equipment ID:
Section 02 — Re
Section 01 —Administrative Information
0
a
A ❑
0
E
G
W permit or newly reported emission source
Pa
O'
a a 4 ❑ ❑
.. ° c
V U,N
M
., 3
`° u :>,,:, o
O
b
ao O N
U U U0 N
U
z w
EOG Resources, Inc.
Critter Creek 20-2411
z z
g
a
E v°,
U
Sec 24, Ti1N, R63W
Source Location:
Request to limit RAPS with a Federally enforceable limit on PTE
ZIP Code: 80202
Denver, Colorado
Person To Contact:
Section 03 — General Information
For new or reconstructed sources, the projected startup date is:
a pipeline becomes available.
N
▪ 3
r th
0
° a o
V
.t.:> on o i U
co
-`o o b
A t L N p a
e a, c - ),T0 U
W`o q iq to u ^fa 2 .c
= o qc.o V E w•i
i
Qv4
dohe.state.co.us/
APEN forms: httu://
E
40
he. state. no. us/
a
Application status: Is
El
m
N
N
=
V c
9.
u E
o o 0
Z
meat Information & Material Use
facturine E
Section 04 — Processin
40' Flare Stack
ti o
NN L
• 0 a
0 0
C '0
a a
a a
va
O 0
a a
o O
U V
rncea
a• o
Check box to r
Check box to r
❑ ❑
FORM APCD-200
123-9196-003-APEN-2011-05-31-01
AIR POLLUTANT EMISSION NOTICE (APEN) & Application for Construction Permit— General
Emission Source AIRS ID:
Permit Number:
Section 05 — Emission Release Information (Attach a separate sheet with relevant information in the event of multiple releases; provide datum & either Lat/Long or UTM)
te-
en
O
CO
00
rei
en
a
e
N
It,
i4
ion Information
Moment & Fuel Consum
Section 06 — Combustion E
in
d
z
O
Company equipment Identifica
Clen
O
ter
O
m
1t
Y
Clen
N
N
A:
C
1,549 Btu/scf (my)
250,000 scf/day
L
TO
s
t
en
H
Section 07 -Emissions Inventory Information & Emission Control Information
U.
U
N
O
0
Ny
VOC wt fraction
AP42 qbl 13.5-1
N
O O'
(5-E,
N
en
b
N
N
^I
N
F
N
Do
0
a
o.
so
0
a
0
q E
CO T
w m
z=
We
`• .,
O"
55 L
Rb o o a
v
5
N
O
• 9
o
g • v
c
o `e
m E
U.
0
O
• W
CO
0 ._
E E
W
Q • O
o,
rq o'
5
c
5
O
Z
S
o c'n
S
5
y
r
0
a
a
=vr'
F
0.
Pt
O
In
O
z
U
O
O
U
c
CO
o
a It- o
CD-200-GeneralAP
EOG CC 20-24II Fl
w0
m
P.
N
AIR POLLUTANT EMISSION NOTICE (APEN) & Application for Construction Permit — General
Emission Source AIRS ID:
[Leave blank unless APCD has already assigned a permit 4 & AIRS ID]
Permit Number:
[Provide Facility Equipment ID to identify how this equipment is referenced within your organi
Facility Equipment ID:
uested Action (chec
Section 02 — Re
Section 01— Administrative Information
W permit or newly reported emission source
en
O o
U U
zN
EOG Resources, Inc.
Critter Creek 20-24H
z z
z z
g
O O
o
U
Change fuel or equipment
V N
O
O
U
, Sec 24, T11N, R63W
Source Location:
Transfer of ownership
Change permit limit
Request to limit HAPs with a Federally enforceable limit on PTE
Request APEN update only (check the box below that applies)
O
a
y
0
w
O
0
trzl 4L
c
Tra
O
U
O
0
0
Denver, Colorado
Person To Contact:
Section 03 — General Information
L
V
t
a
0
o W
b
0.4.1
42 y
O L
v
0
0.
O
'5 a
ea
4) L
o P3
ti 0
'C y
u V
U y
O
O
O U
0 V
c
b
E
c
'L
O O
a
b
VI G
O
U
U
T k
'OO
T
be
r m
L
o V
N E
u
m
v a
r
N e
O
o N F
TpW 4l
`',7; E
R(
O Q o O O.
OO
u 'O
o ca o a
O iL y of Y
UQv A W QvFIF
U
he.state.co.us/
APEN forms: http://wn
Application status: hap
o O
z
>'
3-=
uitnnent Information & Material Use
/Manufacturio
Section 04 — Processin
Serial No.: 29278
Model No.: EOG #4268
0.
7
448,500 scf/yr
en
V
o
UC C
N .0
N. A_
O.
O O
O O
c 'c
cU a
O.
AA
O
O O
a a
O O
X VI
Cro'
0
O O O
X x
O O
AO
A
A A
O U
0
0
T
C
0
aI
mO
00
E 12
t 534
9
c
O
E'O
0
E y
t/'
-0
L3
P
�i
d •
c
-E 5
.E
LOt 2.
o V O
V
o. 4)
x 4y
>
0
123-9196—004-APEN-2011-05-31-01
N
0
O
N
CL
Co
a)
kfD
b tl
FORM APCD-200
C)
O
❑
E
N
❑
O
u
7
O
U
w
❑
O
ci
QI
z
H
'z
H
Y�ll
I�1
L
Emission Source AIRS ID:
Permit Number:
0
0.0
O1
a
0
tn
CO
0.1
E'.
.0c
❑
0
0
11)
c
1,1
❑
0
co
❑
u
-45
CG
co
0
00
00
00
z
z
O
N
00
u
❑ Other (Describe):
Width (inches) =
m
c
00
O
U
o II
0 .0
O
~
r �
o
U
t
J ❑
❑ b
c
m
m
u
c �
U
U °
.0 q
m
C
0 C
W U
° 0
0
U 7
m R
c -5
Q W
Lion Information
ment & Fuel Consum
ci
Section 06— Combustion E
U
h
Manufacturer:
Company equipment Identification No.:
:N
w
0 ,
cis
.�O
h
❑
O
c
e
H
0
b
0
0
c
E
'41
❑
0
R
E
N
'❑i
0
v
C
rr
0
a
0
❑
0
u
4)
ti
VOC wt fraction
.,2
0-0
F
n Factor Documentation attached
oc
0 0
OF
o [q
5
v
0
e
O
ca
0
LL
Y
0
u
0
E
ci
E
0
0
u
9
9
m
W
C
Ca
a
C
O
a
ai
t
L
U
z
Q
cU)
d
0
y
W
U
O
O
U
c
Uo
o
O' o
ti
0
,c
h a
.0 6
U O.
3 0
w €
II
L N
.0GI
0
O
0 3
o
N
b
o=
'0
y
a E
3a
o €
0 d
P
g
a.
, true and correct.
o QIE
0
EOG CC 20-24H ET For
R
E O
w o
❑ a'
L 'fl N
i F WO
R 3
A Q Zf N O
m
d m
❑ P,
'o
U
❑
4-
❑
0
u
❑
O
R
E
td
Certification -
O
d
e
CT-
o u
L 4)
m o
I
^ 0
E >,
d
L 2 c
u
▪ E
❑ W
5 o 8 8
U 5
Q
o a
U „ ¢ .5
L o "5 v
PH
o w z.22
5
CF «
C 0
mewT
0
H Y C C
A. a .°n o
r
M
00
W
3
Permit Number:
Facility Equipment ID: Truck Loadout
a
U
4)
Y
7
Section 02 — Re
Section 01 —Administrative Information
.21
z
a
o • ❑
u 0
e s
c
3 V
u
c
71.41 Y
U
E.H
9 E
T. L
0 d ❑ ❑
a "
2 E
T
3 d
V
0
`0 z
E H
a Q
3 61
W
Z 0 > >
P
c4 c4
® ❑
EOG Resources, Inc.
r Creek 20-2411
'c
U
C
a
or
ii
❑ ❑
N
w
'0 Y1
O
3 N
LA.
, Sec 24, TI1N, R63W
Source Location:
Request to limit HAPs with a Federally enforceable limit on PTE
u
c
is
0
a
0
0
a
u
V
u
0
V
m
a
c
z
b
c
a
❑ ❑
d
0
U
fel
N
Denver, Colorado
❑ ❑
Person To Contact:
303-262-9449
C
z
w
Section 03 — General Information
For new or reconstruct
0
N
N
0
a
52 weeks/year
3
C -
4)
p.
_
CO
u
-u
at
6.
a
R
a+
c
M
R
a)
w
0
9
R
Y
4
.0
H
0 0
❑o❑❑❑
It' z z z z
< COy Vy
N J^
Y
cc I
'b
a O. �(1
0
o^^-
m m m
N N O
VJ
000
m m m
C • .0
W
I..
0 0
a
OU '5. pU
O >
Ain O (a N
y O j `i
o 0 6
U
cam o
o RE?
9 V .= L
i 0 A e C a w ro
6 Y ° < 0 i4 APo 0 i
dohestate.co.us/a
APEN forms: htto://
x
he.state.co.us/a
Application status: h
2 0 5
v
O p p
CO O y•
oE "'a
N o
5.
D:0
U.� U�
W :2
co o tai
I. N .a P-• N n
4) 0 5
-o N O F Cce; �y O p 'u
0 O v b 0
o 'O
0 m
o�v�e
ti d0C p da ,40.." _
pO v« N T pa p O r
C m 0 `a ) V o 0 0
Y C
'd 'O 0 y5 _ ,E O 2 u O 'VO
0 0 0 .. �` v .5 A A 0
om 5 Y V .5 E
C V.5 'v 2. .5 O p
O 0 W a, N w y o
p 0. 0 0 a o ta) E E m•
a Y
E m " c $
m p ' 0
W 0 0 n v o y y y a O
0 0 a, p J C4 Y '^ l
0 O ,0 0. 9 «1y- -J' p, 0
a p U o
u v a
Y g Y 0 as
oT T o a
Q 0 V
0 0
43ca
Y
N
.5
G'
E
2 0 0
m
aG 0°
L
O
A
e
a
Q
Z
ti
G1
0
W
.5
m
U
6
v
X
A
at this facility into:
m
a
rfl
b
pop .G Q a .)4
CO m
E 2
0.� o o d
r
e
.a 0
o 0
Va N @.) F
r. c4
a,
2
w
9
Cu
E '21
U.c v
CID
vi
m
0
V
a
0
N
a.
m
J
at
O
w
u
a'
4
dea eu
d a
as
5 5
0 0
a c
0 0
-Fre
tcP
c
o T
A-8
G
C .5 a
a
E .0
V
~
aN "
n 5
m
a H o
w
N
4 E
°d ?
>
0
v ,
0. v0
Y Y
xaa
FORM APCD-208
uid Loadin
drocarbon Li
AIR POLLUT
Permit Number:
O
0
1 aN
^^N
• 0
• U
u
0
7
.❑
E
u
w
V
4)
C
U
to
0
Section 05 — Stack Information (Combustion stacks must be listed here)
y
CIO
ni
0
m
n
0
z
N
vi
Section 07 — Control Device Information
Section 08 —Emissions Inventory Information & Emission Control Information
Data year for actual calendar year emissions below & throughput in Sec. 04 (e.g. 2007):
Emission Factor Documentation attached
c
e
E
0W
OL
o'.0
U H
ti''.
o
oz
0
0a
O
0
N
U
O
O
U
0
0
0
O
NV
an
0
0
rn
C
en
O
e
tn
H
N
V
F
N
O
N
H
O
ryll
C
L
'a
w
0
ON
N
0
0
0.
N
O
'OY
C
U
Y
L
4.4
' O
1
O
`° .5
U .4.
GL P.
O. y'
A
0
:q a
« o
3 t
-0 C
u
o L 0
9 E
w
Q .0 p
.i.:.<00:
.30 ❑ Q
o
co
N r R
Eo
m
c a b.. N.
a o '>
• Co
-'_ ❑ AZ
W • E 0
c o .C
o ,0
v o
ty 0
0
FOG CC 20-24H FomiAPCD-208-IlydrocarbonLiquidLoadingAPEN.doc
N
N
u
4
onent Leak Emissions
O
O
C
Facility Equipment ID: Fu
nested Action (Check applicable request boxes)
Section 02 — R
Section 01 —Administrative Information
E
u �
O 16
71' 0
O
3
O
Change company name
Transfer of ownership
L
o u ❑ ❑
a
a �
°1 C
C
0
O.
s9
a C
E
o C.
m m
C c
U
a. 7
c2
o a
E
Q C
W 3
D L
O
E
V O
_T L
A L
i Y
d
w `
r.
O
L
O
Pr n
g
a
. o
E z
_ w
s a
a a
C C P C'
3
, Sec 24, T1IN, R63W
Source Location:
CO
N
600 17th Street, Suite 1000N
O`
Q
to
Denver, Colorado
C
Revision to actual calenda
303-262-9946
Phone Number:
O
E-mail Address:
Section 03 — General Information
0
N
h
u
3
r
N
N
C
0
a
pc
O
O
`o
Ca
0
Fugitive emissions from valves, flang
0
O. ozr
•O
N
V
O
0
N
6
C
O
0.
U
a
v
-
O CO in
c m n
P P P ,O
b b b
cn an m O
O O O —
m r. L'
ps
W O
• p
C
L V E0 N
▪ N N
o E 0. - o Y
O S i J
3
O
.74
E r U m o U
Q D'a Q U _ n
ptt
o m V h L D o
r O U C C O y p
Li QOQ w° Qv�
APEN forms: httc://
Application statu
CC
0
C =
cn
ZE
C ct
C
'D
N
oc
O
O V
E-
D'
c 3
3
Information
O
et
Section 04 — Re
o 0 ^o 0
G1 5Q�
❑ ❑
z z
Is this equipment subject to NSPS 40 CFR Part 60, Subpart KKK?
Is this equipment subject to NESHAP 40 CFR Part 63, Subpart HH?
List any other NSPS or NESHAP Subpart that applies to this equipment
Section 05 — Stream Constituents
❑❑
n -Hexane
wt. %)
0o
n
o
a
Q
z
m
C
N
o
a
Xylene
(wt. %)
O
o
G
Z,
l0
O
o
o
'Cr
O
O
0
Ethylbenzene
(wt. %
Cl
o
0
ao0
z
O o
o
O
C
7M
auantoy
P
o
ozoo
0
Q
V1
N
o
Cl
O
C
% 7M
auazuag
en
r4
o
o
a
Q
z
N
ri
o
o
a
el
e
e
S
O •
3
O
o
-
Z
Cl
a
E
W
yi
m
os
c,
Heavy Oil (or Heavy Liquid)
I Light Oil (or Light Liquid)
I
O
'a
3
Check box to request copy of draft permit prior to issuance.
Check box to request copy of draft permit prior to public notice.
O
O
m
a
119 19 3 95
FORM APCD-203
123-9196-006-APEN--2012-02-14-01
onent Leak Emissions
AIR POLLUTANT EMISSION NOTICE (APEN) & Application for Construction Permit — Fu
Cl
Emission Source AIRS ID:
Permit Number:
& Control Information
Section 07 —Leak Detection & Re
Section 06 — Location Information (Provide Datum and either Lat/Long or UTM)
N ry
e
e
t -
co
tb
O
Section 08 — Emission Factor Information
0
O
al
O
C.
0I
Count'
4
24
Light Oil (or Light Liquid)
Units
e4
`.
ujl
iii
oI
v
ry
t-
ri
72
IR
Heavy Oil (or Heavy Liquid)
Units II
Count -I E.R.
U
C.
O
576
m
tT
56 I
Equipment Type
Connectors
Flanges
Open -Ended Lines
Pump Seals
u
Tz
Other
C5
Section 09 — Emissions Inventory Information & Emission Control Information
s
CO
Estimation Method
or
Emission Factor
Source
Tbl 2-4 1995 EPA
Protocol for
Equipment Leak
Emission
Estimates - See
Table C-8
Requested Permitted
Emissions'
Controlled
(Tons/Year)
L
4.5 lb/yr
252 lb/yr
c
T
a
?
L
T
V
V
h
N
r
Uncontrolled
(Tons/Year)
C
.:1
9
e
Actual Calendar Year Emissions
Controlled
(Tons/Year)
0
Uncontrolled
(Tons/Year)
`0
Om
0
E
C
0
to
Units
Identify in Section 08
Q
o
R
°
0
0
W
a
0
Uncontrolled Basis
F
W
C
o
a
C4
U
z
Control
Efficiency
(% Reduction)
Identify in Section 07
Q
U
Q
.O
..
cfiC
0
n
u
Control Device Description
T
4i
N
LI
o
to
Z`
E
..
Pollutant
VOC
0
n
P
0
F
a "_
51,
s
w
xT
t
tux
C
ed with this application is complete, true and correct.
by certify that all information contained herein and information submi
to
Curtis Rice
N
Name of Legally Authorized Person (Please print)
.0.
0
T
N
O
0
Q
T
Co
atu
CID
FOG CC 20-2411 FonnAPCD-203-FugitiveComponentLeaksAPHN doc
0
N
ct
Hello